Краткое содержание страницы № 1
Multi-Purpose Cooker
Product Guide
Model 11101706
Estimated Assembly Time: 15 minutes
IMPORTANT: Fill out the product record information below.
Serial Number
See rating label on unit for serial number.
Date Purchased
No tools required for assembly.
FOR OUTDOOR USE ONLY
CAUTION: WARNING:
Read and follow all warnings and instructions Failure to follow all manufacturer’s instructions
before assembling and using the appliance. could result in serious personal injury and/or
property damage.
INSTALL
Краткое содержание страницы № 2
TABLE OF CONTENTS DANGER Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 1. Never operate this appliance unattended. For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 2. Never operate this appliance within 10ft (3m) of Safety Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 any structure, combustible material or other gas cylinder. Food Safety . . . . . . . . . . . . . . . . . .
Краткое содержание страницы № 3
WARNING WARNING 1. Never leave the appliance unattended. Keep children and 14. Never drop food or accessories into hot cooking liquid. Lower pets away from the appliance at all times. food and accessories slowly into the cooking liquid in order to 2. The use of alcohol, prescription or non-prescription drugs prevent splashing or overflow. When removing food from the may impair the consumer’s ability to properly assemble or appliance care shall be taken to avoid burns from
Краткое содержание страницы № 4
Installation Safety Precautions WARNING • Use your appliance, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. Do not attempt to repair or alter the • The appliance installation must conform with local codes, or in hose/valve/regulator for any “assumed” defect. Any their absence of local codes, with the National Fuel Gas Code, modification to this assembly will void your warranty ANSI Z223.1/ NFPA 54 and Storage and Handling of Liquefied and create the
Краткое содержание страницы № 5
LP Cylinder Valve • A disconnected LP cylinder in storage or being transported CARE AND USE must have a safety cap installed (as shown). Do not store an LP cylinder in enclosed spaces such as a carport, garage, porch, covered DANGER Safety patio or other building. Never leave an LP cylinder Cap inside a vehicle which may become overheated • NEVER store a spare LP cylinder under or near the Retainer Strap by the sun. appliance or in an enclosed area. • Do not store an LP cylinder in an area where
Краткое содержание страницы № 6
e s i w k LP Cylinder Exchange Connecting Regulator to the LP Cylinder • Many retailers that sell this appliance offer you the option of 1. LP cylinder must be properly secured onto appliance. (Refer to replacing your empty LP cylinder through an exchange service. assembly section.) Use only those reputable exchange companies that inspect, 2. Turn all control knobs to the OFF position. precision fill, test and certify their cylinders. Exchange your cylinder only for an OPD safety feature-equ
Краткое содержание страницы № 7
Straight Leak Testing Valves, Hose and Regulator 1. Turn control knob clockwise to closed position. 2. Be sure regulator is tightly connected to LP cylinder. 3. Completely open LP cylinder valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. Correct before proceeding. 4. Brush soapy solution onto areas circled below. Hold coupling nut and regulator as shown for proper connection to LP cylinder valve. 6. T
Краткое содержание страницы № 8
10 ft. Safety Tips WARNING • Before opening LP cylinder valve, check the coupling nut for tightness. For Safe Use of Your appliance and to Avoid Serious • When this appliance is not in use, turn off control knob and LP cylinder valve. Injury: • If you notice grease or other hot material dripping from • This appliance will be hot during and after use. Use appliance onto valve, hose or regulator, turn off gas supply at insulated oven mitts or gloves and long-handled once. Determine the caus
Краткое содержание страницы № 9
Lighting Instructions: Burner Flame Check • Do not lean over appliance while lighting. • Light burner. Turn control knob from OPEN to CLOSED. The • Read all instructions before lighting. Flame height should decrease and then go out. Always check 1. Turn the control knobs clockwise until fully tightened in flame prior to each use. If only low flame is seen refer to CLOSED position "Sudden drop or low flame" in the Troubleshooting Section. 2. Turn on gas cylinder 3. Place lit match next
Краткое содержание страницы № 10
Cleaning the Burner Assembly CAUTION Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting appliance. 1. Close gas control knobs and LP cylinder knob and SPIDER ALERT! disengage regulator from cylinder. 2. Remove 2 screws (one from each side) connecting control panel to burner assembly. SPIDER AND WEBS INSIDE BURNER 3. Remove control panel with valve assembly from appliance. 4. Clean inside of burner venturi using a garden hose. 5. Reinstal
Краткое содержание страницы № 11
LIMITED WARRANTY This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*. The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid by the consumer for re
Краткое содержание страницы № 12
Key Qty Description PARTS LIST - EXPLODED VIEW A 1 BURNER B 1 WINDSHIELD C 3 LEG To order warranty or replacement parts contact D 3 FOOT Char-Broil at 1-800-241-7548 or www.charbroil.com. E 3 BRACE, F/ LEG F 1 CONTROL PANEL G 1 HOSE/VALVE/REGULATOR H 2 CONTROL KNOB I 1 PAN, COOKING J 1 THERMOMETER Not Shown: … 1 HARDWARE PACK … 1 INSTRUCTION MANUAL, ENGLISH … 1 INSTRUCTION MANUAL, SPANISH J I F A C H B G E D Page 12
Краткое содержание страницы № 13
ASSEMBLY STEP 1 First choose a suitable location to assemble your Multi-Purpose Cooker. We recommend that you assemble the unit on a piece of carpet or other non-abrasive surface to prevent scratching the appliance. To begin - place the Burner Assembly upside down in the work area. Insert the Leg Assemblies over the tabs on the Burner Assembly as shown below. Be sure the angle of the Leg Assemblies face outward as shown. Be sure that the tabs of the Windshield are fully inserted into the Leg
Краткое содержание страницы № 14
ASSEMBLY STEP 2 Next - install the three Leg Braces by aligning them together with the tab on one of the legs. Secure the Leg Braces with one Wing Screw and one Wing Nut per Leg Assembly. Tighten securely. Leg Brace (X 3) Wing Screw (X 3) Wing Nut (X 3) Page 14
Краткое содержание страницы № 15
ASSEMBLY STEP 3 Carefully turn the Multi-Purpose Cooker over onto its Legs. Place the Cooking Pan onto the Cooking Pan Supports as shown. Cooking Pan Cooking Pan Supports WARNING NEVER USE THIS APPLIANCE AS A TURKEY FRYER! Use as a turkey fryer may result in a hazardous situation causing property damage, personal injury, or loss of life. Page 15
Краткое содержание страницы № 16
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Possible Cause Prevention/Solution Gas leaking from • Damaged hose. • Turn off gas at LP cylinder or at source on natural gas systems. If cracked/cut/burned hose is cut or cracked, replace valve/hose/regulator. See LP hose. Cylinder Leak Test and Connecting Regulator to the LP Cylinder. Gas leaking from LP • Mechanical failure due to rusting or • Replace LP cylinder. cylind
Краткое содержание страницы № 17
Troubleshooting (continued) Problem Possible Cause Prevention/Solution Sudden drop in gas • Out of gas. • Check for gas in LP cylinder. flow or low flame. • Excess flow valve on regulator tripped. • Turn off control knob, wait 30 seconds and light appliance. If flames are still low, turn off knob and LP cylinder valve. Disconnect regulator. Reconnect regulator and leak-test. Turn on LP cylinder valve, wait 30 seconds and then light appliance. • Vapor lock at coupling nut/LP cylinder • Turn o
Краткое содержание страницы № 18
Notes Page 18
Краткое содержание страницы № 19
REGTEMP REV00 Page 19
Краткое содержание страницы № 20
