Streszczenie treści zawartej na stronie nr. 1
YCE FSVlOO and FSV200 Series
6 G
eneral Purpose Solenoid Valves
@
m
I
8
m
I
@
fx
8
a
03
fx
@
m
I
03
fx
@
m
03
m
I
03
m
I
@
fx
I
8
fx
I
@
a
fl OMEGg
Operator’ s Manual
h An OMEGA Technologies Compsny
Streszczenie treści zawartej na stronie nr. 2
Servicing USA and Canada: Call OMEGA Toll Free Canada USA One Omega Drive, Box 4047 976 Bergar Lava1 (Quebec) H7L 5Al Stamford, CT 06907-0047 Telephone: (514) 856-6928 Telephone: (203) 359-1660 FAX: (514) 856-6886 FAX: (203) 359-7700 Sales Service: l-800-826-6342 / l-800-TC-OMEGASM Customer Service: l-800-622-2378 / l-800-622-BESTSM Engineering Service: l-800-872-9436 / l-800-USA-WHENSM TELEX: 996404 EASYLINK: 62968934 CABLE OMEGA Servicing Europe: United Kingdom Sales and Distribution Center 25
Streszczenie treści zawartej na stronie nr. 3
Table of Contents FSVIOO I FSV200 Series General Purpose Solenoid Valve Page 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Chapter 1 Introduction 1 1 . 1 Unpack ing .................................................................................................................. 1 1.2 Desc ri p ti on ......................
Streszczenie treści zawartej na stronie nr. 4
Notes
Streszczenie treści zawartej na stronie nr. 5
Chapter 1 Introduction 1 .l Unpacking Remove the Packing List and verify that you have received all equipment, including the follow- ing (quantities in parentheses): General Purpose Solenoid Valve (1) Operators Manual (1) ’ If you have any questions about the shipment, please call OMEGA Customer Service Depart- ment. When you receive the shipment, inspect the container and equipment for signs of dam- age. Note any evidence of rough handling in transit. Immediately report any damage to the shippi
Streszczenie treści zawartej na stronie nr. 6
1.3 Features The FSVlOOlFSV200 solenoid valves have the following features: ??2-way Normally Closed ?? Pilot-Operated ??Piston-Type ??Bronze Construction ??Variety of Voltages ??Maximum Temperature of 195°F ??Maximum Pressure 150 PSI 1.4 Available Models OMEGA Engineering, Inc. has the following models with the following characteristics: FSVI 00 Series for Water Description Part Number * FSVI 01 Solenoid Valve with BUNA N/EPDM Seal and 318” NPT Connector FSV102 Solenoid Valve with BUNA N/EPDM Se
Streszczenie treści zawartej na stronie nr. 7
FSV200 Series for Light Oils and Solvents DescriDtion Part Number * FSV201 Solenoid Valve with Viton Seal and 3/8” NPT Connector FSV202 Solenoid Valve with Viton Seal and 112 ” NPT Connector FSV203 Solenoid Valve with Viton Seal and 3/4” NPT Connector FSV204 Solenoid Valve with Viton Seal and 1 .O” NPT Connector FSV205 Solenoid Valve with Viton Seal and 1.25 ” NPT Connector FSV206 Solenoid Valve with Viton Seal and 1.50 ” NPT Connector FSV207 Solenoid Valve with Viton Seal and 2.00 ” NPT Connect
Streszczenie treści zawartej na stronie nr. 8
Solenoid Valve Chapter 2 Parts of the FSVlOO/200 Series PLUNGER ASSEMBLY PISTON SPRING SPLtT RING (TEFLON, PISTON BODY SEAT WASHER NUT Figure 2-1. 310”, l/2”, 314” NPT SOLENOID SPRING WAS HER --SOLENOID BONNET BOHET G PLUNGER ASSEMBLY PISTON SPRING SPLIT RING (TEFLON) -PISTON BODY Figure 2-2. I”, I%“, lYz”, 2” NPT Chapter 3 Installation Be sure to adhere to the following when installing your solenoid valve: Arrow on valve body indicates direction of flow. Apply wrench only on end of valve bein
Streszczenie treści zawartej na stronie nr. 9
Chapter 4 Troubleshooting Guide Problem Possible Cause Corrective Action Failure to open when 1. Low voltage at solenoid Insure proper voltage at (below 85% of rated solenoid solenoid engergized voltage) Check for excessive Solenoid failure 2. voltage at solenoid Replace split rings 3. Worn rings 4. Pressure drop less Increase pressure differential to 5 PSI than 5 PSI Install new bonnet 5. Bonnet bent 6. Should have approx- Trim as required imately 1 /I 6” gap in split piston rings. Remove pisto
Streszczenie treści zawartej na stronie nr. 10
Chapter 5 Spare Parts List Coil with l/2” NPT Conduit outlet and 30” lead wires. Fits all valve sizes. Consult Factory for other voltages and coils with ground wire. 3/8”*1/2”*3/&1”~1 W’*l x”92” NPT Connector Stvles FSVI 00 7319503 7319503 7319503 7319503 73026 83192 83192 83192 N/A 82224 82224 82224 Teflon Split Piston Ring 1 85Oi9Oi (2 Req’ d) , Piston Seat Washer 8249801 84048 84571 84518 8222301 Piston Seat Washer Nut 1 8222 2 86030 76745 76750 7673801 FSVZOO I Same Parts as FSVIOO Except Fo
Streszczenie treści zawartej na stronie nr. 11
Chapter 6 Specifications FSVI OO/FSVZOO Series IT---- f’k I I i-t I 0 0 ri F r-- C --- + Figure 6-2. 1”, 1?4”, I%“, CL 2” Figure 6-i. 3/W ’, 112”, 8 314” FSVlOO: For fluids compatible with bronze, 430 F Stainless Steel, Ethylene Propylene, and Teflon 'I l-114" l-112" 2" pe i P Size 318” l/2" 314” 1 r otCv c Fa 3. 2 3. 3 5. 7 8. 9 15 28 39 si Th . 60 F t op a r e d r essu r p I PS h a 1 it w ve l he va t ough r ht ow ill flwt ha r tet wa f o t ounm The a r) ot c v Fa C : (et No r of d be used l
Streszczenie treści zawartej na stronie nr. 12
Specifications (con?) Flow Capacity Charts 450 100 90 400 80 350 70 300 E E 6o k 250 g 5 0 .E 20 0 175 .E 4 0 3 0 15 0 h. 30 E 125 IA 100 20 ;i 10 5 :8 0 0- 5 10 20 30 40 60 80 100 125 150 5 IO 20 30 40 60 SO 100 125 150 Pressure Drop Across the Valve in PSI Pressure Drop Across the Valve in PSI Figure 64. l”, I%“, I%“, 2” NPT Figure 6-3. 3/W’, l/2”, 314” NPT * Valves require minimum 5 PSI pressure differential for reliable operation. * Must be installed in horizontal piping with solenoid in ver
Streszczenie treści zawartej na stronie nr. 13
Notes
Streszczenie treści zawartej na stronie nr. 14
WARRANTY OMEGA warrants this unit to be free of defects in materials and workmanship and to give satisfac- tory service for a period of 13 months from date of purchase. OMEGA Warranty adds an addition- al one (1) month grace period to the normal one (1) year product warranty to cover handling and shipping time. This ensures that OMEGA ’ s customers receive maximum coverage on each product. If the unit should malfunction, it must be returned to the factory for evaluation. OMEGA ’ s Customer Serv
Streszczenie treści zawartej na stronie nr. 15
Where Do I Find Everything I Need for Process Measurement and Control? OMEGA...Of Course! TEMPERATURE Thermocouple, RTD & Thermistor Probes, Connectors, Panels & Assemblies D Wire: Thermocouple, RTD & Thermistor a I Calibrators & Ice Point References Recorders, Controllers & Process Monitors E Infrared Pyrometers a l PRESSURE/STRAIN FORCE B Transducers & Strain Gages m Load Cells & Pressure Gauges m Displacement Transducers @ Instrumentation & Accessories FLOW/ LEVEL m Rotameters, Gas Mass Flowm
Streszczenie treści zawartej na stronie nr. 16
