Краткое содержание страницы № 1
Ovens
FL-2340
Rev. 5 (7/08) Page 1 of 14
5925 Heisley Road • Mentor, OH 44060-1833
INSTALLATION, OPERATION and MAINTENANCE
MANUAL for Cres Cor
RADIANT OVENS
1000-CH-SS-SPLIT
1000-CH-SS
1000-CH-AL-SPLIT
1000-CH-AL
Models: 1000-CH SERIES
Cabinet model number:
Cabinet serial number:
Authorized Service Agency:
Ph: Fax:
Keep this manual for future reference.
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Краткое содержание страницы № 2
Ovens FL-2340 Rev. 5 (7/08) Page 2 of 14 5925 Heisley Road • Mentor, OH 44060-1833 TABLE OF CONTENTS SUBJECT PAGE INSTALLATION INSTRUCTIONS ...................................................................................... 3, 4 OPERATING INSTRUCTIONS ............................................................................................ 5 Illustration, Control Panel ............................................................................................ 5 MAINTENANCE IN
Краткое содержание страницы № 3
Ovens FL-2340 Rev. 5 (7/08) Page 3 of 14 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION INSTRUCTIONS VENTING YOUR OVEN: 3. Most jurisdictions consider our low-temperature 1. The purpose of ventilating hoods is to direct and ovens (maximum temperature is 350°F/177°C) as capture smoke, grease-laden vapors, heat, odors, or low-heat appliances not requiring vent hoods. fumes. 4. Installation must conform with local codes. The 2. Low temperature equipment (maximum authority having juri
Краткое содержание страницы № 4
Ovens FL-2340 Rev. 5 (7/08) Page 4 of 14 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION INSTRUCTIONS (continued) HOW TO INSTALL CABINETS: 1. Remove all packing material from the inside and all vinyl from the outside of oven. 2. Place the oven in a well ventilated area on level fl oor. Clearance requirements: 3” (76mm) at the back, 2” (51mm) at the top, 1” (25mm) at both sides. 3. Install the pan slide racks on the sidewalls, if necessary. DRIP TRAY 4. Slide drip pan(s) onto the bottom
Краткое содержание страницы № 5
Ovens FL-2340 Rev. 5 (7/08) Page 5 of 14 5925 Heisley Road • Mentor, OH 44060-1833 OPERATING INSTRUCTIONS Thermostat Timer “Hold” Power Thermostat Switch Thermometer “Cook” Green Yellow Light Light FOR FIRST-TIME OPERATION ONLY: HOW TO START UNIT A new oven needs to “burn off” factory oils and glue before (after fi rst-time operation): it’s fi rst use. Do NOT load food into oven until this has Push POWER switch “ON”. been done! NOTE: For HOLD or COOK mode, preheat unit to desired 1. Push switc
Краткое содержание страницы № 6
Ovens FL-2340 Rev. 5 (7/08) Page 6 of 14 5925 Heisley Road • Mentor, OH 44060-1833 HOW TO CLEAN THE UNIT: WARNING Cleaning Hints: BEFORE cleaning the cabinet: 1. Use the mildest cleaning procedure that will do the job. 1. Unplug cord from wall. Allow cabinet to cool. 2. Always rub in the direction of polish lines to avoid 2. Do NOT hose cabinet with water. scratching the surface. 3. Do NOT get water on controls. 3. Use only a soft cloth, sponge, fi brous brushes, plastic or 4. Do NOT use ab
Краткое содержание страницы № 7
Ovens FL-2340 Rev. 5 (7/08) Page 7 of 14 5925 Heisley Road • Mentor, OH 44060-1833 MAINTENANCE INSTRUCTIONS TROUBLE-SHOOTING GUIDE WARNING IF UNIT GETS TOO HOT OR WON’T SHUT OFF, DISCONNECT POWER AT BRANCH PANEL. DO NOT UNPLUG CORD! If hot unit is NOT working, fi rst check the following causes: 1. Cord is unplugged from wall outlet. 3. Switch(es) are turned off. 2. Circuit breaker/fuse to wall outlet is blown. 4. Thermostat(s) are turned off, or are set too low. PROBLEM POSSIBLE CAUSE SOLUTION
Краткое содержание страницы № 8
Ovens FL-2340 Rev. 5 (7/08) Page 8 of 14 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS Include all information on nameplate when ordering parts 3 9 10 1 6 5 2 ITEM DESCRIPTION CMP Part No. 4 1. Switch (On/Off) 0808-113-01-K 2. Knob, Thermostat & Timer 0595-061 7 3. Timer 0849-009-K 4. Thermometer 5238-031 FRONT CONTROL PANEL 8 5. Thermostat, Cook 0848-082 Upper & Lower Ovens 6. Thermostat, Hold 0848-083 7. Pilot Light, Yellow 0766-096 ITEM DESCRIPTION CMP Part No. 8. Pilot Light,
Краткое содержание страницы № 9
Ovens FL-2340 Rev. 5 (7/08) Page 9 of 14 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS Include all information on nameplate when ordering parts 16 15 12 14 28 11 13 27 Insulation 25 Model 1000-CH-SS is shown. Model 1000-CH-SPLIT is 17 half-size single door oven. 26 21 18 19 20 29 23 22 24 Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Краткое содержание страницы № 10
Ovens FL-2340 Rev. 5 (7/08) Page 10 of 14 5925 Heisley Road • Mentor, OH 44060-1833 Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com L15-20P 6000 WATT L1 X Y G L2 G L1 Z L2 6-30P SINGLE 6000 WATT PHASE L3 L1 L2 208 (1) JUMPER 240 (2) JUMPER'S AS SHOWN AS SHOWN SERVICE SWITCH VENT VENT 3 PHASE CLOSED 208 V FAN FAN 3 WIRE 64 69 1 2 1 2 18 62 68 TERMINAL BLOCK FUSE FUSE 1 2 3 4 1 2 3 4 3 A 3 A 66 118 63 5 6 7 8 127 10 128 9 5 6 7 8 TB2 65 67 119 Upper Oven P12
Краткое содержание страницы № 11
Ovens FL-2340 Rev. 5 (7/08) Page 11 of 14 5925 Heisley Road • Mentor, OH 44060-1833 WIRING DIAGRAM FOR 1000CH SERIES, Control Panel Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com Upper control panel P4 119 120121122 17 16 16 12 47 11 P3 Upper Power Fan Thermostat 42 43 44 45 38 45 Switch Switch Hold 47 50 Timer 17 40 41 46 11 Relay A 38 43 42 OUT L2 39 12 39 41 40 46 51 M A G L1 48 49 Thermostat 44 51 48 Roast 50 49 18 18 18 18 20 20 20 20 14 14 14 14 P2 19 19
Краткое содержание страницы № 12
Ovens FL-2340 Rev. 5 (7/08) Page 12 of 14 5925 Heisley Road • Mentor, OH 44060-1833 WIRING DIAGRAM FOR 1000CH-SPLIT SERIES Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com SINGLE PHASE JUMPERS AS 6-20P SHOWN 3000 WATTS 208/240 VOLT 2 1 3 4 SWITCH 66 69 65 64 93 VENT 61 VENT CONTACTOR 92 93 94 94 102 FAN 65 FAN 101 92 95 95 60 91 1 61 L1 T1 100 91 96 96 121 64 2 90 90 97 97 103 HI LIMIT 66 119 L2 T2 89 89 98 98 104 60 3 88 88 99 99 105 69 L3 T3 122 118 59 59
Краткое содержание страницы № 13
Ovens FL-2340 Rev. 5 (7/08) Page 13 of 14 5925 Heisley Road • Mentor, OH 44060-1833 HOW TO REVERSE DOOR OPENING Models: 1000-CH Radiant Ovens HOW TO REVERSE THE DOOR HINGE 1. Pop off hinge covers with screwdriver. STRIKE PLATE 2. Remove the screws from the hinges to the cabinet; remove the door and unscrew the latch strike from the oven. Keep all screws. DOOR 3. Rotate the door 180° so that the hinges are now on the left side of the door. 4. Re-mount the hinges in the same hole pattern on the
Краткое содержание страницы № 14
Ovens FL-2340 Rev. 5 (7/08) Page 14 of 14 5925 Heisley Road • Mentor, OH 44060-1833 NOTES: Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
