Resumo do conteúdo contido na página número 1
Table of Contents
Accu-Z
®
Razor Pro
®
ZRP44 & ZRP52 Zero Turning Radius Mowers
21041
356-117M
Operator’s Manual
Read the Operator’s Manual entirely. When
you see this symbol, the subsequent
!
instructions and warnings are serious - follow
without exception. Your life and the lives of
others depend on it!
7/14/08
© Copyright 2008 Printed
Cover photo may show optional equipment not supplied
with standard unit.
Resumo do conteúdo contido na página número 2
Land Pride Table of Contents Table of Contents Deck Leveling and Height Adjustment . . . . . . . . .19 Important Safety Information . . . . . . . . . . .1 Deck Level Adjustments . . . . . . . . . . . . . . . . .19 Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Tire Inflation Chart . . . . . . . . . . . . . . . . . . . . . . . .19 Introduction . . . . . . . . . . . . . . . . . . . . . . . .6 Deck Cutting Height Adjustment . . . . . . . . . . . . .21 Application . . . .
Resumo do conteúdo contido na página número 3
ON Land Pride Table of Contents Important Safety Information Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. Keep Riders Be Aware of Signal Words ! WARNING! Indicates a potentially hazardous Off Machinery A signal word designates a degree or situation which, if not avoided, could level of hazard seriousness. The Riders obstruct the operator’s result in death or serious injury, and signal words are: view, they
Resumo do conteúdo contido na página número 4
Land Pride Table of Contents Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. Inspect all parts. Make sure parts Practice Safe Maintenance are in good condition & installed Understand procedure before properly. doing work. Use proper tools and Remove build-up of grease, oil or equipment, refer to Operator’s debris. Manual for additional information. Remove all tools and unused Work in a clean dry area. p
Resumo do conteúdo contido na página número 5
Land Pride Table of Contents Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. Avoid High Wear Prepare for Emergencies Pressure Fluids Hazard Protective Equipment Be prepared if a fire starts. Escaping fluid under pressure can Protective clothing and equipment Keep a first aid kit and fire penetrate the skin causing serious should be worn. extinguisher handy. injury. Wear clothing and equipment Keep emergen
Resumo do conteúdo contido na página número 6
Land Pride Table of Contents Important Safety Information 838-303C 21043 Danger: Battery (Beneath Seat) 838-305C Warning: Rollover Hazard (Beneath Bumper on Back of 21042 Frame) 838-306C 21043 Warning: Do not operate without deflector 818-543C Danger: Guard is missing 21043 (Beneath foot pan on mower deck) ZRP44 & ZRP52 Zero Turning Radius Mowers 356-117M 7/14/08 4
Resumo do conteúdo contido na página número 7
Land Pride Table of Contents Important Safety Information 838-307C Warning: Moving Parts (Both Sides) 21043 838-308C Warning: Rotating Blade 21043 Hazard (Both Sides) 838-310C 21041 Warning: General 838-399C 21041 Warning: Fuel Imbedded in Fuel Tank 7/14/08 ZRP44 & ZRP52 Zero Turning Radius Mowers 356-117M 5
Resumo do conteúdo contido na página número 8
Land Pride Table of Contents Introduction Introduction Land Pride welcomes you to the growing family of new IMPORTANT: product owners. For parts and service for your engine contact your This mower has been designed with care and built by nearest dealer or Call Customer Service Hotline. skilled workers using quality materials. Proper assembly, maintenance, and safe operating practices will help you Honda Engine Information: get years of satisfactory use from this mower. Service Manual: P/N 61ZJ41
Resumo do conteúdo contido na página número 9
Land Pride Table of Contents Section 1 Assembly and Set-Up Section 1 Assembly and Set-Up 2. Mount seat (#1) in the operating position, to the seat Control Lever & Seat Assembly platform with four 5/16” nuts (#3) and four 5/16” flat Refer to Figure 1-1: washers (#2). The seat (#1) is shipped loose for ease in shipping. The 3. Connect the switch wires on the mower with the switch control lever’s upper bolts (#4) and nuts (#5) are removed wires on the seat. and the levers are rotated down. 4. Return
Resumo do conteúdo contido na página número 10
Land Pride Table of Contents Section 2 Operating Section 2 Operating 12 8 9 10 17 14 11 3 12 12 16 5 12 6 8 7 21044 11 1 2 4 18 12 15 13 17 1. Ignition Switch 14. Left Deck Cover 2. Throttle Lever 6. Hour Meter 15. Right Deck Cover 10. Battery 3. Control Levers 7. Oil Pressure Light 16. Deck Height Control 11. Deck Adjusting Rod 4. Blade Engagement Switch 8. Fuel Tanks 17. Park Brake Switch 12. Anti-Scalp Wheels 5. Deck Lift Pedal 9. Hydraulic reservoir 18. Choke Lever 13. Discharge Chute Razor
Resumo do conteúdo contido na página número 11
Land Pride Table of Contents Section 2 Operating Left/Right Fuel Tank Valve The Parking Brakes are applied by moving the control levers from the Neutral Position (Figure 2-4) to an outward Refer to Figure 2-3: position (Figure 2-5). Each rear wheel brake operates The mower is equipped with a Left/Right Fuel Tank Valve independently of the other. located on the right side behind the seat. It determines which fuel tank the mower is operating from. It is not important which fuel tank the mower is u
Resumo do conteúdo contido na página número 12
Land Pride Table of Contents Section 2 Operating engagement switch is up or the control levers are in Instrumentation neutral position. Oil Pressure Light 6. Check the function of the seat switch If the engine fails Refer to Figure 2-2: to stop when the blade engagement switch is up or if This light comes on when the ignition switch is placed in one or both of the control levers are in and the the RUN position and stays lit until the engine is running operator is off the seat. Replace the seat s
Resumo do conteúdo contido na página número 13
Land Pride Table of Contents Section 2 Operating IMPORTANT: The engine starter should not be IMPORTANT: Following repairs, always make certain operated for periods longer then 30 seconds at a time. the two bypass valve stems are returned to their An interval of at least two minutes should be allowed operating position before running the mower. between such cranking periods to protect the starter from overheating and burn-out. Driving the Mower 5. Perform test to make sure safety start interlock
Resumo do conteúdo contido na página número 14
Land Pride Table of Contents Section 2 Operating Front of Mower Faces This Direction N N Forward Travel Pivot Right Turn Forward Travel Reverse Travel Reverse Travel Right Turn Right Turn N= Neutral Position Direction of arrows indicate direction of mower movement. Steering Figure 2-8 Peak mowing performance is maintained when the throttle Operating Suggestions is set at full rpm. This gives maximum power to the drive wheels and deck when needed. Use the control levers to ! DANGER! control groun
Resumo do conteúdo contido na página número 15
Land Pride Table of Contents Section 2 Operating Operating Instructions After thoroughly familiarizing yourself with the Operator’s Manual and completing the Operator’s Checklist, you are almost ready to begin mowing. Approach the mower from the front. Spread the steering levers fully apart if they aren’t already in the wide-open parking brake position. Taking care not to step on either side of the mower deck, step up on the operators’ platform and comfortably seat yourself. With both steering l
Resumo do conteúdo contido na página número 16
Land Pride Table of Contents Section 3 Adjustments Section 3 Adjustments It is recommended that the following be checked after the Introduction first 2 hours of initial operation, and every 50 hours following removal for repair or replacement: ! WARNING! • Wheel lug nuts Unless specifically required, DO NOT have engine running • Wheel motor nut when servicing or making adjustments to the mower. Place • Blade spindle bolts (top and bottom) control levers in the park brake position and remove ignit
Resumo do conteúdo contido na página número 17
Land Pride Table of Contents Section 3 Adjustments Control Lever Neutral Adjustment nuts on the pump linkage rods and rotate the rod to shorten the steering control linkage until the wheel(s) Refer to Figure 3-2 come to a stop. Repeat for the opposite side if Before considering any adjustment, check the tire air necessary. pressure and make certain hydraulic system oil is at 6. When both wheels remain in neutral, tighten the jam operating temperature. Unequal tire pressure will cause nuts to loc
Resumo do conteúdo contido na página número 18
Land Pride Table of Contents Section 3 Adjustments 3. Do this for each side. NOTE: The dampener must not bottom out when the Refer to Figure 3-3 on page 15. To adjust the stops for pump lever is fully stroked in either direction. driving straight when control levers are against the stops during operation: Control Lever Adjustment 4. Determine which drive tire is rotating too fast when Refer to Figure 3-5 both control levers are against the stops. Then stop The control levers may be adjusted vert
Resumo do conteúdo contido na página número 19
Land Pride Table of Contents Section 3 Adjustments NOTE: Refer to Figure 3-6. The front brake link is not adjustable. Park Brake Slot Front brake link (right side) Control Lever 1/8” 21070 Control Lever Position* Figure 3-8 21058 NOTE: Refer to Figure 3-9. When the control lever is Figure 3-6 against the outside edge of the slot, the brakes 2. Raise and block the tractor up so the drive wheels are should not be engaged. off of the floor. 3. Refer to Figure 3-7. Open the hydraulic pumps bypass val
Resumo do conteúdo contido na página número 20
Land Pride Table of Contents Section 3 Adjustments 7. Refer to Figure 3-10. Loosen the brake linkage jam Hydro-Drive Belt Adjustment nuts. Refer to Figure 3-12 The pump drive belt tension remains constant by means Jam Nut Jam Nut of a tension idler and spring. There is no tension adjustment of this belt. Spring Brake Linkage Turnbuckle 21073 Tension Idler Pump Drive Figure 3-10 Belt 8. Rotate the tire and at the same time rotate the turnbuckle to shorten the length of the brake linkage to increa
