Resumo do conteúdo contido na página número 1
GAS GRILL
Built-In LP Gas Grill Installation Guide
Tank Enclosure Installation - Pg 25
™
S-460
™
S-660
#43267
YOU MUST READ THIS OWNER’S GUIDE
WARNING: Follow all leak-check procedures
BEFORE OPERATING YOUR GAS GRILL carefully in this manual prior to barbecue
operation. Do this even if the barbecue was
dealer-assembled.
DANGER
If you smell gas:
NOTICE TO INSTALLER: These instructions
1. Shut off gas to the appliance.
must be left with the owner and the owner
2. Extinguish any open fl
Resumo do conteúdo contido na página número 2
2 WARNINGS Keep any electrical supply cord and the fuel supply hose DANGER away from any heated surfaces. Failure to follow the Dangers, Warnings and Cautions ® Do not use this Weber tank enclosure kit unless all parts are contained in this Owner’s Manual may result in serious bodily in place. The unit must be properly assembled according injury or death, or in a fire or an explosion causing damage to to the instructions outlined in the “Assembly Instruction” property. section of th
Resumo do conteúdo contido na página número 3
3 BUILT-IN CUTOUT DIMENSIONS BUILT-IN STRUCTURE CUTOUT DIMENSIONS BUILT-IN CUTOUT DIMENSIONS 3 ALL DIMENSIONS ARE TO FINISHED SURFACES. S-460™ S-660™ TOLERANCES WARNING: All countertop finished surfaces must be 1 1 1 1 1 30 / ˝ (768.35 mm) 38 / ˝ (971.55 mm) + / ˝ - / ˝ (6.35mm) constructed of a noncombustible material. 4 4 4 4 3 3 1 1 2 34 / ˝ (873.13 mm) 34 / ˝ (873.13 mm) + / ˝ - / ˝ (6.35mm) 8 8 4 4 1 1 3 23˝ (584.2 mm) 23˝ (584.2 mm) + / ˝ - / ˝ (6.35mm) 4 4 GENERAL CONSTRUCTION
Resumo do conteúdo contido na página número 4
4 PARTS LIST ™ S-460 Lid - 1 Left Door - 1 Cookbox - 1 Right Door - 1 Warming Rack - 1 OR ™ S-660 Lid - 1 Right Enclosure Panel - 1 Cookbox - 1 Left Enclosure Panel - 1 Front Frame Rail - 1 Front Vent Panel - 1 Rear Frame Rail - 1 Rear Panel Assembly - 1 Rear Vent - 1 Bottom Shelf - 1 Corrugated Gas Line - 1 ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 5
5 PARTS LIST ® Flavorizer Bars Smoker - 1 5 ™ - 8 S-460 ™ - 12 S-660 Stainless Steel Cooking Grates Smoker Bar - 1 ™ S-460 - 2 ™ - 3 S-660 1/2 inch Bolts (¼-20 x 1/2 inch Bolt) - 10 Collection Tray - 1 Nylon Washer - 10 Catch-Pan Holder - 1 Hinge Pin - 2 Catch-Pan - 1 Hair Pin Cotter - 2 Disposable Drip Pans - 2 #10-32 x 1/4 inch Steel Screw - 5 Battery Housing - 1 ¼-20 x 1/2 inch Truss Head Screw - 2 #10 Sheet Metal Screw - 3 Right Front Vent Clip - 1 Flat Head Screw - 2 Left Front Vent Clip -
Resumo do conteúdo contido na página número 6
6 ASSEMBLY 1 2 1 2 1 Arrow stickers on Frame Rail (1) and Left Side Panel (2) should point toward each other (shown 3 above). Door Stop Bracket (3) should be positioned as shown (left). 2 ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 7
7 ASSEMBLY 7 3 ATTENTION! Do not fully tighten screws. Clips should slide freely when installed. 4 ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 8
8 ASSEMBLY 5 6 Back ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 9
9 ASSEMBLY 9 7 ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 10
10 ASSEMBLY ® CAUTION: Use two people to lift and install the Summit Built-In frame assembly. A) Lift the frame assembly into the “island” structure opening. Make sure the frame is resting level on the finished surface of the structure. 8 B) Adjust the Front Vent to rest squarely on ground. CLEARANCES 24" (610 mm) Any Surface 1 Grill Frame a Note: For a countertop treatment: Recommended 19.1 mm (3/4˝ b inch) overhang. Notch front edge for frame to fully slide in. ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 11
11 ASSEMBLY 11 9 1/4" (6.35 mm) Drill Bit A) Apply a bead of silicone sealant (1) around the perimeter and front edges of the grill that are in contact with the “island” structure. This A 10 will prevent moisture seepage. The sealant you use must have a temperature rating above 120°F (48.8° C). (1) S-460™ S-660™ ATTENTION! Before applying any silicone sealant make sure the cookbox is flush with the front of the grill frame. ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 12
ASSEMBLY 12 S-460™ 11 3 - 2 1 BATTERY HOUSING WIRING 1 BLACK WIRE 2 GREEN WIRE 4 3 RED WIRE 3 4 RED WIRE WARNING: Make sure that all control knobs are turned to the OFF position before connecting the gas supply and operating the grill. ® WWW.WEBER.COM D
Resumo do conteúdo contido na página número 13
ASSEMBLY 13 Requires 3 “D” alkaline batteries (Included). Use alkaline batteries only. Do not mix old and new batteries or different types 13 of batteries (standard, alkaline or rechargeable). 12 13 Note: Secure wire to side panel. (1) (2) (3) ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 14
14 ASSEMBLY 14 S-460™ S-660™ 15 S-460™ S-660™ 16 ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 15
15 ASSEMBLY S-460™ S-660™ 15 17 A B Match Holder C ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 16
16 ASSEMBLY 18 ATTENTION! Before drilling any holes for the 1/4" (6.35 mm) rear vent make Drill Bit sure the cookbox is flush with the front of the grill frame. ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 17
17 ASSEMBLY S-460™ S-660™ 17 19 20 ™ ™ S-460 S-660 ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 18
18 ASSEMBLY 21 ™ ™ S-460 S-660 S-460™ S-660™ 22 ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 19
ASSEMBLY 19 S-460™ S-660™ 19 23 ® WWW.WEBER.COM
Resumo do conteúdo contido na página número 20
ASSEMBLY 20 ™ S-460 24 ™ S-660 ® WWW.WEBER.COM
