Краткое содержание страницы № 1
GP Series Portable Generator
MODEL: 005789-0
Owner’s
Manual
• SAFETY
• ASSEMBLY
• OPERATION
• TROUBLESHOOTING
• WARRANTY
AUTHORIZED DEALER SUPPORT:
www.generac.com
or
1-888-GENERAC
Краткое содержание страницы № 2
Table of Contents Portable Generator System Introduction ............................................................. 1 Section 3 – Maintenance ........................................ 9 3.1 Maintenance Schedule ...................................................9 3.2 Product Specifications ....................................................9 Read this Manual Thoroughly ................................. 1 3.2.1 Generator Specifications .....................................9 3.2.2 Engine Spec
Краткое содержание страницы № 3
The operator is responsible for proper and safe use INTRODUCTION of the equipment. We strongly recommend that the Thank you for purchasing this model by Generac Power Systems, operator read this manual and thoroughly understand Inc. This model is a compact, high performance, air-cooled, all instructions before using the equipment. engine driven generator designed to supply electrical power to We also strongly recommend instructing other users operate electrical loads on job sites, or remo
Краткое содержание страницы № 4
IMPORTANT SAFETY INSTRUCTIONS Portable Generator System SAVE THESE INSTRUCTIONS – The manufacturer suggests that these rules for safe operation be copied and posted near the unit's installation site. Safety should be stressed to all operators and potential operators of this equipment. Study these SAFETY RULES carefully before installing, operating or servicing this equipment. Become familiar with this manual and with the unit. The generator can operate safely, Do not overfill the fuel
Краткое содержание страницы № 5
IMPORTANT SAFETY INSTRUCTIONS Portable Generator System • Adequate, unobstructed flow of cooling and ventilating air FIRE HAZARDS is critical to correct generator operation. Do not alter the installation or permit even partial blockage of ventilation • For fire safety, the generator must be operated and maintained provisions, as this can seriously affect safe operation of the properly. Operation must always comply with applicable codes, generator. The generator MUST be operated outdoor
Краткое содержание страницы № 6
Section 1 – General Information Portable Generator System Figure 1 – Wheel Assembly 1.1 UNPACKING • Remove all packaging material. • Remove separate accessory box. • Remove the generator from carton. 1.1.1 ACCESSORY BOX Check all contents. If any parts are missing or damaged, locate an authorized dealer at 1-888-436-3722. • 1 - Owner’s Manual • 1- Oil SAE 30 • 2- 7” Wheels • 1- Handle Assembly • 1- Handle Bracket • 1- Wheel Axle • 1- Hardware Bag (containing the following): 2 - Rubber bumpers 7
Краткое содержание страницы № 7
Section 2 – Operation Portable Generator System 4. Choke Knob – Used when starting a cold engine. Figure 5 - Generator Controls 5. Fuel Tank – Tank holds 4 U.S. gallons of fuel. 6. Grounding Lug – Ground the generator to an approved earth 7 ground here. See "Grounding the Generator" for details. 7. On/OFF Switch – Controls the operation of the generator. 8. Muffler – Quiets the engine. 9. Handle – Pivot and retract for storage. 10. Gas Cap – Fuel fill location. 11. Fuel Gauge – Shows fuel level
Краткое содержание страницы № 8
Section 2 – Operation Portable Generator System Figure 7 - Grounding the Generator 2.2 CORD SETS AND CONNECTION PLUGS 2.2.1 120 VAC, 20 AMP, DUPLEX RECEPTACLE This is a 120 Volt outlet protected against overload by a 13.5 Amp push-to-reset circuit breaker (Figure 6). 13.5 Amps of current may be drawn from each socket, however, total power drawn must be kept within data plate ratings. Use only high quality, well insulated, 3-wire grounded cord sets rated for 125 Volts at 20 Amps (or greater)
Краткое содержание страницы № 9
Section 2 – Operation Portable Generator System NOTE: 2.6 BEFORE STARTING THE GENERATOR All figures are approximate. See data label on appliance for Prior to operating the generator, engine oil and gasoline will need wattage requirements. to be added, as follows: 2.5 WATTAGE REFERENCE GUIDE Device . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Running Watts 2.6.1 ADDING ENGINE OIL *Air Conditioner (12,000 Btu) . . . . . . . . . . . . . . . . . . . . . . . . . . 1700 A
Краткое содержание страницы № 10
Section 2 – Operation Portable Generator System • To start engine, firmly grasp the recoil handle and pull slowly until increased resistance is felt. Pull rapidly up and away. • 1/2-CHOKE When engine starts, move choke lever to position Do not overfill the fuel tank. Always leave room until engine runs smoothly and then fully into RUN position. If for fuel expansion. If the fuel tank is overfilled, engine falters, move choke back out to 1/2-CHOKE position fuel can overflow onto a HOT e
Краткое содержание страницы № 11
Section 3 — Maintenance Portable Generator System 3.2.2 ENGINE SPECIFICATIONS 2.8 STOPPING THE ENGINE • Shut off all loads, then unplug the electrical loads from generator Displacement .............................................................................. 208 cc panel receptacles. Never start or stop the engine with electrical Spark Plug Type ................... F6TC, NGK BPR4ES or Champion RN14YC devices plugged in and turned on. Spark Plug Gap .............................0.028-0.031 i
Краткое содержание страницы № 12
Section 3 — Maintenance Portable Generator System Use the following instructions to change the oil while the engine 3.3.2 TO CLEAN THE GENERATOR is still warm: • Use a damp cloth to wipe exterior surfaces clean. • Clean area around oil drain plug. • A soft, bristle brush may be used to loosen caked on dirt, oil, • Remove oil drain plug from engine and oil fill plug to drain oil etc. completely into a suitable container. • A vacuum cleaner may be used to pick up loose dirt and • When oil has
Краткое содержание страницы № 13
Section 3 — Maintenance Portable Generator System NOTE: 3.7 LONG TERM STORAGE To order a new air filter, please contact the nearest authorized It is important to prevent gum deposits from forming in essential service center at 1-888-436-3722. fuel system parts such as the carburetor, fuel hose or tank during storage. Also, experience indicates that alcohol-blended fuels (called gasohol, ethanol or methanol) can attract moisture, which Figure 13 - Air Filter leads to separation and formation
Краткое содержание страницы № 14
Section 4 — Troubleshooting Portable Generator System 4.1 TROUBLESHOOTING GUIDE PROBLEM CAUSE CORRECTION Engine is running, but no AC output 1. Circuit breaker is open. 1. Reset circuit breaker. is available. 2. Poor connection or defective cord set. 2. Check and repair. 3. Connected device is bad. 3. Connect another device that is in good condition. 4. Fault in generator. 4. Contact Authorized Service Facility. Engine runs good but bogs down 1. Short circuit in a connected load. 1. Di
Краткое содержание страницы № 15
Section 5 — Notes 13
Краткое содержание страницы № 16
Section 6 — Warranty Portable Generator System FEDERAL EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The United States Environmental Protection Agency (EPA) and Generac Power Systems, Inc. (Generac) are pleased to explain the Emission Control System warranty on your new 2008 and later equipment. New equipment that use small spark-ignited engines must be designed, built, and equipped to meet stringent anti-smog standards for the federal government. Generac will warran
Краткое содержание страницы № 17
Section 6 — Warranty Portable Generator System EMISSION CONTROL SYSTEM WARRANTY Emission Control System Warranty (ECS warranty) for equipment using small spark-ignited engines: (a) Applicability: This warranty shall apply to equipment that uses small off-road engines. The ECS Warranty period shall begin on the date the new equipment is purchased by/delivered to its original, end-use purchaser/owner and shall continue for 24 consecutive months thereafter. (b) General Emissions Warranty Covera
Краткое содержание страницы № 18
Section 6 — Warranty Portable Generator System GENERAC POWER SYSTEMS “TWO YEAR” LIMITED WARRANTY FOR GP SERIES PORTABLE GENERATORS For a period of two years from the date of original sale, Generac Power Systems, Inc. (Generac) warrants its GP Series generators will be free from defects in materials and workmanship for the items and period set forth below. Generac will, at its option, repair or replace any part which, upon examination, inspection and testing by Generac or a Generac Authorized W
Краткое содержание страницы № 19
Serie GP Generador portátil MODELO: 005789-0 Manual del propietario • SEGURIDAD • MONTAJE • OPERACIÓN • RESOLUCIÓN DE PROBLEMAS • GARANTÍA GARANTÍA LIMITADA 2 AÑOS ASISTENCIA DE CONCESIONARIOS AUTORIZADOS: www.generac.com o 1-888-GENERAC 17
Краткое содержание страницы № 20
Índice Sistema de generador portátil Introducción .......................................................... 19 Sección 3 – Mantenimiento .................................. 27 3.1 Programa de mantenimiento ........................................27 Lea este manual completamente .......................... 19 3.2 Especificaciones del producto ......................................27 Reglas de seguridad ............................................. 20 3.2.1 Especificaciones del generador ........
