Краткое содержание страницы № 1
™
RAM SERIES
™
BLACK BEAR ZTR®
®
ZTR
Safety Instructions
and
Operator’s Manual
RAM 44, BS/968999551 RAM MAG 50, KAW /968999561
RAM 50, BS/968999552 RAM 50 MAG, HON/968999562
RAM MAG 44, HON/968999559 RAM 50 MAG KOH/968999563
RAM MAG 44, KOH/968999560
Краткое содержание страницы № 2
2
Краткое содержание страницы № 3
IMPORTANT - READ CAREFULLY The Dixon® ZTR® mower is both easy and fun to operate. However, any power mower must be operated properly to be safe. It is not a toy or a recreational vehicle. Before you start to use the mower, read this Operator’s Manual carefully. It contains valuable information that is necessary for the safe operation of the machine. Observe all safety rules and become completely familiar with the controls. The information contained in this manual applies to all Dixon Ram Series™
Краткое содержание страницы № 4
4
Краткое содержание страницы № 5
TABLE OF CONTENTS GENERAL OPERATION.................................................................. 8-9 SLOPE OPERATION .................................................... 10-11 FIRE HAZARDS ............................................................ 12-13 CHILDREN, BYSTANDERS AND PETS ............................ 14 SERVICE ............................................................................ 15 SPECIFICATIONS ....................................................................... 12
Краткое содержание страницы № 6
SAFETY RIDING LAWN MOWERS, IF IMPROPERLY OPERATED, CAN CAUSE SERIOUS INJURY ! OR DEATH Pictured below are the most common causes of injury to the operator or bystander. Please read and understand this manual to prevent injuries. Blade Contact Tip Over Run Over Back Over 6
Краткое содержание страницы № 7
SAFETY Safety Alert Symbol ! When you see this symbol, BE ALERT to the potential for injury. Follow the recommended safety precautions and safe operating practices. DANGER (highlighted in red) indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING (highlighted in orange) indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. CAUTION (highlighted in yellow) indicates a potentially
Краткое содержание страницы № 8
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. GENERAL OPERATION Read, understand, and follow all instructions in this manual and on the mower before starting. Only allow responsible adults, who are familiar with the instructions, to operate the mower. Clear the area of objects such as rocks, toys, wire, etc., that could be picked up and thrown by the blade. Be sure the area is clear of bystanders before mowing. Stop mower if anyone ente
Краткое содержание страницы № 9
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. GENERAL OPERATION (continued) Turn off blades when not mowing. Injury could occur from contact with moving parts. Under no circumstances should you place hands or feet under the mower deck or in the chute while blades or impeller are still running. To avoid personal injury from accidental clutch engagement, stop engine before removing grass catcher or unclogging chute. Mow only in daylight o
Краткое содержание страницы № 10
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. SLOPE OPERATION Slopes are a major factor related to loss-of-control and tip-over accidents, which can result in severe injury or death. All slopes require extra caution. If you feel unsure on any slope, do not mow it! DO Mow across the slope with your Dixon ZTR — never up or down. This will decrease the risk of tip-over. Remove obstacles such as rocks, tree limbs, wires and other foreign ob
Краткое содержание страницы № 11
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. SLOPE OPERATION (continued) DO NOT Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible. Rapid uphill turns may cause tip-over. Do not mow near drop-offs, ditches, or embankments. Unstable ground may cause loss of control. Do not mow on wet grass. Reduced traction could cause sliding. Do not try to stabilize the mower by putting your foot on the g
Краткое содержание страницы № 12
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. FIRE HAZARDS Use extra care when handling gasoline and other fuels. They are flammable and vapors are explosive. Store all fuel in approved containers specifically designed for that purpose. Allow engine to cool before refueling. Never remove fuel cap or add fuel with engine running. Do not smoke while refueling or operating the mower. To reduce fire hazard, keep mower free of grass, leaves
Краткое содержание страницы № 13
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. FIRE HAZARDS (continued) To prevent fire or explosion, keep sparks and open flames away from battery. Keep electrical connections clean and tight. Inspect them often. Loose connections and corrosion increase fire risk. Before disconnecting the negative ground cable, make sure all switches are off. This decreases the chance of sparking and fire. Use care when backing to avoid pushing the gras
Краткое содержание страницы № 14
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. CHILDREN, BYSTANDERS AND PETS Tragic accidents can occur if the operator is not alert to the presence of children, bystanders and pets. Children are attracted to lawn mowers and the mowing activity. NEVER assume children, bystanders and pets will stay where they were last seen. Be alert to avoid accidents. Keep bystanders and pets out of the mowing area and keep children under the watchful c
Краткое содержание страницы № 15
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. SERVICE Never run a mower inside a closed area or without proper ventilation. Keep nuts and bolts tight, especially blade attachment bolts, and keep equipment in good condition. Never tamper with safety devices. Check their proper operation regularly. Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting. Never make adjustments or repairs with the en
Краткое содержание страницы № 16
® ® DIXON ZTR COMMERCIAL / RESIDENTIAL WARRANTY POLICY RAM 44, RAM 50, RAM 44 MAG™ & RAM 50 MAG™ DIXON® WARRANTS ITS ZTR® MOWERS AGAINST DEFECTS IN MATERIAL AND WORKMANSHIP FOR THE PERIODS SET FORTH BELOW. THE SOLE REMEDY UNDER THIS WARRANTY IS REPLACEMENT OR REPAIR OF PARTS INCLUDING LABOR COSTS. THIS WARRANTY IS SUBJECT TO THE FOLLOWING CONDITIONS AND LIMITATIONS: 1. COMMERCIAL WARRANTY (use other than, or in addition to, mowing at owner’s primary place of residence): a. One Year - 100% parts
Краткое содержание страницы № 17
SPECIFICATIONS RAM SERIES™ 44 Model 968999551 Chassis: 1½" square tube side frame Mower Deck: Made of 11 gauge fabricated welded construction with external reinforcement ribs. Three blades combine for a 42" (107cm) cut width. Cut height approximately 1½" (38mm) to 4½" (114 mm). Blade Drive: Electric clutch Drive System: Each rear wheel is independently driven by a Hydro Gear hydrostatic drive ZT2800 7" cooling fan. Engine: 26 HP Briggs & Stratton, twin cylinder, overhead valve, air cooled, gasol
Краткое содержание страницы № 18
SPECIFICATIONS RAM SERIES™ 50 Model 968999552 Chassis: 1½" square tube side frame Mower Deck: Made of 11 gauge fabricated welded construction with external reinforcement ribs. Three blades combine for a 48" (122cm) cut width. Cut height approximately 1½" (38mm) to 4" (114 mm). Blade Drive: Electric clutch Drive System: Each rear wheel is independently driven by a Hydro Gear ZT2800 hydrostatic drive 7" cooling fan. Engine: 26 HP Briggs and Stratton engine, overhead valve, air cooled, gasoline, fu
Краткое содержание страницы № 19
SPECIFICATIONS RAM MAG SERIES™ 44 Model 968999559 1½" square tube side frame Chassis: Made of 11 gauge fabricated welded construction Mower Deck: with external reinforcement ribs. Three blades combine for a 42" (107cm) cut width. Cut height approximately 1½" (38mm) to 4" (114 mm). Electric clutch Blade Drive: Each rear wheel is independently driven by a Drive System: Hydro Gear ZT2800 hydrostatic drive with integral charge pump and 7" cooling fan. 20 HP Honda engine, overhead valve, air cooled,
Краткое содержание страницы № 20
SPECIFICATIONS RAM MAG SERIES™ 44 Model 968999560 Chassis: 1½" square tube side frame Mower Deck: Made of 11 gauge fabricated welded construction with external reinforcement ribs. Three blades combine for a 42" (107cm) cut width. Cut height approximately 1½" (38mm) to 4" (114 mm). Blade Drive: Electric clutch Drive System: Each rear wheel is independently driven by a Hydro Gear ZT2800 hydrostatic drive with integral charge pump and 7" cooling fan. Engine: 20 HP Kohler engine, overhead valve, air
