Краткое содержание страницы № 1
OFF
LO HI
MED
PROPANE CONSTRUCTION
TM CONVECTION HEATER
OWNER’S MANUAL
For more information, visit www.desatech.com
For more information, visit www.desatech.com
Variable
40,000, 60,000 and
80,000 Btu/Hr Models
IMPORTANT: Read and understand this manual before assembling, starting, or servicing
heater. Improper use of heater can cause serious injury. Keep this manual for future reference.
GENERAL HAZARD WARNING:
FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS
HEATER, C
Краткое содержание страницы № 2
SAFETY INFORMATION 2 SAFETY INFORMATION WARNINGS ANSI/NFPA 58 and the Natural Gas Installation Code, CAN/ CGA B149.2. This instructs on the safe storage and handling of WARNING: This product contains and/or generates propane gases. chemicals known to the State of California to cause • This product has been approved for use in the Commonwealth cancer or birth defects, or other reproductive harm. of Massachusetts. • Use only propane gas set up for vapor withdrawal. • Provide adequate ventilation
Краткое содержание страницы № 3
OFF LO HI MED PRODUCT IDENTIFICATION 3 UNPACKING 3 THEORY OF OPERATION PROPANE SUPPLY VENTILATION PRODUCT IDENTIFICATION PROPANE SUPPLY You must provide propane gas and propane tank(s). Top Use this heater only with a propane vapor withdrawal supply system. See Chapter 5 of the Standard for Storage and Handling of Liquefied Petroleum Gas, ANSI/NFPA 58 and/or CAN/CGA B149.2. Shell Your local library or fire department will have this booklet. This heater will operate with a 20-pound propane tank.
Краткое содержание страницы № 4
OFF HI LO MED OFF LO HI MED OFF LO HI MED INSTALLATION 4 OPERATION To Start Heater INSTALLATION WARNING: Review and understand the warnings Valve Inlet in the Safety Information section, page 2. They are needed to safely operate this heater. Follow all local codes when using this heater. Hose WARNING: Test all gas piping and connections for leaks after installation or servicing. Never use an open flame to check for a leak. Apply a mixture of Figure 3 - Hose and Valve Inlet liquid soap and wate
Краткое содержание страницы № 5
OPERATION 5 5 To Start Heater (Cont.) Flame Patterns To Stop Heater To Restart Heater STORAGE OPERATION Continued 7. After ignition, hold control knob down for about 30 seconds. This activates the automatic control system. 8. When burner remains lit, set heater at the desired heat level by slightly depressing the control knob and turning it counterclock- wise to the MED or HIGH settings (see Figure 4, page 4). 9. If burner goes out, turn off gas. Slightly depress and turn con- trol knob fully cl
Краткое содержание страницы № 6
MAINTENANCE SPECIFICATIONS 6 REPLACEMENT PARTS MAINTENANCE REPLACEMENT PARTS WARNING: Use only original replacement parts. WARNING: Never attempt to service heater while This heater must use design-specific parts. Do not it is connected to propane supply, operating, or hot. substitute or use generic parts. Improper replace- Severe burns can occur. ment parts could cause serious or fatal injuries. This will also protect your warranty coverage for parts 1. Keep heater clean. replaced under warra
Краткое содержание страницы № 7
TROUBLESHOOTING 7 7 ACCESSORIES TROUBLESHOOTING WARNING: Never attempt to service heater while it is connected to propane supply, operating, or hot. Severe burns can occur. Note: For additional help, visit DESA International’s technical service website at www.desatech.com. SYMPTOM POSSIBLE CAUSE REMEDY Burner fails to light 1. Propane supply valve closed on propane 1. Open propane supply valve slowly tank(s) 2. Excess flow check valve closed 2. Close propane supply valve on propane tank and reo
Краткое содержание страницы № 8
OFF LO HI MED ILLUSTRATED PARTS BREAKDOWN 8 Models TC80V and RCP80V ILLUSTRATED PARTS BREAKDOWN MODELS TC80V RCP80V 1 3 9 8 5 7 4 11 12 2 6 10 For more information, visit www.desatech.com For more information, visit www.desatech.com 103385-01F
Краткое содержание страницы № 9
PARTS LIST 9 9 Models TC80V and RCP80V PARTS LIST MODELS TC80V RCP80V This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 6 of this manual. KEY PART NO. NO. DESCRIPTION QTY. 1 103928-01 Top and Shell Assembly 1 2 103929-01 Burner Assembly 1 3 103904-01 Ignitor Electrode 1 4 103032-01 Nozzle 1 5 103031-01 Base 1 6 103036-01 Control Knob 1 7 102445-01 Piezo Ignitor Kit 1 8 099236-01 Thermocouple Kit 1 9 10385
Краткое содержание страницы № 10
10 NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ ___________
Краткое содержание страницы № 11
11 11 OWNER'S REGISTRATION FORM Complete registration form and mail or complete on-line registration at www.desatech.com within 30 days after purchase. Brand: (Reddy Heater, Master, Remington, etc.) Model: (R60, HD15, etc.) Date Purchased: Note: Keep receipt for warranty verification. Serial Number: 7 or 9 digit number located on product or identification tag. First Name: Last N
Краткое содержание страницы № 12
Postage Required TM 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 TAPE TAPE
Краткое содержание страницы № 13
OTHER OUTDOOR HEATING PRODUCTS PROPANE/LP FORCED AIR HEATERS PROPANE/LP CONVECTION HEATERS PORTABLE KEROSENE/DIESEL FORCED AIR HEATERS PROPANE/LP TANK TOP HEATERS PROPANE/LP AND NATURAL GAS GARAGE HEATERS PROPANE/LP PROPANE/LP AND NATURAL PATIO HEATERS GAS CHIMENEAS klsuiejlb oeklhi kokle ,,;log;e ;;pdl;lklsuiejlb oe ;e ;;pdl;lklsuiejlb oeklhi kokle ,,;log;e ;;pdl;l WARNING klsuiejlb oeklhi kokle ,,;log;e ;;pdl;l klsuiejlb oeklhi kokle ,,;log;e ;;pdl ;l klsuiejlb oeklhi kokle ,,;log;e ;;p
Краткое содержание страницы № 14
14 WARRANTY AND REPAIR SERVICE KEEP THIS WARRANTY LIMITED WARRANTY DESA International warrants this product and any parts thereof, to be free from defects in materials and workmanship for one (1) year from the date of first purchase when operated and maintained in accordance with instructions. This warranty is extended only to the original retail purchaser, when proof of purchase is provided. This warranty covers only the cost of parts and labor required to restore the product to proper operatin
