Краткое содержание страницы № 1
GAS
COOKER
ZCG 640
ZCG 641
INSTRUCTION BOOKLET
Please read this instruction booklet before using the appliance
GB
Краткое содержание страницы № 2
Important Safety Information You MUST read these warnings carefully before installing or using the hob. If you need assistance, contact our Customer Care Department on 08705 727727 Installation Unstable or misshapen pans should not be used on This appliance must be installed and serviced by a the hob burners as unstable pans can cause an competent person as stated in the Gas Safety ( accident by tipping or spillage. Installation and Use) Regulations Current Editions and the IEE Wiring Regula
Краткое содержание страницы № 3
Contents For the User For the Installer Important Safety Information 2 Guarantee Conditions 13 Control Panel 4 Important Safety Requirements 14 The Gas Hob Controls 5 Instructions for the Installer 14 The Gas Oven and Electric Grill Control 5 Installation 15 Before the First Use of the Cooker 6 Electrical Connections 17 Using the Oven 6 Commissioning 18 The Minute Minder 7 Conversion from Natural to LPG Gas 18 Using the Gas oven 7 Gas Oven Cooking Chart 8 Grilling 9 Maintenance and Cleaning 10 C
Краткое содержание страницы № 4
Control Panel 1 2 3 4 5 6 7 8 9 1. Electric ignition button 2. Oven Light button 3. Back left burner control knob (semi-rapid) 4. Front left burner control knob (rapid) 5. Front right burner control knob (auxiliary) 6. Back right burner control knob (semi-rapid) 7. Gas Oven and Electric Grill control knob 8. Minute Minder 9. Grill function Pilot Light Accessories The Oven Cavity Grill/roasting pan Grill trivet Electric Grill Oven Light Removable handles 2 anti-tip shelves Gas Oven Bottom Plate 4
Краткое содержание страницы № 5
The Gas Hob Controls To light a burner: - Push the electric ignition button which is marked with a little spark ( ). - At the same time push in and turn the relevant control knob anticlockwise to maximum position. - Then adjust the flame as required. If the burner does not ignite, turn the control knob to zero, and try again. When switching on the mains, after installation or a power cut, it is quite normal for the spark generator to be activated automatically. To ensure maximum burner effic
Краткое содержание страницы № 6
The Minute Minder The minute minder will mark the end of a timed period with an acoustic alarm. The maximum timing is 60 minutes. Turn the Minute Minder knob clockwise to the maximum time position, then turn it back to the required time. The Minute minder will not affect in any way the oven operation, if it is in use. Before the First Use of the Cooker Remove all packaging, both inside and outside the cooker, before using it. Before first use, the oven should be heated without food. During this
Краткое содержание страницы № 7
Hints and Tips Condensation and Steam Cookware When food is heated it produces steam in the same way Use any oven proof cookware which will withstand as a boiling kettle. The oven vents allow some of this temperatures of 250°C. steam to escape. However, always stand back from Baking trays, oven dishes, etc. should not be placed the oven when opening the oven door to allow any directly against the grid covering the fan at the back build up of steam or heat to release. of the oven, or placed o
Краткое содержание страницы № 8
Gas Oven Cooking Chart This chart is intended as a guide only. It may be necessary to increase or decrease the temperature to suit your individual requirements. Only experience will enable you to determine the correct setting for your personal requirements. SHELF COOKING TEMPERATURES FOOD °C POSITION TIME PUDDINGS Milk puddings 170 2 1½ - 2 hours Baked sponge pudding 210 2 45-60 minutes Baked custard 190 2 50-60 minutes CAKES Rich Fruit Cake 170 3 2¼ hours Christmas Cake 170 3 3½ - 4½ hour
Краткое содержание страницы № 9
Grilling Grilling must be carried out with the oven door Cooking chart closed. The grill pan handles must be removed Cooking time depends on the thickness of the meat and from the pan. not on its weight. How to Use the Grill Type of food Mins per side 1. Turn the oven control function knob to . Bacon rashers 2 - 5 The grill pilot light will come on. Chicken joints 15 - 20 Gammon rashers 5 - 8 2. Adjust the grid and grill pan runner position to allow for different thicknesses of food. Positio
Краткое содержание страницы № 10
Maintenance and Cleaning Before any maintenance or cleaning can be carried out, you must DISCONNECT the cooker from the electricity supply. This appliance cannot be cleaned with steam or with a steam cleaning machine. The Hob Top The Burners The hob is best cleaned whilst it is still warm, as spillage The burner caps and crowns can be removed for cleaning. can be removed more easily than if it is left to cool. Wash the burner caps and crowns using hot soapy Regularly wipe over the hob top using
Краткое содержание страницы № 11
Oven Cavity The enamelled oven cavity is best cleaned whilst the oven is still warm. Wipe the oven over with a soft cloth soaked in warm soapy water after each use. From time to time it will be necessary to do a more thorough cleaning, using a proprietary oven cleaner. Oven Shelves To clean the oven shelves, soak in warm soapy water and remove stubborn marks with a well wetted soap impregnated pad. Rinse well and dry with a soft cloth. Replacing the Oven Light Disconnect the appliance from the
Краткое содержание страницы № 12
Something Not Working If the appliance is not working correctly, please carry out the following checks, before contacting your local Service Force Centre. IMPORTANT: If you call out an engineer to a fault listed below, or to repair a fault caused by incorrect use or installation, a charge will be made even if the appliance is under guarantee. SYMPTOM SOLUTION There is no spark when lighting the gas Check that the unit is plugged in and the electrical supply is switched on Check that t
Краткое содержание страницы № 13
Customer Care Department For general enquiries concerning your Zanussi appliance or for further information on Zanussi products, please contact our Customer Care Department by letter or telephone at the address below or visit our website at www.zanussi.co.uk Customer Care Department Zanussi-Electrolux Cornwall House 55-77 High Street Slough Berkshire SL1 1DZ 08705 727727 (*) * calls to this number may be recorded for training purposes. Guarantee Conditions Zanussi guarantee conditions * Applianc
Краткое содержание страницы № 14
Instructions for the Installer Technical Data Hob Appliance Class 2 sub class 1 and Class 1 Rear left burner (semi-rapid) 2000 W Front left burner (rapid) 3000 W APPLIANCE CATEGORY: II2H3+ Rear right burner (semi-rapid) 2000 W APPLIANCE GAS SUPPLY: Natural Gas G20 20mbar Front right burner (auxiliary) 1000 W Dimensions Oven Height 900 mm Electric Grill 1650 W Depth 600 mm Gas Oven burner 2700 W Width 600 mm Oven light 25 W Oven Capacity 56 litres / 1.97 Cu. ft Total Electric Rating 1675 W Supply
Краткое содержание страницы № 15
L.P.G. cookers MUST NOT be installed below ground Location of the appliance level, i.e. in a basement, or aboard any boat, yacht or This appliance must not be installed in a bed-sitting other vessel. room of volume less than 20m³ or in a bathroom, shower For appliances installed in the Republic of Ireland please room or garage. It is essential that the appliance is refer to NSAI- Domestic Gas Installation I.S 813 Current positioned as stated below (see fig.1) i.e. shelves, wall Edition Section
Краткое содержание страницы № 16
FO 0179 Fig. 2 Fitting the Stability Bracket Connecting to Gas (Not supplied) This cooker is designed to be installed with an appliance flexible connection. Connection is made to the RC 1/2 (1/2" B.S.P.) threaded entry pipe located just below the If the cooker has to be installed with a flexible supply hotplate lev
Краткое содержание страницы № 17
Electrical connections Any electrical work required to install this cooker Permanent Connection should be carried out by a qualified electrician or In the case of a permanent connection, it is necessary competent person, in accordance with the current that you install a double pole switch between the cooker regulations. and the electricity supply (mains), with a minimum gap of 3 mm. between the switch contacts and of a type THIS COOKER MUST BE EARTHED. suitable for the required load in complianc
Краткое содержание страницы № 18
Commissioning When the hob has been fully installed it will be necessary to check the minimum flame setting. To do this, follow the procedure below. - Turn the gas tap to the MAX position and ignite. - Set the gas tap to the MIN flame position then turn the control knob from MIN to MAX several times. If the flame is unstable or is extinguished follow the procedure below. Procedure: - Re-ignite the burner and set to MIN. - Remove the control knob. According to the different gas tap versions, th
Краткое содержание страницы № 19
Replacement of gas oven burner nozzle To replace the gas oven nozzle, follow this procedure: 1. Remove the bottom plate of the oven cavity (“A”); 2. Undo the two fixing screws (“C”) which keep the oven gas burner in place 3. Gently slide the oven gas burner off the injector support (“D”) and slowly move it to the left hand side, taking care not to cause stress to the spark plug connection wire (“E”) and the thermocouple (“F”) conductor; 3. With a socket spanner 7 unscrew and remove the gas burne
Краткое содержание страницы № 20
CUSTOMER CARE Zanussi-Electrolux Cornwall House 55-77 High Street Slough Berkshire SL1 1DZ 08705 727727 (*) © Electrolux plc 2004 From the Electrolux Group. The world’s No.1 choice. The Electrolux Group is the world’s largest producer of powered appliances for kitchen, cleaning and outdoor use. More than 55 million Electrolux Group products (such as refrigerators, cookers, washing machines, vacuum cleaners, chain saws and lawn mowers) are sold each year to a value of approx. USD 14 billi
