Краткое содержание страницы № 1
70R21HV
Owner’s Manual
532 19 99-80 Rev. 1 05.11.06 BY Printed in U.S.A.
Краткое содержание страницы № 2
SAFETY RULES Safe Operation Practices for Walk-Behind Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. � Stop the blade(s) when crossing gravel drives, walks, Look for this symbol to point out im- or roads. por tant safety precautions. It means � Stop the engine (motor) whenever you leave the equip- CAUTION!!! BE COME ALERT!!! YOUR men
Краткое содержание страницы № 3
� Never refuel the machine indoors. wire away from plug to prevent accidental starting. � Never store the machine or fuel container where there � Keep nuts and bolts, especially blade attachement is an open fl ame, spark or pilot light such as a water bolts, tight and keep equipment in good condition. heater or on other appliances. � Never tamper with safety devices. Check their proper � Never fi ll containers inside a vehicle, on a truck or trailer operation regularly. bed with
Краткое содержание страницы № 4
ASSEMBLY Read these instructions and this man u al in its entirety before you attempt to assemble or operate your new lawn mow er. OPERATOR MOWING PRESENCE PO SI TION IMPORTANT: THIS LAWN MOWER IS SHIPPED WITH- CONTROL OUT OIL OR GASOLINE IN THE ENGINE. BAR Your new lawn mower has been as sem bled at the factory LIFT with the ex cep tion of those parts left unassembled for ship- UP ping purposes. All parts such as nuts, washers, bolts, etc., necessary to com plete the as sem bly have be
Краткое содержание страницы № 5
OPERATION KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your mower or in literature supplied with it. Learn and understand their meaning. OPERATOR PRESENCE CON TROL BAR STARTER HANDLE DRIVE CONTROL LEVER DRIVE COVER HANDLE EN GINE OIL CAP KNOB WIT
Краткое содержание страницы № 6
OPERATION The operation of any lawn mower can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your lawn mower or performing any adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask over spectacles. 2. Turn nut on underside of drive control to increase drive HOW TO USE YOUR LAWN MOWER speed. ENGINE SPEED 3. Operate mower to test drive speed. Readjust a
Краткое содержание страницы № 7
OPERATION � Secure rear of discharge chute to lawn mower housing � Mower is now ready for side discharging operation. with knob. � To convert to mulching operation, side dis charge de- � Place rear handle of grass catcher on the crossbar of fl ector must be removed and mulcher door secured to the lawn mower's lower handle as shown. mower housing with knob. � Lift the round door of the discharge chute and place � To convert to rear bagging operation, side discharge the grass ca
Краткое содержание страницы № 8
OPERATION TO EMPTY GRASS CATCHER (See Figs. 8 –9) BEFORE STARTING ENGINE 1. Open round door of discharge chute to move starter ADD OIL (See Fig. 10) rope out and away from grass catcher. Your lawnmower is shipped without oil in the engine. For type and grade of oil to use, see “EN GINE” in the Maintenance section of this manual. FRONT OPEN HANDLE CAUTION: DO NOT overfi ll engine with oil, or it will smoke heavily from ROUND DOOR the muffl er on startup. 1. Be sure lawnmower is level.
Краткое содержание страницы № 9
OPERATION � For extremely heavy cutting, reduce the width of cut ADD GASOLINE (See Fig. 10) by overlapping previously cut path and mow slowly. � Fill fuel tank to bottom of tank fi ller neck. Do not over- � For better grass bagging and most cutting conditions, fi ll. Use fresh, clean, regular unleaded gasoline with the engine speed should be set in the fast position. a minimum of 87 octane. Do not mix oil with gasoline. Purchase fuel in quan ti ties that can be used within 30 �
Краткое содержание страницы № 10
MAINTENANCE BEFORE AFTER EVERY EVERY EVERY BEFORE EACH EACH 10 25 HOURS 100 STORAGE USE USE HOURS OR SEASON HOURS Check for Loose Fasteners Clean / Inspect Grass Catcher * Check Tires Check Drive Wheels *** Clean Lawn Mower **** Clean under Drive Cover *** Check Drive Belt / Pulleys *** Check / Sharpen / Replace Blade Lubrication Clean and Recharge Battery ** Check Engine Oil level Change Engine Oil Clean Air Filter Inspect Muffler Replace Spark Plug Replace Air Filter Paper Cartridge Empty fuel
Краткое содержание страницы № 11
MAINTENANCE LAWN MOWER BLADE Always observe safety rules when performing any main- BLADE ADAPT ER te nance. TRAILING TIRES EDGE � Keep tires free of gasoline, oil, or insect control chem- i cals which can harm rubber. � Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage. HARDENED WASHER DRIVE WHEELS Check rear drive wheels each time be fore you mow to be sure they move freely. LOCK WASHER BLADE BOLT The wheels not turning freely means trash, g
Краткое содержание страницы № 12
MAINTENANCE Change the oil after every 25 hours of operation or at least CAUTION: Pe tro leum solvents, such as once a year if the lawn mower is not used for 25 hours in ker o sene, are not to be used to clean one year. car tridge. They may cause de te ri o ra tion Check the crankcase oil level before starting the engine of the cartridge. Do not oil car tridge. and after each fi ve (5) hours of continuous use. Tighten oil Do not use pres sur ized air to clean or plug securely each time
Краткое содержание страницы № 13
SERVICE AND ADJUSTMENTS CAUTION: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: 1. Release control bar and stop engine. 2. Make sure the blade and all moving parts have completely stopped. 3. Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. 4. Pivot idler arm assembly to slacken drive belt, then LAWN MOWER remove drive belt from drive pulley, belt keepers and TO ADJUST CUTTING HEIGHT idler arm. See “TO ADJUST
Краткое содержание страницы № 14
SERVICE AND ADJUSTMENTS 2. Route the other end of the new drive belt through hole in housing. KNOB 3. Reattach debris shield to housing with screw previ- BOLT ously removed. Be sure tab of debris shield is in gap of housing. LOW 4. Position blade on the blade adapter aligning the two (2) holes in the blade with the raised lugs on the HANDLE HIGH adapter. BRACKET 5. Be sure the trailing edge of blade (opposite sharp edge) is up toward the engine as shown (See Fig. 17). 6. Install
Краткое содержание страницы № 15
STORAGE HANDLE (See Figs. 20 and 21) ENGINE You can fold your lawn mower handle for storage. FUEL SYSTEM 1. Loosen the two (2) handle knobs on sides of the upper IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS handle and allow handle to fold down to the rear. SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR 2. Remove the two (2) handle knobs and carriage bolts TANK DURING STORAGE. ALCOHOL BLENDED FUELS on sides of the lower handle and pivot
Краткое содержание страницы № 16
TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Does not start 1. Dirty air fi lter. 1. Clean/replace air fi lter. 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Empty f
Краткое содержание страницы № 17
ROTARY LAWN MOWER - - MODEL NUMBER 70R21HV (96143001400) - PRODUCT NUMBER 961 43 00-14 GEAR CASE ASSEMBLY - - PART NUMBER 532 18 82-94 KEY PART NO. NO. DESCRIPTION 1 532 18 75-30 Case, Lower 2 532 19 12-45 Case, Upper 3 532 18 75-32 Gear, 24 Teeth 4 532 19 12-46 Shaft, Worm 5 532 18 35-05 Wireform 6 532 18 35-06 Bearing, Ball 7 532 18 35-08 Seal, Output Shaft 8 532 18 35-09 Washer 9 532 18
Краткое содержание страницы № 18
18 ROTARY LAWN MOWER - - MODEL NUMBER 70R21HV (96143001400) - PRODUCT NUMBER 961 43 00-14
Краткое содержание страницы № 19
19 ROTARY LAWN MOWER - - MODEL NUMBER 70R21HV (96143001400) - PRODUCT NUMBER 961 43 00-14 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 532 19 05-82 Handle, Grassbag, Rear 31 532 18 34-78 Spring, Door, Discharge Chute 2 532 06 53-22 Hairpin Cotter 32 532 18 34-45 Rod, Door, Discharge Chute 3 532 18 34-83 Rod, Rear Handle, Grassbag 33 532 19 05-78 Discharge Chute, Plastic 4 532
Краткое содержание страницы № 20
20 ROTARY LAWN MOWER - - MODEL NUMBER 70R21HV (96143001400) - PRODUCT NUMBER 961 43 00-14
