Resumo do conteúdo contido na página número 1
CENTURY®
L E G E N D A R Y L E A D E R S H I P
OWNER'S MANUAL
5130 / 5230
INSTALLATION, OPERATION, MAINTENANCE & PARTS
NOTE: MANUAL including SPECIFICATIONS, subject to change without notice
All ratings specified are based on structural factors only,
not vehicle capacities or capabilities.
CENTURY®
Miller Industries Towing Equipment Inc.
8503 Hilltop Drive
Ooltewah, Tennessee 37363 FORM NO. 0501140
08 / 01
Phone (423) 238-4171 • FAX (423) 238-5371 PRICE $25.00
Resumo do conteúdo contido na página número 2
LIMITED WARRANTY MILLER INDUSTRIES TOWING EQUIPMENT INC., hereinafter referred to as MILLER, warrants to the original purchaser that each new MILLER wrecker or other MILLER products will be free from defects in material and workmanship for a period of twelve (12) months from date placed in service, but in no event shall such warranty period exceed twenty-four (24) months from date of manufacture by MILLER. The purchaser must promptly notify MILLER in writing of any failure in material or workman
Resumo do conteúdo contido na página número 3
Section VI - PARTS This Section is provided by the manufacturer for the purpose of ordering any component part of the CENTURY 5130 or 5230 that may be required when part replacement is necessary. Be certain to use only original equipment replacement parts for warranty purposes as well as for keeping your CENTURY 5130 or 5230 in its original state and optimum operating capacities. When ordering replacement or spare parts be sure to provide the following information to the manufacturer’s Parts De
Resumo do conteúdo contido na página número 4
Section VI - PARTS (cont'd) SUBFRAME ASSEMBLY VI-2
Resumo do conteúdo contido na página número 5
Section VI - PARTS (cont'd) SUBFRAME ASSEMBLY REF. NO. PART NO. REQ'D NUMBER DESCRIPTION 1 6 0300113 GREASE FITTING 2 2 0301861 QUICK PIN 3 2 0302538 BUSHING, 3-1/2" X 2-1/2" INTERNAL 4 8 0302540 CENTER BONDED MOUNT 5 12 0302541 SPECIAL WASHER 6 2 0303140 RAMP PAD 7 2 0303445 SAFETY CHAIN, SYSTEM 10 8 REF. 0306647 SPADE CYLINDER 9 REF. 0307012 LIFT CYLINDER 10 8 0400066 SCREW, 1/4"-20 X 3/4" HEX HD CAP 11 10 0400128 SCREW, 3/8"-16 X 1-1/4" FL HD SKT 12 4 0400139 SCREW, 3/8"-16 X 1-1/2" HEX SKT S
Resumo do conteúdo contido na página número 6
Section VI - PARTS (cont'd) STANDARD BODY ASSEMBLY - 5130 VI-4
Resumo do conteúdo contido na página número 7
Section VI - PARTS (cont'd) STANDARD BODY ASSEMBLY - 5130 REF. NO. PART REF. NO. PART NO. REQ'D NUMBER DESCRIPTION NO. REQ'D NUMBER DESCRIPTION 1 14 FT. 0300345 RUBBER FENDER 32 -- 0904217 BODY MOUNTING HARDWARE (NOT SHOWN) 2 2 0301223 MUDFLAP -- 34 0400288 SCREW, 3/4"-10 X 2-1/2" HEX HD CAP 3 6 0301912 DOOR CHECK, 11" -- 4 0400303 SCREW, 7/8"-9 X 2-1/2" HEX HD CAP 4 7 FT. 0303056 "D" GASKET (NOT SHOWN) -- 34 0400431 NUT, 3/4"-10 NYLOK HEX 5 1 0303061 BACKUP ALARM (NOT SHOWN) -- 4 0400436 NUT,
Resumo do conteúdo contido na página número 8
Section VI - PARTS (cont'd) STANDARD BODY ASSEMBLY - 5230 VI-6
Resumo do conteúdo contido na página número 9
Section VI - PARTS (cont'd) STANDARD BODY ASSEMBLY - 5230 REF. NO. PART REF. NO. PART NO. REQ'D NUMBER DESCRIPTION NO. REQ'D NUMBER DESCRIPTION 1 28 FT. 0300345 RUBBER FENDER 34 -- 0902328 BODY MOUNTING KIT (NOT SHOWN) 2 2 0301223 MUDFLAP -- 2 0707174 ANGLE, TAILGATE MOUNTING 3 6 0301912 DOOR CHECK, 11" -- 2 0707175 MOUNTING PLATE 4 7 FT. 0303056 "D" GASKET (NOT SHOWN) -- 2 0711256 MOUNTING PLATE 5 1 0303061 BACKUP ALARM (NOT SHOWN) -- 2 0711286 SPACER, REAR FRAME BRACKET 6 113 FT. 0306553 DOOR
Resumo do conteúdo contido na página número 10
Section VI - PARTS (cont'd) RECOVERY BOOM ASSEMBLY VI-8
Resumo do conteúdo contido na página número 11
Section VI - PARTS (cont'd) RECOVERY BOOM ASSEMBLY REF. NO. PART NO. REQ'D NUMBER DESCRIPTION 1 4 0300113 GREASE FITTING 2 2 0300626 SHEAVE, 8" 3 3 0301895 GREASE FITTING, STR 1/8" 4 14 FT. 0301949 SYNFLEX HOSE, 3/8" 5 2 0301959 SNAP RING, 1-1/2" INTERNAL 6 2 0303490 WEAR PAD 7 8 0306585 PIPE PLUG, 4 AL PLUG 8 2 0306899 WIRE ROPE, 5/8" X 200' 6x37 IWRC XIPS 9 5 0400121 SCREW, 3/8"-16 X 3/4" HEX HD CAP 10 2 0400132 SCREW, 3/8"-16 X 1-1/2" HEX HD CAP 11 2 0400133 SCREW, 3/8"-16 X 3" HEX HD CAP 12
Resumo do conteúdo contido na página número 12
Section VI - PARTS (cont'd) UNDERLIFT & TOWER ASSEMBLY VI-10
Resumo do conteúdo contido na página número 13
Section VI - PARTS (cont'd) UNDERLIFT & TOWER ASSEMBLY REF. NO. PART REF. NO. PART NO. REQ'D NUMBER DESCRIPTION NO. REQ'D NUMBER DESCRIPTION 1 2 0300110 SNAP RING 1" 29 2 0706995 BOLT-ON SPACER PAD 2 14 0300113 GREASE FITTING 30 1 0706996 SPACER PAD 3 1 0301197 COMPRESSION SPRING, CROSS BAR 31 1 0707028 BOLT-ON BEARING PAD 4 1 0301398 DETENT BALL, 1-3/16" 32 4 0707034 STOP PLATE 5 1 0301822 "O" RING, PIVOT PIN 33 1 0707179 PIN, FOLD CYLINDER ROD END 6 2 0302538 SPRING BUSHING 34 1 0708470 SPACER
Resumo do conteúdo contido na página número 14
Section VI - PARTS (cont'd) UNDERLIFT HYDRAULICS VI-12
Resumo do conteúdo contido na página número 15
Section VI - PARTS (cont'd) UNDERLIFT HYDRAULICS REF. NO. PART NO. REQ'D NUMBER DESCRIPTION 1 7 0300044 CONNECTOR, 6MJ-8MB 2 1 0300142 ELBOW, 6MJ-4MP90 3 1 0300206 BRANCH TEE, 6MJ-6MJ-4MP 4 1 0301425 CONNECTOR, 6MJ-6MP 5 4 0301470 ELBOW, 6MJ-8MP90 6 2 0301473 HOSE ASSEMBLY, 18" 7 3 0301522 CONNECTOR, 6MJ-6MB 8 4 0301601 HOSE CLAMP, INSULATED 5/8" 9 2 0301620 ELBOW, 6MJ-6MB90 10 1 0301730 DOUBLE HOLDING VALVE 11 1 0301731 HOLDING VALVE 12 1 0301837 IN-LINE ORIFICE 13 1 0302000 HOSE ASSEMBLY, 24"
Resumo do conteúdo contido na página número 16
Section VI - PARTS (cont'd) RECOVERY BOOM HYDRAULICS VI-14
Resumo do conteúdo contido na página número 17
Section VI - PARTS (cont'd) RECOVERY BOOM HYDRAULICS REF. NO. PART NO. REQ'D NUMBER DESCRIPTION 1 2 0300044 CONNECTOR, 6MJ-8MB 2 4 0300113 GREASE FITTING 3 2 0301207 HOSE ASSEMBLY, 72" 4 4 0301470 ELBOW, 6MJ-8MB90 5 2 0301522 CONNECTOR, 6MJ-6MB 6 2 0302575 BULKHEAD RUN TEE W/NUT 7 2 0302585 HOSE ASSEMBLY, 54" 8 2 0303017 CONNECTOR, 8MB-6FB 9 1 0303093 CONTROL VALVE, VDP11DDDC110 10 2 0303389 HOSE ASSEMBLY, 46" 11 2 0303394 HOSE ASSEMBLY, 46" 12 2 0307012 CYLINDER, BOOM LIFT 13 2 9013020 CONNECTO
Resumo do conteúdo contido na página número 18
Section VI - PARTS (cont'd) PUMP, VALVE & FILTER HYDRAULICS VI-16
Resumo do conteúdo contido na página número 19
Section VI - PARTS (cont'd) PUMP, VALVE & FILTER HYDRAULICS REF. NO. PART REF. NO. PART NO. REQ'D NUMBER DESCRIPTION NO. REQ'D NUMBER DESCRIPTION 1 2 0301696 ELBOW, 6MJ-6FJX90 35 2 0400382 NUT, 5/16"-18 NYLOK HEX 2 2 0301965 HOSE ASSEMBLY, 131" 36 2 0400384 NUT, 5/16"-24 NYLOK HEX 3 2 0302205 GAUGE, FLUSH MOUNT 6000 PSI 37 12 0400392 NUT, 3/8"-16 NYLOK HEX 4 2 0302577 CONNECTOR, 6MJ-4FP 38 2 0400451 WASHER, 1/4" FLAT 5 2 0303392 HOSE ASSEMBLY, 73" 39 4 0400480 WASHER, 3/8" FLAT 6 1 0303867 PUMP,
Resumo do conteúdo contido na página número 20
Section VI - PARTS (cont'd) WINCH HYDRAULICS & AIR FREE SPOOL VI-18
