Краткое содержание страницы № 1
GAS GRILL
Built-In LP Gas Grill Installation Guide
Tank Enclosure Installation - Pg 25
™
S-460
™
S-660
#43267
YOU MUST READ THIS OWNER’S GUIDE
WARNING: Follow all leak-check procedures
BEFORE OPERATING YOUR GAS GRILL carefully in this manual prior to barbecue
operation. Do this even if the barbecue was
dealer-assembled.
DANGER
If you smell gas:
NOTICE TO INSTALLER: These instructions
1. Shut off gas to the appliance.
must be left with the owner and the owner
2. Extinguish any open fl
Краткое содержание страницы № 2
2 WARNINGS Keep any electrical supply cord and the fuel supply hose DANGER away from any heated surfaces. Failure to follow the Dangers, Warnings and Cautions ® Do not use this Weber tank enclosure kit unless all parts are contained in this Owner’s Manual may result in serious bodily in place. The unit must be properly assembled according injury or death, or in a fire or an explosion causing damage to to the instructions outlined in the “Assembly Instruction” property. section of th
Краткое содержание страницы № 3
3 BUILT-IN CUTOUT DIMENSIONS BUILT-IN STRUCTURE CUTOUT DIMENSIONS BUILT-IN CUTOUT DIMENSIONS 3 ALL DIMENSIONS ARE TO FINISHED SURFACES. S-460™ S-660™ TOLERANCES WARNING: All countertop finished surfaces must be 1 1 1 1 1 30 / ˝ (768.35 mm) 38 / ˝ (971.55 mm) + / ˝ - / ˝ (6.35mm) constructed of a noncombustible material. 4 4 4 4 3 3 1 1 2 34 / ˝ (873.13 mm) 34 / ˝ (873.13 mm) + / ˝ - / ˝ (6.35mm) 8 8 4 4 1 1 3 23˝ (584.2 mm) 23˝ (584.2 mm) + / ˝ - / ˝ (6.35mm) 4 4 GENERAL CONSTRUCTION
Краткое содержание страницы № 4
4 PARTS LIST ™ S-460 Lid - 1 Left Door - 1 Cookbox - 1 Right Door - 1 Warming Rack - 1 OR ™ S-660 Lid - 1 Right Enclosure Panel - 1 Cookbox - 1 Left Enclosure Panel - 1 Front Frame Rail - 1 Front Vent Panel - 1 Rear Frame Rail - 1 Rear Panel Assembly - 1 Rear Vent - 1 Bottom Shelf - 1 Corrugated Gas Line - 1 ® WWW.WEBER.COM
Краткое содержание страницы № 5
5 PARTS LIST ® Flavorizer Bars Smoker - 1 5 ™ - 8 S-460 ™ - 12 S-660 Stainless Steel Cooking Grates Smoker Bar - 1 ™ S-460 - 2 ™ - 3 S-660 1/2 inch Bolts (¼-20 x 1/2 inch Bolt) - 10 Collection Tray - 1 Nylon Washer - 10 Catch-Pan Holder - 1 Hinge Pin - 2 Catch-Pan - 1 Hair Pin Cotter - 2 Disposable Drip Pans - 2 #10-32 x 1/4 inch Steel Screw - 5 Battery Housing - 1 ¼-20 x 1/2 inch Truss Head Screw - 2 #10 Sheet Metal Screw - 3 Right Front Vent Clip - 1 Flat Head Screw - 2 Left Front Vent Clip -
Краткое содержание страницы № 6
6 ASSEMBLY 1 2 1 2 1 Arrow stickers on Frame Rail (1) and Left Side Panel (2) should point toward each other (shown 3 above). Door Stop Bracket (3) should be positioned as shown (left). 2 ® WWW.WEBER.COM
Краткое содержание страницы № 7
7 ASSEMBLY 7 3 ATTENTION! Do not fully tighten screws. Clips should slide freely when installed. 4 ® WWW.WEBER.COM
Краткое содержание страницы № 8
8 ASSEMBLY 5 6 Back ® WWW.WEBER.COM
Краткое содержание страницы № 9
9 ASSEMBLY 9 7 ® WWW.WEBER.COM
Краткое содержание страницы № 10
10 ASSEMBLY ® CAUTION: Use two people to lift and install the Summit Built-In frame assembly. A) Lift the frame assembly into the “island” structure opening. Make sure the frame is resting level on the finished surface of the structure. 8 B) Adjust the Front Vent to rest squarely on ground. CLEARANCES 24" (610 mm) Any Surface 1 Grill Frame a Note: For a countertop treatment: Recommended 19.1 mm (3/4˝ b inch) overhang. Notch front edge for frame to fully slide in. ® WWW.WEBER.COM
Краткое содержание страницы № 11
11 ASSEMBLY 11 9 1/4" (6.35 mm) Drill Bit A) Apply a bead of silicone sealant (1) around the perimeter and front edges of the grill that are in contact with the “island” structure. This A 10 will prevent moisture seepage. The sealant you use must have a temperature rating above 120°F (48.8° C). (1) S-460™ S-660™ ATTENTION! Before applying any silicone sealant make sure the cookbox is flush with the front of the grill frame. ® WWW.WEBER.COM
Краткое содержание страницы № 12
ASSEMBLY 12 S-460™ 11 3 - 2 1 BATTERY HOUSING WIRING 1 BLACK WIRE 2 GREEN WIRE 4 3 RED WIRE 3 4 RED WIRE WARNING: Make sure that all control knobs are turned to the OFF position before connecting the gas supply and operating the grill. ® WWW.WEBER.COM D
Краткое содержание страницы № 13
ASSEMBLY 13 Requires 3 “D” alkaline batteries (Included). Use alkaline batteries only. Do not mix old and new batteries or different types 13 of batteries (standard, alkaline or rechargeable). 12 13 Note: Secure wire to side panel. (1) (2) (3) ® WWW.WEBER.COM
Краткое содержание страницы № 14
14 ASSEMBLY 14 S-460™ S-660™ 15 S-460™ S-660™ 16 ® WWW.WEBER.COM
Краткое содержание страницы № 15
15 ASSEMBLY S-460™ S-660™ 15 17 A B Match Holder C ® WWW.WEBER.COM
Краткое содержание страницы № 16
16 ASSEMBLY 18 ATTENTION! Before drilling any holes for the 1/4" (6.35 mm) rear vent make Drill Bit sure the cookbox is flush with the front of the grill frame. ® WWW.WEBER.COM
Краткое содержание страницы № 17
17 ASSEMBLY S-460™ S-660™ 17 19 20 ™ ™ S-460 S-660 ® WWW.WEBER.COM
Краткое содержание страницы № 18
18 ASSEMBLY 21 ™ ™ S-460 S-660 S-460™ S-660™ 22 ® WWW.WEBER.COM
Краткое содержание страницы № 19
ASSEMBLY 19 S-460™ S-660™ 19 23 ® WWW.WEBER.COM
Краткое содержание страницы № 20
ASSEMBLY 20 ™ S-460 24 ™ S-660 ® WWW.WEBER.COM
