Руководство по эксплуатации HP (Hewlett-Packard) HP51640

Краткое содержание страницы № 1

Hewlett-Packard Disposable Cartridge
Maintenance Manual
(Applicable to the Following Cartridges: HP51626A, HP51638A,
HP51633M, HPC6117A, HP51640(A,C,M,Y), HP51641A, HPC6105A,
HPC1823A, HPC6116A, HP51645A, HPC6104A, HPC6168A,
HPC6169A, and HPC6170A.)

Rev :X3 11/11/99

Краткое содержание страницы № 2

Contents 1. INTRODUCTION ....................................................................................................... 3 1.1. TIJ Background .........................................................................................................3 2. PEN CARE................................................................................................................. 4 2.

Краткое содержание страницы № 3

1. INTRODUCTION This document acts as a guide for the maintenance and care of Hewlett-Packard disposable print cartidge products including the HP51626A, HP51638A, HP51633M, HPC6117A, HP51640(A,C,M,Y), HP51641A, HPC6105A, HPC1823A, HPC6116A, HP51645A, HPC6168A, HPC6169A, HPC6170A, and HPC6104A. Each pen consists of a printhead and a pressurized ink source. 1.1 Backgroun

Краткое содержание страницы № 4

2. PRINT CARTRIDGE CARE 2.1 Set-up Once the cartridge is out of the box it can be easily snapped into the carriage. It is TIP important to remove the tape from the printhead before the cartridge is snapped into place. The cartridge will not function with the tape still in place. 2.2 Storage Short-term storage is defined as less than 2 days or less than 1 day in a hot and

Краткое содержание страницы № 5

3. PRINTHEAD AND INTERCONNECT CARE 3.1 Inserting and Removing the Print Cartridge The print cartridge should stay in the carriage at all times except when the operator is ? Replacing it ? Cleaning it ? Storing it The print cartridge should never be: ? Shaken Watch Out! ? Dropped ? Hit against the palm of one’s hand or any other hard surface (e.g. a table) Shaki

Краткое содержание страницы № 6

Never use the following to wipe the printhead: ? Industrial paper towels (These cloths usually contain a high recycle content and are abrasive.) Watch Out! ? Toilet paper (These cloths are usually not fiberless.) ? Sponge (Particles from the sponge can be left behind on the nozzle plate.) The cloth must be soft so that it does not scratch the printhead. It should be fiberless

Краткое содержание страницы № 7

Figure 2: Direction of Wiping for the HP51645A, the HPC6104A, the HP51641A, the HPC6105A, the HPC1823A, the HPC6116A, the HPC6168A, the HPC6169A, and the HPC6170A. The direction of the wipe should especially be monitored on the tri-color pens such as the HP51641A, the HPC6105A, the HPC1823A, and the HPC6116A. The cartridge can be ruined due to color mixing if the top plate is not

Краткое содержание страницы № 8

Figure 4: Direction of Wiping for the HP51640(A,C,M,Y) In all three wiping configurations the printhead should be pointing down while it is being wiped. This position will prevent the nozzles from pulling little bubbles into the firing chambers. Applying heavy pressure is not necessary to clean the particles off of the printhead. A large pressure can actually cause particles to s

Краткое содержание страницы № 9

- When the cartridge is removed from the carriage, it is important to hold the cartridge by the black side covers of the cartridge. TIP - The print cartridge should never be shaken, dropped, or hit against a hand or any hard surface. - Never use industrial paper towels, toilet paper or sponge to wipe the printhead. Watch Out! - The interc

Краткое содержание страницы № 10

4. PEN FAILURE ANALYSIS 4.1 Trouble Shooting Guide There are several things that can be done to recover damaged cartridges. The following list acts to troubleshoot any problems that may appear. Problem Example Action ? Check to make sure the Cartridge will not print tape is off of the “Sheet is blank even after it printhead has gone underneath ? Re-insert the cartr

Краткое содержание страницы № 11

Black streaks around ? Wet wipe the cartridge text or streaks the same (There is ink buildup.) color of the ink in the cartridge 5. SUPPLIES ORDERING INFORMATION 5.1 The following process will work for ordering the suggested TexWipes. The company TexWipe only sells their products through distributors, but partners/customers can contact TexWipe directl

Краткое содержание страницы № 12

If outside of the US -- Call the TexWipe International Customer Service and Technical Support Line at 1-201-327-9100 (ext 325 or 254). The TexWipe customer service representative will then determine a local distributor for the TexWipe Products. The International Customer Service Representatives can also be reached at intercs@texwipe.com. TexWipe does distribute products all over