Streszczenie treści zawartej na stronie nr. 1
Installation and Maintenance
Instructions for Drying
Tumblers
30 Pound (13 Kg) Capacity
JCB30CE, JCB30CG, JCB30CSH, JCB30CSL, JCB30WE, JCB30XG,
SCB30CE, SCB30CG, SCB30CSH, SCB30CSL, SCB30WE and SCB30XG
50 Pound (22 Kg) Capacity
JC50CE, JC50CG, JC50CSH, JC50EG, JCB50CE, JCB50CG, JCB50CSH,
JCB50EG, SC50CE, SC50CG, SC50CSH, SC50EG, SCB50CE, SCB50CG,
SCB50CSH and SCB50EG
75 Pound (34 Kg) Capacity
JC75CE, JC75CG, JC75CSH, JCB75CE, JCB75CG, JCB75CSH, SC75CE,
SC75CG, SC75CSH, SCB75CE, SCB75CG and SCB7
Streszczenie treści zawartej na stronie nr. 2
Streszczenie treści zawartej na stronie nr. 3
WARNINGS AND LABELS aWARNING FAILURE TO INSTALL, MAINTAIN, AND/OR OPERATE THIS MACHINE ACCORDING TO MANUFACTURER’S INSTRUCTIONS MAY RESULT IN CONDITIONS WHICH CAN PRODUCE SERIOUS INJURY, DEATH AND/OR PROPERTY DAMAGE. NOTE: The WARNING and IMPORTANT instructions appearing in this manual are not meant to cover all possible conditions and situations that may occur. It must be understood that common sense, caution and carefulness are factors which CANNOT be built into this tumbler. These factors MUS
Streszczenie treści zawartej na stronie nr. 4
WARNING To reduce the risk of fire, electric shock, serious injury or death to persons when using your dryer, follow these basic precautions: 1. Do not allow children to play on or in the tumbler. Close supervision of children is necessary when the tumbler is used near children. This is a safety rule for all appliances. 2. Before the tumbler is removed from service or discarded, remove the door to the drying compartment. 3. Do not install or store the tumbler where it will be exposed to water a
Streszczenie treści zawartej na stronie nr. 5
TABLE OF CONTENTS NAMEPLATE LOCATION ........................................4 Electrical Requirements: REPLACEMENT PARTS INFORMATION ................4 30 Pound (13 kg) Narrow Cabinet Tumblers ...... 35 30 Pound (13 kg) Tumblers ................................ 36 50 Pound (22 kg) Tumblers ................................ 38 SECTION I 75 Pound (34 kg) Tumblers ................................ 40 ROUGHING-IN DIMENSIONS AND Electrical Connections............................................ 41 SPEC
Streszczenie treści zawartej na stronie nr. 6
NAMEPLATE LOCATION IMPORTANT When writing for information on any tumbler, be sure to mention model and serial numbers. The model and serial numbers will be found on the nameplate as shown on rear of tumbler or underneath the door hinge. T238IE3A IMPORTANT When writing for information on any tumbler, be sure to mention model and serial numbers. The model and serial numbers will be found on the nameplate as shown on the rear of tumbler or underneath the door hinge. T
Streszczenie treści zawartej na stronie nr. 7
SECTION I Roughing-In Dimensions and Specifications 30 Pound (13 kg) Narrow Cabinet Gas Tumbler SIDE PANEL 8.59 cm (3-3/8") 67.95 cm 8.59 cm (26-3/4") (3-3/8") T024IE3B TOP VIEW OF EXHAUST 3.81 cm (1-1/2") 81.76 cm (32-3/16") 113.98 cm (44-7/8") T258IE3A DISCONNECT 15.24 cm (6") SWITCH DIAMETER EXHAUST AIR FLOW SWITCH GAS CONNECTION AND SHUT OFF VALVE CLEARANCES: Minimum ELECTRICAL to nearest Combustible JUNCTION BOX Material Top — 12" (30.5 cm) Minimum. 0" permitted for first 4" (10.2 cm) along
Streszczenie treści zawartej na stronie nr. 8
30 Pound (13 kg) Narrow Cabinet Gas Tumbler Cabinet Finish: Electrostatically applied thermosetting polyester. Cylinder: 26.5" x 30" (67.3 cm x 76.2 cm) perforated galvanized steel with three baffles Motor: ¹⁄₃ H.P., lifetime lubricated, internal overload protected Electrical Requirements: 230 Volt, 50 Hertz, 1 Phase; 5.5 Amps Gas Consumption: 75,000 BTU per hour (79.1 MJ/hr.) Gas Connection: 1/2" (12.7 mm) N.P.T. Types of Gas: Factory equipped with Natural/Mixed Gas (6¹⁄₂ ± 1¹⁄₂ inch water colu
Streszczenie treści zawartej na stronie nr. 9
30 Pound (13 kg) Narrow Cabinet Electric Tumbler SIDE PANEL 8.59 cm (3-3/8") 67.95 cm 8.59 cm (26-3/4") (3-3/8") T024IE3B TOP VIEW OF EXHAUST 3.81 cm (1-1/2") 81.76 cm (32-3/16") 113.98 cm (44-7/8") T258IE3A DISCONNECT SWITCH 15.24 cm (6") ELECTRICAL DIAMETER JUNCTION BOX EXHAUST CLEARANCES: Minimum to nearest Combustible Material Top — 12" (30.5 cm) Minimum. 0" permitted for first 4" (10.2 cm) along front of machine. Back — 0" - 24" (61 cm) AIR FLOW Minimum recommended SWITCH for service acces
Streszczenie treści zawartej na stronie nr. 10
30 Pound (13 kg) Narrow Cabinet Electric Tumbler Cabinet Finish: Electrostatically applied thermosetting polyester. Cylinder: 26.5" x 30" (67.3 cm x 76.2 cm) perforated galvanized steel with three baffles Motor: ¹⁄₃ H.P., lifetime lubricated, internal overload protected Electrical Requirements: 230 Volt, 50 Hertz, 1 Phase; 90 Amps (See nameplate for 230 Volt, 50 Hertz, 3 Phase; 53 Amps voltage of your tumbler) 380 Volt, 50 Hertz, 3 Phase; 33 Amps 415 Volt, 50 Hertz, 3 Phase; 30 Amps Element: 18,
Streszczenie treści zawartej na stronie nr. 11
30 Pound (13 kg) Gas Tumbler CLEARANCES: Minimum to nearest Combustible Material Top — 12" (30.5 cm) Minimum. 0" permitted for first 4" (10.2 cm) along front of machine. Back — 0" - 24" (61 cm) Minimum recommended for service access. Sides — 0" Permitted. 71.5 cm (28-1/4") 3.81 cm 81.75 cm (32-3/16") (1-1/2") 114 cm (44-7/8") DISCONNECT SWITCH 118.6 cm (46-11/16") GAS CONNECTION AND SHUT OFF VALVE AIR FLOW SWITCH (Standard Models) ELECTRICAL 20.3 cm (8") JUNCTION BOX DIAMETER EXHAUST DUCT TH
Streszczenie treści zawartej na stronie nr. 12
30 Pound (13 kg) Gas Tumbler Cabinet Finish: Electrostatically applied thermosetting polyester Cylinder: 30" x 30" (76.2 x 76.2 cm) perforated galvanized steel with three baffles; 30 pounds (13.6 kg) dry weight (cotton load) Motor: ¹⁄₃ H.P., lifetime lubricated, internal overload protected Electrical Requirements: 230 Volt, 50 Hertz, 1 Phase, 5.5 Amp Gas Consumption: Energy Saver Models — 80,000 BTU per hour (84.4 MJ/hr.) Standard Models — 105,000 BTU per hour (110.8 MJ/hr.) Types of Gas: Factor
Streszczenie treści zawartej na stronie nr. 13
30 Pound (13 kg) Electric Tumbler CLEARANCES: Minimum to nearest Combustible Material Top — 12" (30.5 cm) Minimum. 0" permitted for first 4" (10.2 cm) along front of machine. Back — 0" - 24" (61 cm) Minimum recommended for service access. Sides — 0" Permitted. 71.7 cm (28-1/4") 3.81 cm (1-1/2") 81.75 cm (32-3/16") DISCONNECT 114 cm (44-7/8") SWITCH ELECTRICAL JUNCTION BOX 183.5 cm (72-1/2") 11.3 cm (4-7/16") 20.3 cm (8") DIAMETER EXHAUST DUCT THIMBLE CONNECTION 55.6 cm AIR FLOW (21-7/8") SWITC
Streszczenie treści zawartej na stronie nr. 14
30 Pound (13 kg) Electric Tumbler Cabinet Finish: Electrostatically applied thermosetting polyester Cylinder: 30" x 30" (76.2 x 76.2 cm) perforated galvanized steel with three baffles; 30 pounds (13.6 kg) dry weight (cotton load) Motor: ¹⁄₃ H.P., lifetime lubricated, internal overload protected Electrical Requirements: 230 Volt, 50 Hertz, 1 Phase, 90 Amp (see nameplate for voltage 230 Volt, 50 Hertz, 3 Phase, 54 Amp of your tumbler) 380 Volt, 50 Hertz, 3 Phase, 33 Amp 415 Volt, 50 Hertz, 3 Phase
Streszczenie treści zawartej na stronie nr. 15
30 Pound (13 kg) Steam Tumbler CLEARANCES: Minimum to nearest Combustible Material Top — 12" (30.5 cm) Minimum. 0" permitted for first 4" (10.2 cm) along front of machine. Back — 0" - 24" (61 cm) Minimum recommended for service access. Sides — 0" Permitted. 71.75 cm (28-1/4") 3.81 cm (1-1/2") 81.75 cm (32-3/16") 114 cm (44-7/8") (High Pressure Models) 114.4 cm (45-1/32") DISCONNECT (Low Pressure Models) SWITCH 35.6 cm 19.05 cm (7-1/2") (14") 1.9 cm (3/4") I.D. STEAM ELECTRICAL OUTLET JUNCTI
Streszczenie treści zawartej na stronie nr. 16
30 Pound (13 kg) Steam Tumbler Cabinet Finish: Electrostatically applied thermosetting polyester Cylinder: 30" x 30" (76.2 x 76.2 cm) perforated galvanized steel with three baffles; 30 pounds dry weight (13.6 kg) (cotton load) Motor: High Pressure (4 coils) ¹⁄₂ H.P. Low Pressure (4 coils) ³⁄₄ H.P. Boiler Horsepower: 4 coil High Pressure – 3.7 Bhp (123,950 BTU/hr., 58 kg/hr, 31,235 kCal/hr.) 4 coil Low Pressure – 2.6 Bhp (87,100 BTU/hr., 40 kg/hr, 21,949 kCal/hr.) Electrical Requirements: Low Pre
Streszczenie treści zawartej na stronie nr. 17
50 Pound (22 kg) Gas Non-reversing Tumblers CLEARANCES: Minimum to nearest Combustible Material Top — 12" (30.5 cm) Minimum. 0" permitted for first 4" (10.2 cm) along front of machine. Back — 0" - 24" (61 cm) Minimum recommended for service access. Sides — 0" Permitted. 71.75 cm (28-1/4") 3.81 cm (1-1/2") 81.75 cm (32-3/16") 119.4 cm (47") DISCONNECT GAS CONNECTION SWITCH AND SHUT OFF VALVE AIR FLOW SWITCH (Standard Models) 20.3 cm (8") DIAMETER EXHAUST DUCT THIMBLE CONNECTION (Energy Saver
Streszczenie treści zawartej na stronie nr. 18
50 Pound (22 kg) Gas Tumblers Cabinet Finish: Electrostatically applied thermosetting polyester Cylinder: 37" x 30" (94 cm x 76.2 cm) perforated galvanized steel with four baffles; 50 pounds (22.7 kg) dry weight (cotton load) Motor: 1/2 H.P., lifetime lubricated, internal overload protected (Nonreversing Models) (See below for reversing models.) Electrical Requirements: 230 Volt, 50 Hertz, 1 Phase, 6.0 Amp Non-Reversing Models Electrical Requirements: 230 Volt, 50 Hertz, 1 Phase, 8.0 Amp Revers
Streszczenie treści zawartej na stronie nr. 19
50 Pound (22 kg) Gas and Steam Reversing Tumblers ELECTRICAL DISCONNECT JUNCTION BOX SWITCH CYLINDER MOTOR 20.3 cm (8") DIAMETER EXHAUST THIMBLE CONNECTOR (Energy Saver Gas Models) 194.6 cm (76-5/8") 146.4 cm (57-5/8") 20.3 cm (8") DIAMETER EXHAUST THIMBLE CONNECTION AIRFLOW SWITCH 34 cm (13-3/8") 13.65 cm (5-3/8") FAN MOTOR 98.1 cm (38-5/8") T264IE3B M412616 17
Streszczenie treści zawartej na stronie nr. 20
50 Pound (22 kg) Electric Non-reversing Tumblers CLEARANCES: Minimum to nearest Combustible Material Top — 12" (30.5 cm) Minimum. 0" permitted for first 4" (10.2 cm) along front of machine. Back — 0" - 24" (61 cm) Minimum recommended for service access. Sides — 0" Permitted. 71.75 cm (28-1/4") 3.81 cm (1-1/2") 81.75 cm (32-3/16") DISCONNECT 119.4 cm (47") SWITCH ELECTRICAL JUNCTION BOX 20.3 cm (8") DIAMETER EXHAUST DUCT THIMBLE CONNECTION 13.65 cm (5-3/8") AIR FLOW SWITCH 98.1 cm (38-5/8")
