Краткое содержание страницы № 1
Owner’s Manual
Assembly, Operation, Use and Care
®
MODEL 06401314
THIS GRILL IS FOR OUTDOOR USE ONLY .
INSTALLER/ASSEMBLER: Leave these instructions with
DANGER
consumer.
CONSUMER: Keep this manual for future reference.
If you smell gas:
WARNING
1. Shut off gas to the appliance.
This manual contains important information necessary
2. Extinguish any open flame.
for the proper assembly and safe use of the appliance.
3. Open lid.
4. If odor continues, keep away from the appliance
Read and follow
Краткое содержание страницы № 2
Safety Symbols CAUTION The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the • Keep the fuel supply hose away from any heated manual. surfaces. • For residential use only. Not intended for commercial use. DANGER • Do not leave appliance unattended. Keep children and DANGER: Indicates an imminently hazardous pets away from appliance at all times. situation which, if not avoided, will result in death or serious injury
Краткое содержание страницы № 3
Table of Contents Limited Warranty For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Grill Service Center. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Safety Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Table of Content
Краткое содержание страницы № 4
Use and Care LP (Liquefied Petroleum Gas) WARNING • Is nontoxic, odorless and colorless when produced. For Your Safety, LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. For Safe Use of Your Grill and to Avoid Serious • LP gas is highly flammable and may ignite unexpectedly Injury: when mixed with air. • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn (i.e. Propane Cylinder Use (1 lb. Disposable) gasolin
Краткое содержание страницы № 5
CAUTION DANGER If ignition does NOT occur in 5 seconds, turn the • NEVER store a spare cylinder under or near the burner controls OFF, wait 5 minutes and repeat the appliance or in an enclosed area. lighting procedure. If the burner does not ignite with • Never fill a cylinder beyond 80% full. the valve open, gas will continue to flow out of the • An overfilled or improperly stored cyclinder is a hazard burner and could accidently ignite with risk of injury. due to possible gas release from the
Краткое содержание страницы № 6
CAUTION CAUTION • Putting out grease fires by closing the lid is not NATURAL HAZARD • SPIDERS possible. Grills are well ventilated for safety FACT: Sometimes spiders and other small insects climb reasons. into the burner tubes attached to the burners. The • Do not use water on a grease fire. Personal injury spiders spin webs, build nests and lay eggs. The may result. If a grease fire develops, turn knobs webs or nests can be very small, but they and LP cylinder off. are very strong and can bloc
Краткое содержание страницы № 7
Storing Your Grill How To Tell If Meat Is Grilled Thoroughly • Clean cooking surface and grease container. •Meat and poultry cooked on a grill often browns very fast on the • When LP cylinder is connected to grill, store outdoors in well- outside. Use a meat thermometer to be sure food has reached ventilated space and out of reach of children. a safe internal temperature, and cut into food to check for • Cover grill if stored outdoors. visual signs of doneness. • Store grill indoors ONLY if LP c
Краткое содержание страницы № 8
PARTS LIST CALL OUT PART QUANTITY DESCRIPTION LETTER NUMBER A 55710316 LOGO PLATE, THERMOS, GRILL-2-GO 1 B 80008883 LID ASSEMBLY 1 C 80008857 HANDLE LIGHT ASSEMBLY 1 D 55710317 LID HANDLE 1 E 55710318 COOKING GRATE, SET OF 2 1 F 80008892 VAPORIZER BAR 2 G 55710310 BURNER, TUBULAR, STAINLESS 2 H 80008862 BOTTOM CASTING 1 I 80001812 MATCH HOLDER AND CHAIN ASSEMBLY 1 J 55710314 VALVE / MANIFOLD ASSEMBLY 1 K 80008868 HEAT SHIELD, CONTROL PANEL 1 L 80008855 LEFT SIDE SHELF ASSEMBLY 1 M 80008854 RIGH
Краткое содержание страницы № 9
PARTS DIAGRAM A B C D E F G W H I J K L M N O O P Q R Q S T U V U Note: Some grill parts shown in assembly steps may differ slightly in appearance from those on your particular grill model, However the method of assembly remains the same. 06401314 • 9
Краткое содержание страницы № 10
ASSEMBLY 1) Lay bottom casting assembly upright on level ground. Best to place on top of protective mat or cardboard to reduce scratching. 1 2) Insert each leg assembly onto bottom casting assembly. Assure cutouts on leg pivot engages over threaded tabs on bottom casting assembly. 3) Attach each leg assembly using (2) #10-24x3” screws. Leg Threaded Tabs Assemblies #10-24x3” Screws #10 x 3” Screw Qty: 4 Bottom Casting Assembly 1) Open legs and set grill upright standing on legs. Note: Le
Краткое содержание страницы № 11
1) Attach handle to grill lid using (4) #10-24 x 3/8” screws. 3 Use ONLY hand driven screwdriver. Do not over tighten Handle #10-24 x 3/8” Screw Qty: 4 #10-24 x 3/8” Screw Grill Lid 1) Attach grill lid to grill bottom using (2) hitch pins and (2) cotter pins. 4 Grill Lid Hinge Pin Cotter Pin Hitch Pin Qty: 2 Cotter Pin Qty: 2 Grill Bottom 06401314 • 11
Краткое содержание страницы № 12
1) Remove (2) battery covers from handle light by loosening (2) screws. 2) Insert (4) AA batteries (NOT INCLUDED), 2 per battery compartment as indicated on 5 handle light. 3) Replace covers and secure screws that were loosened earlier. AA Batteries Handle Light Battery Cover 1) Insert hook end on handle light into right side of handle, push down on other side to lock 6 handle light in place. 2) To remove handle light, slide release button on left side of handle light. pull handle light
Краткое содержание страницы № 13
1) Attach (2) control knobs and (1) rotary ignition knob by aligning holes with control panel as shown. 7 2) Remove (4) clear protectors from shelf supports. Clear Protectors Control Knob Qty: 2 Rotary Ignitor Knob Control Knob Control Knob Qty: 1 Rotary Ignitor Control Knob Knob Rotary Ignitor Knob Control Knob 1) Open grill lid, unfold side shelves. 8 2) Remove (2) cooking grates from grill. 3) Install (2) vaporizer bars by inserting round end of vaporizer bar inside front hole of grill.
Краткое содержание страницы № 14
1) Close grill lid. 2) Insert hose regulator support wires into holes provided in end of left side-shelf. 9 3) Remove yellow cap from gas inlet located bottom rear side of grill. 4) Bring hose connector to the rear of grill. 5) Pull back outer ring of hose connector and push connector onto back of gas inlet. Release outer ring. Ring should connect and lock hose in place. NOTE: Perform leak test as described in Care & Use section before operation. Hose Regulator Support Wires Remove Yello
Краткое содержание страницы № 15
STORING & TRANSPORTING NOTE: Allow grill to cool down to room temperature before handling. 1) Remove regulator hose assembly. 2) Fold side shelves into bottom casting, and close lid. 3) Fold both legs inward towards center underneath bottom casting. 4) Using match holder located at rear of grill, secure legs together by inserting loop ends of match holder over leg notch located on each leg. Legs fold Inward Match Holder Leg Notches 06401314 • 15
Краткое содержание страницы № 16
Troubleshooting EMERGENCIES: Emergencies Possible Cause Prevention/Solution Gas leaking from • Damaged hose. • Turn off gas at source. Replace damaged valve/hose/regulator. cracked/cut/burned See Leak Test and Connecting Regulator To The LP Cylinder. hose. Gas leaking from LP • Mechanical failure due to rusting or • Replace LP cylinder. cylinder. mishandling. Gas leaking from LP • Failure of cylinder valve from • Turn off gas valves. Return LP cylinder to gas supplier. cylinder valve. mishandlin
Краткое содержание страницы № 17
Troubleshooting (continued) Problem Prevention/Solution Possible Cause ROTARY IGNITION: Burner(s) will not light • Rotary knob rotates without clicking. • Replace knob. using ignitor. • Sparking between ignitor and electrode. • Inspect wire insulation and proper connection. Replace wires if insulation is broken. • See “GAS ISSUES:” on previous page. Burner(s) will not • Match will not reach. • Use paper match, long-stem match (fireplace match) or match match light. holder (where supplied). • Imp
Краткое содержание страницы № 18
Limited Warranty Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid, by the consumer, for review and examination. 90 Days LIMITED warranty Upon consumer supplying proof
Краткое содержание страницы № 19
Please register your grill online at: WWW.GRILLREGISTRATION.COM (If you register online, you do not need to send in this registration card.) 06401314 • 19
Краткое содержание страницы № 20
STOP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-232-3398 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling Safety Checklist Read and understand owners manual.Check tubes for spider webs. Ensure valves are correctly installed in burner tubes. Always ensure control knobs are in OFF position and regulator is attached to tank BEFORE opening tank valve to avoid low
