Краткое содержание страницы № 1
KEEPERS O F T HE FLAME
L P Gas Grill Use and Care
For Outdoor Use Only
™
To installer or person assembling grill: Leave this manual with grill for future reference.
To consumer: Keep this manual for future reference.
This manual applies to a variety of grill styles. Your grill will not have all of the features shown.
WARNING
Read this manual before cooking on grill. Failure to follow all manufacturers’ instructions could result in serious
personal injury and/or property damage.
Combustion by-pro
Краткое содержание страницы № 2
CAUTION WARNING For residential use only. Do not use for FOR YOUR SAFETY commercial cooking. 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP tank not connected for use Installation Safety Precautions shall not be stored in the vicinity of Use grill only with LP (propane) gas and the this or any other appliance. regulator/valve assembly supplied. FOR YOUR SAFETY Grill installation must conform with local codes, or
Краткое содержание страницы № 3
Table of Contents For Your Safety .........................................................................2 Call Grill Service Center For Help and Parts...................................................2 Fill Out Warranty Information...............................................................2 Installation Safety Precautions .............................................................2 Table of Contents........................................................................3 Safety Symbols
Краткое содержание страницы № 4
Safety Symbols Warranty The symbols and boxes shown below explain what Manufacturer warrants to the original consumer-purchaser each heading means. Read and follow all of the only that this product shall be free from defects in workmanship messages found throughout the manual. and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning with the date of purchase. DANGER Castings - Limited Lifetime All Burner - 3 years DANGER: Indicates a
Краткое содержание страницы № 5
LP Tank Removal, Transport And Storage Turn OFF all control knobs and LP tank valve. Turn DANGER coupling nut counterclockwise by hand only - do not use tools to disconnect. Remove attachment holding LP tank, then lift up and off support bracket. Never fill the cylinder beyond 80% full. An overfilled Install safety cap onto LP tank valve. Always use LP tank is hazardous due to possible gas released cap and strap supplied with valve. Failure to use from the safety relief valve. safety cap as
Краткое содержание страницы № 6
e s i w k LP (Liquefied Petroleum Gas) Use a clean paint brush and a 50/50 soap and water solution. Use mild soap and water. Do LP gas is nontoxic, odorless and colorless when not use household cleaning agents. Damage to produced. For Your Safety, LP gas has been given gas train components can result. an odor (similar to rotten cabbage) so that it can be smelled. LP gas is highly flammable and may ignite Brush soapy solution onto unexpectedly when mixed with air. areas indicated by arrow
Краткое содержание страницы № 7
Straight Do not use a POL transport plug DANGER (plastic part with external threads)! It will defeat the safety feature Do not insert any tool or foreign objects into of the valve. the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in explosion, fire, severe personal injury, or death. 5. Hold regulator and insert nipple into LP tank valve. Hand-tighten the coupling nut, holding regulator in If a leak is detected at any time, STOP an
Краткое содержание страницы № 8
Leak Testing Valves, Hose and Regulator WARNING 1. Turn all grill control knob(s) to OFF. 2. Be sure regulator is tightly connected to LP tank. If the regulator frosts turn off grill and LP tank valve immediately. This indicates a problem 3. Completely open LP tank valve by turning hand with the tank and it should not be used on wheel counterclockwise. If you hear a rushing any product. Return to supplier! sound, turn gas off immediately. There is a major leak at the connection. Correct before
Краткое содержание страницы № 9
Ignitor Lighting Traditions Series, QuickSet and QuickSet Traditional WARNING Do not lean over grill while lighting. For Safe Use Of Your Grill And To Avoid 1. Open lid during lighting. Turn on gas at LP tank. Serious Injury: 2. Turn LEFT knob to IGNITE. Do not let children operate or play near grill. 3. Push Piezo Ignitor Button rapidly, or hold Electronic Ignition, or turn Rotary Ignitor Knob (up to 5 times) to light. Be sure burner lights Keep grill area clear and free from materials th
Краткое содержание страницы № 10
Match Lighting for Four Burner Grills Ignitor Lighting: Performance and Advantage Series Do not lean over grill while lighting. 1. Open lid. Turn on gas at LP tank. Two Burner Grill: 2. Place lit match into match lighting hole from Do not lean over grill while lighting. outside of grill bottom (as shown). 1. Open lid. Turn on gas at LP tank. 3. Push in and turn right knob to . Be sure 2. Turn left knob to . burner lights and stays lit. Push in right-center 3. Push and hold Electronic Ignitor
Краткое содержание страницы № 11
Rotisserie Burner Ignitor Lighting Burner Flame Check 1. Turn all knobs to OFF. Light burner, rotate knob(s) from HIGH to LOW. You 2. Open lid during lighting. Turn gas on at LP should see a smaller flame in LOW position than Tank. seen on HIGH. Always check flame prior to each 3. Push in and turn Burner Selector Knob to ON use. Perform flame check on sideburner (if ROTISSERIE BURNER. equipped). If only low flame is seen refer to 4. Press Piezo Ignitor Button or Electronic "Sudden drop or low
Краткое содержание страницы № 12
Cleaning The Traditional Series, QuickSet and QuickSet Traditional Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill. 1. Turn gas off at control knobs and LP tank. 2. Remove cooking grate and V-Bar. 3. Under grill remove soup can, (unscrew ignitor button and remove battery on electronic ignition models), disconnect short ignitor wire (A) and clips from burner (B). To remove clips pull down on large end of clip att
Краткое содержание страницы № 13
QuickSet Burner Electrode Burner Tube Valve Clip B C A Short Ignitor Wire Remove button and battery on electronic ignition models 13
Краткое содержание страницы № 14
Cleaning The Performance and Advantage Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill. 1. Turn gas off at control knobs and LP tank. 2. Remove cooking grids and vaporizer tents. 3. Remove two pal nuts, carry-over tube and burners. 4. Under grill remove grease pan and tray. Clean with soap and water. 5. Disconnect battery and under console disengage ignitor wire. 6. Wipe ceramic electrode with rubbing alcohol an
Краткое содержание страницы № 15
Vaporizer Tents Pal Nuts Carry-Over Tube Burner Burner tubes correctly engaged in valves A Burner Valve Tube 15
Краткое содержание страницы № 16
Cleaning The Rotisserie Burner Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill. 1. Turn gas off at control knobs and LP tank. 2. Disconnect ignitor wire from electrode (A). 3. Remove thumbscrew from shield (B), remove shield and clean any accumulation of grease with soap and water. 4. Unfasten hinge pins and hitch pin. Note how hinge pins and hitch pins are attached. 5. Using a garden hose (preferably with nozzle), force water
Краткое содержание страницы № 17
Rotisserie Burner Use The rotisserie burner is a 10,500 BTU radiant heat burner that transforms your grill into a multilevel cooking center. It is attached to the back of the bottom casting, above the main grid. You can use the burner as a broiler to cook foods on the cooking grates or bonus-grid. If you do, then you cannot use the bottom burner. Or, you can remove the cooking grates or bonus grid, install a rotisserie and use the burner to perfectly roast foods on the split. This is the most co
Краткое содержание страницы № 18
General Grill Cleaning Repainting Your Grill Keep the outside of your grill looking new by cleaning it once a month with warm soap and water After extended use and exposure to weather, paint or a non-abrasive cleaner. If you don’t have a grill on grill may change color slightly or become cover, wipe off dust and grime before starting your spotted. Although this detracts from grill’s grill. appearance, it will not impair its performance. To refinish your grill brush outside of grill lid and
Краткое содержание страницы № 19
Care And Cleaning Of Stainless Steel Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The methods below are suggestions for cleaning stainless steel surfaces. Choose a cleaning method appropriate to the requirement. If you choose to use scouring powder or solvents, consult with the solvent manufacturer or supplier before use. Before cleaning, first test any cleaning product in an inconspicuous location and consider the possibility of scratchin
Краткое содержание страницы № 20
CAUTION NATURAL HAZARD SPIDERS FACT: Sometimes spiders and other small insects climb into the burner tubes attached to the burner. The spiders spin webs, build nests and lay eggs. The webs or nests can be very small, but they are very strong and can block the flow of gas. Clean burner(s) prior to use after storing, at the beginning of grilling season or after a period of one month not being used. Typical spider webs inside burner Spider Guards are on the air intakes in an effort to reduce this
