Resumo do conteúdo contido na página número 1
L
I
P
F
F
O
HI
LO
PREMIUM AGED SPLIT OAK
AND YELLOW FLAME UNVENTED (VENT-FREE)
PROPANE/LP GAS LOG HEATER
OWNER’S OPERATION AND INSTALLATION MANUAL
Remote Control
Operation Requires
CGD3924PR
Two (2) 9-Volt Alkaline
CGB3924PR
Batteries Not Included
CGB3930PR
24" and 30" Remote
Controlled Models
®
(Yellow Flame Model Shown)
WARNING: Improper installation, adjust-
WARNING: If the information in this manual
ment, alteration, service, or maintenance
is not followed exactly, a fire or explosion
can c
Resumo do conteúdo contido na página número 2
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER • immediately call your gas supplier 13. This heater needs fresh, outside air ven- SAFETY from a neighbor’s phone. Follow the tilation to run properly. This heater has INFORMATION gas supplier’s instructions an oxygen depletion sensor (ODS) pi- • if you cannot reach your gas supplier, lot light safety system. The ODS shuts call the fire department down the heater if not enough fresh air WARNINGS is available. See Air for Comb
Resumo do conteúdo contido na página número 3
HI TEMP MAN LO ON AUTO OFF STATUS OWNER’S MANUAL PRODUCT PRODUCT IDENTIFICATION FEATURES Operation Crossover Log Back This heater is clean burning. It requires no Log outside venting. There is no heat loss out a vent or up a chimney. Heat is generated by realistic dancing, yellow flames. This heater Front Log is designed for vent-free operation with flue damper closed. State and local codes in some areas prohibit the use of vent-free heaters. Safety Pilot Remote Burner This heater has a pilot wi
Resumo do conteúdo contido na página número 4
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER Unusually Tight Construction Confined Space and Unconfined AIR FOR Space The air that leaks around doors and win- COMBUSTION AND dows may provide enough fresh air for The National Fuel Gas Code (ANSI Z2123.1, VENTILATION combustion and ventilation. However, in 1992 Section 5.3) defines a confined space buildings of unusually tight construction, as a space whose volume is less than 50 3 you must provide additional fresh air. cu
Resumo do conteúdo contido na página número 5
OWNER’S MANUAL AIR FOR COMBUSTION AND VENTILATION Continued DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION Determining if You Have a Confined or Unconfined Space Use this work sheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install heater plus any adjoining rooms with doorless passageways or ventilation grills between the rooms. 1. Determine the volume of the space (length x width x height). Length x Width x Height = _________________cu.
Resumo do conteúdo contido na página número 6
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER AIR FOR 12" COMBUSTION AND VENTILATION Ventilation Continued Ventilation Grills Grills Into Adjoining Room, Into Adjoining VENTILATION AIR Or Option 2 Room, Remove Ventilation Air From Inside Option 1 Door into Building Adjoining This fresh air would come from an adjoining Room, unconfined space. When ventilating to an Option adjoining unconfined space, you must pro- 3 vide two permanent openings: one within 12" of the ceil
Resumo do conteúdo contido na página número 7
OWNER’S MANUAL INSTALLATION LOG SIZING REQUIREMENTS WARNING: Never install the Minimum Firebox Size heater NOTICE: This heater is intended • in a bedroom or bathroom Rear for use as supplemental heat. Use • in a recreational vehicle Width this heater along with your pri- • where curtains, furniture, Log Front At 14" mary heating system. Do not in- clothing, or other flammable Size Height Depth Width Depth stall this heater as your primary objects are less than 36 inches heat source. If you have
Resumo do conteúdo contido na página número 8
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER INSTALLATION Non-Combustible Requirements for Continued Material Distance (A) Safe Installation 12" or more Non-combustible material okay. Minimum Non-Combustible Between 8" and 12" Install fireplace hood accessory (GA6050, GA6052, Material Clearances or GA6053, see Accessories, page 21). If Not Using Mantel Less than 8" Non-combustible material must be extended to at Note: If using a mantel, proceed to If Using least 8". See
Resumo do conteúdo contido na página número 9
OWNER’S MANUAL INSTALLATION Mantel Shelf 10" Underside of Continued 8" Mantel Shelf 6" 1 2 /2" MANTEL CLEARANCES If you meet minimum clearance between All minimum distances are mantel shelf and top of fireplace opening, a in inches hood is not required (see Figure 6). Minimum Non- (A) Combustible If minimum clearances in Figure 6 are not Material met, you must have a hood. When using a 12" 18" 20" 22" 24" Log Set hood there are still certain minimum mantel 24"/30" Models clearances required.
Resumo do conteúdo contido na página número 10
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER 4. Mark screw locations through holes in Installation Items Needed INSTALLATION mounting flanges (see Figure 11). If in- Before installing heater, make sure you have Continued stalling in a brick-bottom fireplace, the items listed below. mark screw locations in mortar joint of INSTALLING HEATER BASE • piping (check local codes) bricks. ASSEMBLY • sealant (resistant to propane/LP gas) 5. Remove heater base from fireplace. CAUT
Resumo do conteúdo contido na página número 11
OWNER’S MANUAL Install sediment trap in supply line as shown INSTALLATION in Figure 13. Locate sediment trap where it CAUTION: Make sure exter- Continued nal regulator has been installed is within reach for cleaning. Locate sedi- between propane supply and ment trap where trapped matter is not likely to freeze. A sediment trap traps moisture heater. See guidelines under Con- CAUTION: Use only new, and contaminants. This keeps them from necting to Gas Supply, page 10. black iron or steel pipe. I
Resumo do conteúdo contido na página número 12
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER 4. Check all joints from manual shutoff 9-VOLT BATTERY INSTALLATION valve to control valve (see Figure 15). INSTALLATION Continued Apply mixture of liquid soap and wa- Two 9-volt alkaline batteries (not included) ter to gas joints. Bubbles forming show are required to operate this heater with the Pressure Testing Heater Gas a leak. wireless hand-held remote control set. One Connections 5. Correct all leaks at once. battery mus
Resumo do conteúdo contido na página número 13
3 OWNER’S MANUAL Front Log (#3) Back Log (#1) INSTALLATION Peg Continued Hole in INSTALLING LOGS Grate Base (CGD3924PR) WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts specifically approved with Post this heater may result in property damage or personal injury. Post Recess CAUTION: After installation Figure 20 - Installing Front Log (#3) and periodically thereafter, check Burner to ensure that no flame comes in Crossover Log (#1) Notches co
Resumo do conteúdo contido na página número 14
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER 1. Place the base of the middle log (#1) in 4. Locate the notches in the bottom of the INSTALLATION the U-shaped slots of the grate base. front log (#4). Place the front log on Continued The cutout on the right of the middle the grate fingers. Make sure the notches log should bit over the burner (see Fig- of the front log line up with the grate INSTALLING LOGS ON ure 22). Make sure the front of the fingers (see Figure 25). mid
Resumo do conteúdo contido na página número 15
O L I P F F O H I L OWNER’S MANUAL LIGHTING OPERATING WARNING: Burners will come INSTRUCTIONS on automatically within one HEATER minute when the remote selector WARNING: switch is in the ON position after FOR YOUR SAFETY • If fireplace has glass doors, the pilot is lit. READ BEFORE never operate this heater with glass doors closed. If you oper- 4. Press in and turn control knob clock- LIGHTING wise to the OFF position. ate heater with doors closed, heat buildup inside fireplace will 5. Wait
Resumo do conteúdo contido na página número 16
N O T O H L I I L CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER IMPORTANT: Do not leave the re- THERMOSTAT OPERATING mote selector switch in the REMOTE CONTROL HEATER position when the pilot is not lit. This OPERATION will drain the battery. Continued The thermostat control setting on the 2. Select the MANUAL or AUTO button 9. Slightly push in and turn control remote control unit can be set to any on the hand-held remote control unit. knob counterclockwise to the comfort
Resumo do conteúdo contido na página número 17
OWNER’S MANUAL OPERATING CLEANING AND HEATER MAINTENANCE Continued WARNING: Turn off heater Shows Temperature Setting HI and let cool before cleaning. Increases Room Temperature TEMP CAUTION: You must keep Decreases Room Allows Burners to be Turned Temperature control areas, burner, and circu- On and Off with the Hand- lating air passageways of heater Held Remote Unit. LO MAN ON Turns Burners clean. Inspect these areas of On and Off heater before each use. Have The log heater will automati- A
Resumo do conteúdo contido na página número 18
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER TROUBLESHOOTING WARNING: Turn off heater CAUTION: Never use a wire, and let cool before servicing. Only needle, or similar object to clean Note: All troubleshooting items are listed in ODS/pilot. This can damage ODS/ order of operation. a qualified service person should pilot unit. service and repair heater. OBSERVED PROBLEM POSSIBLE CAUSE REMEDY When ignitor button is pressed, there is no 1. Ignitor electrode not connected t
Resumo do conteúdo contido na página número 19
OWNER’S MANUAL TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Burner does light after ODS/pilot is lit 1. Burner orifice clogged 1. Clean burner (see Cleaning and Mainte- nance, page 17) or replace burner orifice 2. Inlet gas pressure is too low 2. Contact local propane gas company 3. Burner orifice diameter is too small 3. Replace burner orifice 4. Thermopile leads disconnected or im- 4. Reconnect leads (see Wiring Diagram, properly connected page 21) 5. Burners will not come
Resumo do conteúdo contido na página número 20
CGD3924PR, CGB3924PR and CGB3930PR UNVENTED PROPANE/LP GAS LOG HEATER TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. • If you cannot reach your gas supplier, call the fire department. IMPORTANT: Operating heater where impurities in air exist may create od
