Manual do usuário Hayward Pools ABG1001

Resumo do conteúdo contido na página número 1

Hayward0205English 8/3/05 9:38 AM Page 1
®
HAYWARD
Installation, Operation & Service Procedures
Above Ground Pool Heater
Models H100ID1 & ABG1001
Unit must be installed outdoors only
and below an altitude of 2000 feet
FOR YOUR SAFETY
WARNING: If the information in these instruc-
tions is not followed exactly, a fire or explo-
sion may result causing property damage,
personal injury, or death.
– Do not store or use gasoline or other flammable vapors or liq-
uids in the vicinity of t

Resumo do conteúdo contido na página número 2

Hayward0205English 8/3/05 9:38 AM Page 2 Section I. General Information tion) and applicable local codes. If propane gas tank is Important notice: installed underground, the discharge of the regulator vent The instructions herein are intended for the use of a must be above the highest probable water level. qualified technician, specifically trained and experienced in Propane tanks must have sufficient capacity to provide the installation of this type of heating equ

Resumo do conteúdo contido na página número 3

Hayward0205English 8/3/05 9:38 AM Page 3 1. Clean filter thoroughly. clockwise to increase the pressure required to close 2. Set heater thermostat to highest setting. the switch (this may be required if the heater is 3. Start filter pump. Make sure all air is out of water installed more than 4 feet below water level). lines and complete system is full of water. 5. To check operation, turn the pump on and off several 4. Place a 5/64” allen head wrench in the adjusting times. The h

Resumo do conteúdo contido na página número 4

Hayward0205English 8/3/05 9:38 AM Page 4 Figure 4 Gas pipe size: Follow local (as codes for proper gas line material selection (copper, iron or plastic etc.) It is VERY IMPORTANT when installing a propane heater on a LOW PRESSURE NATURAL GAS PIPE SIZING: two (2) stage regulation system, to follow the gas line sizing (Based upon gas pressure of 0.5 psig or less and a chart below—without exception. pressure drop of 0.5” W.C.) HIGH PRESSURE “TWO STAGE” SYSTEMS: D

Resumo do conteúdo contido na página número 5

Hayward0205English 8/3/05 9:38 AM Page 5 spas or hot tubs. Heater operation: If the pool/spa is used for therapy, it should be done with the Full lighting and shutdown instructions are included on the light- advice of a physician. Always stir the water before entering to mix ing instructions label installed on the front access door inside the in any hot surface water that might exceed healthful temperature heater cabinet. This heater cannot be operated with

Resumo do conteúdo contido na página número 6

Hayward0205English 8/3/05 9:38 AM Page 6 Figure 6 Operating Instructions 6

Resumo do conteúdo contido na página número 7

Hayward0205English 8/3/05 9:38 AM Page 7 Parts List & Illustration ITEM NO. DESCRIPTION PART NO. ITEM NO. DESCRIPTION PART NO. 1 1. Jacket, Top IDX JKT 1100 12. Grommet 1 ⁄2” Pipe IDX GRM 0001 2. Combustion Blower (JakelgJakel) IDX BWR 1930 13. Front Access Door IDX FAD 1101 Combustion Blower (JakelgFasco conversion) IDX BWR 1931 14. Burner Orifice, Natural Gas IDX ORF 1933 Combustion Blower (FascogFasco) IDX BWR 1932 15. Gas Manifold IDX MAN 1100 3. Blower Gasket (Jakel only) IDX BLG

Resumo do conteúdo contido na página número 8

Hayward0205English 8/3/05 9:38 AM Page 8 Hayward Pool Heater Certificate of Limited Warranty tations of the service life of various components. Do not install this prod- Limited heater warranty: uct where such leakage can cause damage. MANUFACTURER IS NOT TERMS AND COVERAGE: We warrant our pool heater to be free from RESPONSIBLE OR LIABLE FOR ANY COSTS INCURRED BY SUCH defects in workmanship and materials under normal use and service. DAMAGE. Pursuant to this war