Resumo do conteúdo contido na página número 1
OPERATOR’S MANUAL
3000
TRACTOR
Model 3165
IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Warning: This unit is equipped with an internal combustion engine and should not be used on or
near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s
exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a
spark arrester is used, it should be maintained in effective working order by the operator. In the State
of Cali
Resumo do conteúdo contido na página número 2
SECTION 1: TABLE OF CONTENTS PAGE IMPORTANT SAFE OPERATION PRACTICES . . . . . . . . . . . . . . . . . . . . . . 2 SAFETY LABELS FOUND ON YOUR UNIT . . . . . . . . . . . . . . . . . . . . . . . . . 7 TABLE OF CONTENTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CALLING SERVICE INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 FINDING YOUR MODEL & SERIAL NUMBER . . . . . . . . . . . . . . . . . . . . . . . 6 CONTROLS. . . . . . . . .
Resumo do conteúdo contido na página número 3
Clear the area of objects such as Do not operate the machine while rocks, toys, wire, etc., which could under the influence of alcohol or be picked up and thrown by the drugs. blade. A small object may have Watch for traffic when operating been overlooked and could be near or crossing roadways. accidentally thrown by the mower in any direction and cause injury to Use extra care when loading or you or a bystander. To help avoid a unloading the machine into a trailer thrown objects injury,
Resumo do conteúdo contido na página número 4
Avoid starting or stopping on a 2. SLOPE OPERATION slope. If tires lose traction, Slopes are a major factor related to disengage the blade(s) and proceed loss of control and tip-over accidents slowly straight down the slope. which can result in severe injury or death. All slopes require extra caution. DO NOT: If you cannot back up the slope or if Do not turn on slopes unless you feel uneasy on it, do not mow it. necessary; then, turn slowly and For your safety, use the slope gauge gradually
Resumo do conteúdo contido na página número 5
Remove key when machine is Keep all nuts, bolts and screws tight unattended to prevent unauthorized to be sure the equipment is in safe operation. working condition. Never tamper with safety devices. 4. SERVICE Check their proper operation Use extreme care in handling regularly. Use all guards as gasoline and other fuels. They are instructed in this manual. extremely flammable and the vapors After striking a foreign object, stop are explosive. the engine, remove the wire from Use on
Resumo do conteúdo contido na página número 6
Use proper containers when DO NOT pour oil or other fluids into draining fluids. Do not use food or the ground, down a drain or into a beverage containers that may stream, pond, lake or other body of mislead someone into drinking from water. Observe Environmental them. Properly dispose of the Protection Agency regulations when containers immediately following the disposing of oil, fuel, coolant, brake draining of fluids. fluid, filters, batteries, tires and other harmful waste. WARNING - YOU
Resumo do conteúdo contido na página número 7
SECTION 5: SAFETY LABELS FOUND ON YOUR UNIT STOP IGNITION WARNING AVOID SERIOUS INJURY OR DEATH ST ARTING INSTRUCTIONS GO UP AND DOWN SLOPES, NOT ACROSS. 1. BE FAMILIAR WITH CONTROLS BEFORE STARTING ENGINE AVOID SUDDEN TURNS. AND OPERATING. DO NOT OPERATE UNIT 2. SET CHOKE, MOVE THROTTLE WHERE IT COULD SLIP TO MID POSITION AND OR TIP. DEPRESS BRAKE PEDAL. IF MACHINE STOPS 3.TURN KEY TO THE START GOING UPHILL, STOP PTO POSITION. AND BACK DOWN HILL SLOWLY. 4.AFTER ENGINE START
Resumo do conteúdo contido na página número 8
SECTION 6: CONTROLS A R O B P N C D M G E F L Q (Not Shown) K J I H Figure 3 A Parking Brake Lever J Fuel Fill Cap B PTO Switch K Cup Holder C Brake Pedal L Hydraulic Lift Lever D Reverse Pedal M Steering Wheel Tilt Lock E Forward Pedal N Cruise Control Lever F Ignition/Light Switch O Choke Lever G Center Lift Height Indicator P Throttle Lever H Transmission Release Rod Q Seat Adjustment Lever (Not Shown) I Transmission Oil Fill/Dipstick R Indicator Light Pod * Steering Wheel and Seat Removed
Resumo do conteúdo contido na página número 9
disengage the cruise control. The NOTE: References to LEFT and brake pedal must be fully depressed to RIGHT indicate that side of the tractor activate the safety interlock switch when facing forward while seated in when starting the tractor. the drivers seat. Reference to FRONT indicates the grille end of the tractor; Reverse Pedal to REAR, the drawbar end. Steering Wheel The steering wheel is centered on the dash panel. It is used to change the direction (left or right) of the tractor while dri
Resumo do conteúdo contido na página número 10
Ignition / Light Switch mission oil dipstick serves as the fill tube plug and should fit snugly in the To prevent accidental starting and/or fill tube. battery discharge, remove the key from the ignition switch when the Fuel Fill Cap tractor is not in use. The combination The fuel fill cap is located on the lights and ignition switch has four fender to the left of the seat. positions. See Figure 8 for a Cup Holder description of each position. The cup holder is located on the fender to the lef
Resumo do conteúdo contido na página número 11
The throttle lever is located to the left IMPORTANT: When using power of the steering wheel in the throttle/ take-off operated equipment, best choke lever pod. This lever controls performance is achieved with the the speed of the engine. Push the throttle lever in the “FAST” position. lever forward to increase the engine Seat Adjustment Lever speed. When set in a given position, The seat adjustment lever is located the throttle will maintain a uniform below the seat. This lever is used to engine
Resumo do conteúdo contido na página número 12
fuel in a quantity that can be used SECTION 7: OPERATION within 30 days to assure fuel fresh- Safety Interlock Switches ness. In countries other than the This tractor is equipped with a safety U.S.A., leaded gasoline may be used interlock system for the protection of if it is commercially available and the operator. If the interlock system unleaded is not available. should ever malfunction, do not The fuel fill point is located on the operate the tractor. Contact your fender to the left of the s
Resumo do conteúdo contido na página número 13
Place the PTO switch in the “OFF” Slowly depress the forward control position. Move the throttle control pedal until the desired speed is lever to the “MID” position. Then achieved. turn the ignition key to the “OFF” Lightly push the cruise control lever position. downward. Remove the key from the ignition While continuing to hold the cruise switch. lever down, lift your foot from the forward control pedal (you should Driving The Tractor feel the cruise latch engage). If properly en
Resumo do conteúdo contido na página número 14
Before operating the tractor on any Pull the PTO switch to the “RUN” position. slope, walk the slope to look for possible hazards such as rocks. Advance the throttle lever to the mounds, ruts, stumps or other surface operating speed (full engine speed). irregularities which could cause the The operator must remain in the tractor to be upset. tractor seat at all times. If the Back the tractor with attachment up operator should leave the seat without turning off the power take- the steepest
Resumo do conteúdo contido na página número 15
Do not cut the grass too short, as the WARNING: To avoid possi- mower will tend to scalp the grass. ble injury, do not allow anyone Short grass invites weed growth and in the area opposite the dis- yellows quickly in dry weather. charge chute while mowing. Mowing should be done with the Although the area has been engine at full throttle. Do not mow at supposedly cleared of foreign high ground speed. objects, small objects may be During certain times of the year and picked up and discharged by u
Resumo do conteúdo contido na página número 16
Steering Wheel Tilt Adjustment Steering Axle WARNING: Do not adjust Hex Lock Nut the steering wheel when the tractor is moving. Adjusting the steering wheel while the tractor is moving could Tie Rod cause the operator to lose Hex Jam Nut control of the tractor. Ball Joint To allow for the comfort of the Figure 14 operator, an easy to operate adjustable steering wheel is a feature Brake Inspection and Adjustment of this tractor. To adjust the steering During the normal operation of the wheel fo
Resumo do conteúdo contido na página número 17
With the brake pedal disengaged, tighten and counterclockwise to insert an .030” feeler gauge between loosen the brake assembly. See Fig- the inner brake pad and the rotor. If ure 15. the .030” gauge does not fit, the Turn the adjustment nut as neces- brakes are overly tightened and sary to obtain the .030” to .060” should be loosened. clearance. Attempt to insert an .060” feeler Repeat the above procedure to gauge between the inner brake pad check and adjust the other brake and the roto
Resumo do conteúdo contido na página número 18
SECTION 10: LUBRICATION ILLUSTRATION Cub Cadet 251H EP Grease or equivalent No. 2 lithium grease Engine Oil: See Figure 24 on page 28 Transmission Oil-See your Cub Cadet Dealer Oil Can (High quality lubricating oil) 18 Transmission Engine Front Pivot Axle Foot Control Pivot Points L/R Front Wheels L/R Steering Knuckle
Resumo do conteúdo contido na página número 19
Accessing Engine Compartment panels. To remove the quick release side panels (see Figure 16): The engine compartment can be accessed by lifting the hood upward Open the hood by pulling up. from the recessed notches of the side Flip quick release fasteners up and panels and tipping the hood forward. If turn to align with slots in side panels. greater access is required, the tractor Swing the side panel out and away is equipped with quick release side from the tractor Quick Fasteners Lift Ho
Resumo do conteúdo contido na página número 20
Battery Removal cables. Removing the battery from the unit is recommended. The battery is located under the dash All batteries discharge during panel in the frame pedestal. storage. Keep the exterior of the To remove the battery: battery clean, especially the top. A Open the tractor hood by lifting it at dirty battery will discharge itself the notches in the side panels. more rapidly. Remove the upper baffle of the The battery must be stored with a bulkhead from the front of the dash ful
