Streszczenie treści zawartej na stronie nr. 5
WARNING • This cooker is a high pressure gas appliance for OUTDOOR USE ONLY. • This cooker does not have automatic thermostat controls so must be attended and monitored at all times during use. • If having any doubts or concerns about your ability to use this product call 800-864-6194. • Should you still have concerns about operating this product, then do not use. Contact your dealer for return and refund. • The warnings and safety instructions in this manual MUST be followed to provide reasonab
Streszczenie treści zawartej na stronie nr. 6
WARNING COOKING WITH OIL OR GREASE • This cooker does not have automatic thermostat controls so must be attended and monitored at all times during use. • For frying with this cooker, do not use a cooking vessel larger than 10-quart or smaller than 12 inches diameter. • Follow instructions contained in this manual for proper assembly and positioning of the cooker, gas leak and thermometer test, determining proper amount of oil to use, heat-up and frying operation, cleanup and storage. • When coo
Streszczenie treści zawartej na stronie nr. 7
DANGER IF OIL OR GREASE FIRE OCCURS In the event of an oil/grease fire, do not attempt to extinguish with water. Immediately call your local Fire Department. A Type BC or ABC dry chemical fire extinguisher may in some cases contain the fire. If a fire occurs INSIDE THE COOKING VESSEL follow these steps. • Turn off gas supply. • Wearing a protective glove, cover the pot with a lid. DO NOT re-open lid as the oil/grease fire could re-ignite. Allow cooking vessel to cool down to 115˚F (45˚C) before
Streszczenie treści zawartej na stronie nr. 8
WARNING THERMOMETER & OIL TEMPERATURE • This gas appliance does not have automatic thermostat controls so must be attended and monitored at all times during use. • When cooking with oil or grease, a thermometer MUST be used for reasonable temperature reading. Follow instructions for proper testing, installation and use of a thermometer on pages 18 - 19 in this manual. • Test thermometer before each use. If the thermometer does not function properly, a replacement thermometer must be obtained bef
Streszczenie treści zawartej na stronie nr. 9
WARNING LP GAS CYLINDER • Use only a 20 pound LP Gas Cylinder or smaller with a protective collar. • LP (propane) gas is colorless, tasteless, heavier than air, and is both flammable and explosive. Combustion of propane consumes oxygen and produces carbon monoxide, a poisonous gas. Therefore, never operate an outdoor cooker appliance inside a building or confined area where ventilation may be restricted. Make sure the LP cylinder and the cooker are placed in an open area. DO NOT obstruct the flo
Streszczenie treści zawartej na stronie nr. 10
WARNING GENERAL OPERATING - CONTINUED • Keep children and pets away from the cooking area at all times. Carefully monitor all activity around cooker to avoid burns or other injuries. • This appliance will be hot during and after use. Use insulated oven mitts or gloves for protection from hot surfaces or splatter from cooking liquids. Always wear closed toe shoes while cooking with this appliance. • Use the 10-qt cooking vessel supplied with this appliance for frying with oil/grease. DO NOT use a
Streszczenie treści zawartej na stronie nr. 11
150 100 200 150 100 50 ˚C ˚F 350 ˚C ASSEMBLY INSTRUCTIONS READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING OR OPERATING YOUR COOKER. Inspect contents in the box to ensure all parts are included and undamaged. FOR MISSING PARTS OR ASSISTANCE, PLEASE CALL 1-800-864-6194 M-F 8am - 5pm CST. Proof of purchase will be required. TOOLS REQUIRED: PARTS INCLUDED: 3 - Bolts 1 1/4" 4 - Bolts 3/4" 7 - Locking Nuts 3 - Bolts 3/8” 3 - Nuts 3 - Locking Washers Adjustable Wrench Flath
Streszczenie treści zawartej na stronie nr. 12
LP GAS CYLINDER SPECIFICATIONS DANGER CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you. Never use this appliance in an enclosed space such as a camper, tent, car or home. WARNING LP GAS CYLINDER (NOT SUPPLIED WITH THIS COOKER) The LP (Liquid Propane) gas cylinder specifically designed to be used with this cooker must have a 20 lb (9.1 kg) capacity incorporating a Type-1 cylinder valve and an over-filling protection de
Streszczenie treści zawartej na stronie nr. 13
WARNING • Turn off the cylinder valve when your cooker is not in use. Cylinder Valve • Handle the LP gas cylinder with care. • Always secure the LP gas cylinder in an upright position. • Never connect an unregulated LP gas cylinder to your cooker. • DO NOT expose LP gas cylinders to excessive heat or ignition sources. Store upright with Protective Cap • DO NOT store a spare LP gas cylinder near your cooker. CLOSED Use and store cylinder • Allow only qualified LP gas dealers to fill or rep
Streszczenie treści zawartej na stronie nr. 14
Regulator TYPE-1 Connector REGULATOR HOSE ASSEMBLY Control Knob Coupling Nut Your cooker is equipped with a Type-1 connection device with the following features: 1. The system will not allow gas flow from the cylinder For connection to until a positive connection to the cylinder valve has been made. LP Gas Cylinder NOTE: The cylinder valve must be turned off (clockwise) before any connection is made or removed. Brass Orifice Connector 2. A flow limiting device, when activated, restricts the For
Streszczenie treści zawartej na stronie nr. 15
WARNING Insure the cylinder valve is CLOSED (valve turned clockwise) prior to connecting the LP gas cylinder to your cooker. Turn the regulator control knob counter-clockwise to properly close the regulator valve. Read and follow all instructions and warnings on the supply hose safety tags. Read and follow all warnings in this manual concerning the safe use of LP gas cylinders and the regulator hose assembly, before connecting cylinder to cooker. Read and follow all warnings on the LP gas cyl
Streszczenie treści zawartej na stronie nr. 16
GAS LEAK TEST INSTRUCTIONS Note: The gas leak test must be performed in an area that has adequate lighting in order to see if bubbles are developing. DO NOT use a flashlight to check for bubbbles. 1. Create a mixture of 50% water and 50% liquid dishwashing soap. 2. Turn the gas cylinder valve to the OFF position (clockwise). Then turn regulator control knob to OFF position (counter-clockwise). 3. To turn ON the fuel supply, turn the cylinder valve knob one turn counter-clockwise. Gas will flow t
Streszczenie treści zawartej na stronie nr. 17
PRE-COOKING CHECK LIST WARNING DO NOT operate this cooker until you have read and understand ALL of the warnings and instructions in this manual. Property damage, bodily harm, severe burns and death could result from failure to follow these safety steps. These steps should be performed after the cooker has been assembled, stored, moved, cleaned, or repaired. 1. Insure that the cooker is properly assembled and connected to propane cylinder. 2. Position the cooker on level ground in a well ventil
Streszczenie treści zawartej na stronie nr. 18
O O N F O O F O - O - N P N C F E C O - - F N O U C C - U L V L N C LIGHTING INSTRUCTIONS WARNING DO NOT stand with head, body or arms over the cooker when lighting. Loose clothing and hair can catch fire. Follow the instructions exactly. Read and follow all warnings and instructions in this manual before using your cooker. 1. Make sure the regulator control knob and cylinder valve are in the OFF positions. 2. Turn ON the fuel supply by S-L-O-W-L-Y rotating the cylinder valve counter-clockwise
Streszczenie treści zawartej na stronie nr. 19
O F F - C O O F U F N - T BURNER FLAME CHECK ORANGE Adjust flame height using regulator control knob. Rotate air control shutter BURNER BLUE FLAME to achieve mostly blue flame. The air control shutter mounted on the front of burner helps to control the amount of air that mixes with the LP gas. A blue flame with little or no yellow flame indicates a proper air/gas mixture and provides the best heat. Adjust the air control shutter until CORRECT INCORRECT the desired flame is achieved. NOTE: Make s
Streszczenie treści zawartej na stronie nr. 20
OPERATING INSTRUCTIONS WARNING Read, understand and follow all warnings and instructions contained in this manual. DO NOT skip any of the warnings and instructions contained in the preceding sections of this manual. • Do not use a cooking vessel larger than 10-quart for frying on this cooker. DO NOT use a cooking vessel smaller than 12" diameter on this cooker. • Make sure cooker is positioned at least 10-ft from all combustible materials including building overhangs and tree branches. Follow
Streszczenie treści zawartej na stronie nr. 1
MODEL
#2212
LP GAS COOKER
OWNER’S MANUAL
SAFETY ALERTS, ASSEMBLY & OPERATING INSTRUCTIONS
GENERAL MAINTENANCE & STORAGE
This Instruction Manual contains important information necessary for the proper
assembly and safe use of this appliance. You must carefully read and follow all warnings and
instructions in this manual before assembling and using this appliance.
KEEP THIS MANUAL FOR FUTURE REFERENCE
WARNING
• The maximum size cooking vessel for frying with this cooker using oil/grease is 10-qua
Streszczenie treści zawartej na stronie nr. 2
CONTENTS Warnings & Dangers 1 - 8 Turning off Cooker and Disconnecting Hose 17 Assembly Instructions 9 Operating Instructions 18 LP Gas Cylinder Specifications 10 - 11 Test Your Thermometer and Placement 18 - 19 Regulator Hose Assembly 12 How to Determine Proper Amount of Oil 19 Connecting Regulator Hose Assembly to Cooker 12 Frying Instructions 20 - 21 Connecting Regulator Hose Assembly 13 Cooking Oil: Important Facts to Know 22 to LP Gas Cylinder Trouble Shooting Tips 23 Gas Leak Testing 13 -
Streszczenie treści zawartej na stronie nr. 3
NOTE TO CONSUMER This LP Gas Cooker is a specialized high pressure gas appliance having greater heat output than traditional kitchen stoves. It is referred to as cooker and appliance in this manual and on warning tags. Same as a kitchen stove, this cooker does not have automatic thermostat controls so must be attended and monitored at all times during use. This LP Gas Cooker is for OUTDOOR USE ONLY! Do not use a cooking vessel larger than 10-quart for frying on this cooker. Do no use a cooking
Streszczenie treści zawartej na stronie nr. 4
SAFETY PRECAUTIONS AND WARNINGS WARNING This cooker does not have automatic thermostat controls. Failure to follow these instructions could result in fire or explosion which could cause property damage, personal injury or death! ALWAYS OUTDOOR USE ONLY! NEVER NEVER operate in a open area Do not operate inside use under any LEAVE COOKER a minimum of 10-ft from garages, carports roof or overhang. UNATTENDED! buildings, trees or patios. and overhangs. NEVER NEVER NEVER! NEVER use on decks, boats or
