Resumo do conteúdo contido na página número 1
®
GE Monogram
Installation
Instructions
Outdoor
Cooking Center
Dual Burner
Outdoor Cooktop
Liquid Propane
Model ZX2L SS
Natural Gas
Model ZX2N SS
Resumo do conteúdo contido na página número 2
Before you begin—Read these instructions completely and carefully. IMPORTANT: Save these instructions for local inspector’s use. IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES. NOTE TO INSTALLER: Be sure to leave these instructions with the Consumer. NOTE TO CONSUMER: Keep these instructions with your Owners Manual for future reference. If you have questions concerning the Installation of this burner requires basic installation of this product, call the GE mechanical skills. Proper instal
Resumo do conteúdo contido na página número 3
Design Information Dual Burner Outdoor Cooktop These models can be mounted to the right Monogram Dual Burner Outdoor Cooktops Models side of a Monogram 27" wide grill which has are factory set for LP or natural gas. Order the Available been installed on a cart. model for your installation situation. Natural Gas These models can also be installed in a Liquid Propane Model ZX2N SS combustible or non-combustible enclosure. Model ZX2L SS When installed on the side of a grill cart, allow Product 6"
Resumo do conteúdo contido na página número 4
Design Information Dual Burner Outdoor Cooktop • These cooktops are designed for outdoor use • Do not install an outdoor cooktop below Choosing only. Do not locate the cooktop in a building, overhead unprotected combustible the Location garage or other enclosed area. construction. • Ensure that fresh air ventilation is adequate. • The installation must conform to local codes • Consider exposure to wind and proximity to or in the absence of local codes, with the traffic paths. national fuel gas c
Resumo do conteúdo contido na página número 5
Installation Dual Burner Outdoor Cooktop The cooktop burner is designed to fit onto the right side of the 27" grill head. Step 1/4-20 • Open the grill lid and remove the right Lock Nut Support 2 cooking grate and Gourmet Radiant Tray (or Bracket Lava Rock Tray). Installation On 27" Cart Secure Support Brackets to Grill Gas Hose • Remove the cooktop burner cover, burner (Skip this step if 1/4-20 Bushing grate and stainless steel aeration pan and you are installing 1/4" Flat Lock Nut drip tray. Wa
Resumo do conteúdo contido na página número 6
Installation Dual Burner Outdoor Cooktop • All built-in installations should be at least 15-3/8" 35-1/2" above the floor. Step 2x2 24-5/8" Clearances to Combustibles: Opening 2A • Allow at least 6" clearance from the back and for Gas Supply sides to any combustible material. Installation Line • Allow at least 1" clearance below the cooking Into An surface on all sides. 1" 11" Installation in a combustible enclosure: Enclosure 1-1/8" • Installation into a combustible enclosure (Skip this step
Resumo do conteúdo contido na página número 7
Installation Dual Burner Outdoor Cooktop WARNING PRODUCT STORAGE Step When storing the LP burner indoors, 3 disconnect the LP tank. Store the tank outdoors in a well ventilated area. Provide Do not store spare LP tanks near or below Gas the burner installation. Supply For installation with a 27" LP gas grill that To Manifold 1/2" NPT x of Grill does not feature the new Quick Disconnect 3/8" Flare Fitting LP GAS MODELS coupling. Go to Step 3A • Completely close the main valve on the LP To Cooktop
Resumo do conteúdo contido na página número 8
Installation Dual Burner Outdoor Cooktop NATURAL GAS MODELS The burner and its individual shut-off valve Regulator Step must be disconnected from the gas supply 4.0" W.C. 3A during any pressure testing of the system at test pressures in excess of 1/2 PSIG. Provide 1/2 NPT Gas Supply Close Nipple The burner must be isolated from the gas supply system by closing its individual shut-off • Install a manual gas shut-off valve in an easily valve during any pressure testing of the system accessible lo
Resumo do conteúdo contido na página número 9
Installation Dual Burner Outdoor Cooktop The valve panel must be removed to check Step WARNING TEST FOR LEAKS the valves and fittings. A complete gas tightness check must be • All control valves should be in the “OFF” 4 performed at the installation site. DO NOT position. USE A FLAME TO CHECK FOR GAS • Remove the knobs. Test for LEAKS. • Remove the 4 screws holding the valve panel Leaks to the burner. • Do not use the burner until all connections • Pull the panel outwards and unplug the wire hav
Resumo do conteúdo contido na página número 10
Installation Dual Burner Outdoor Cooktop Step Adjustments should not be required, unless vibration during transit or variations in local 1-1/2" Proper Flame gas supply make minor adjustments necessary. 6 Adjustments must be made by a qualified Adjusting technician at the time of installation. Extreme 3/8" the Burners care should be used if adjustments are made after installation. Burner • Push and turn the burner control knobs to the “LITE” position. Push and turn the small ignitor knob clockwis
Resumo do conteúdo contido na página número 11
Notes Dual Burner Outdoor Cooktop 11
Resumo do conteúdo contido na página número 12
Note: While performing installations described in this book, safety glasses or goggles should be worn. To obtain specific information concerning any ® Monogram product or service, call GE Answer Center consumer information service at 800.626.2000—any time, day or night. For Monogram local service in your area, call 1-800-444-1845. Pub. No. 49-8842-1 Dwg. No. 164D3333P082 NOTE: Product improvement is a continuing endeavor at General Electric. Therefore, materials, appearance and specifications ar
