Streszczenie treści zawartej na stronie nr. 1
GTO 14001
1 CHANNEL POWER AMPLIFIER
SERVICE MANUAL
JBL Consumer Products
250 Crossways Park Dr.
Woodbury, New York 11797 Rev0 3/2008
Released 2008
Discontinued XXXX
Streszczenie treści zawartej na stronie nr. 2
GTO14001 - CONTENTS - SPECIFICATIONS ………………………………………..1 PACKING……………………………………………..…....2 CONTROL/INSTALLATION DRAWINGS………………3 CONTROL/INSTALLATION INSTRUCTIONS………....4 BASIC TROUBLESHOOTING……………………………5 EXPLODED VIEW/PARTS LIST…….….….…………....6 AMPLIFIER BLOCK DIAGRAM…………………….……7 ELECTRICAL PARTS LIST ..……….……….…….…….8 P.C.B. DRAWINGS….………………………..…….……13 IC/TRANSISTOR PINOUTS..………………..….….…..20 SCHEMATICS……………..……………….………..…...21 GTO 14001 Spe
Streszczenie treści zawartej na stronie nr. 3
GTO14001 2
Streszczenie treści zawartej na stronie nr. 4
GTO14001 4x 2x 1x 1x 4x 1x 10-3/8" 263mm 18-9/16" 02 1 470mm 2-1/8" 53mm D 34 9A 8 1" 25mm 56 7 AB C B 1-5/8" AB C D 40mm A 8 3
Streszczenie treści zawartej na stronie nr. 5
GTO14001 GTO14001 CAR AUDIO SUBWOOFER AMPLIFIER OWNER’S MANUAL 0 7 Installation Warnings and Tips Speaker Output Connectors DBO (Dynamic Bass Optimization) Variable • Disconnect the negative (–) lead from your vehicle’s • Connect the speakers to these terminals, Subsonic High-Pass Filter With Variable Boost (Q) battery. observing proper polarity. Either + or – • For woofers in tuned (vented) enclosures, set terminal may be used. Minimum total the Frequency control to
Streszczenie treści zawartej na stronie nr. 6
GTO14001 Amplifier Troubleshooting Guide 1. Status LED on Amplifier not Lit - Head Unit (Source) Turned ON Verify: A. Remote turn-on wire from source to amplifier has proper voltage B. Power (B+) connections at amplifier, terminal blocks, and battery are secure C. Ground (GND) connections at amplifier and vehicle chassis are secure D. Battery B+ fuse (if used) is OK E. Amplifier fuse is OK F. B+ at battery and B+ at amplifier has proper voltage 2. St
Streszczenie treści zawartej na stronie nr. 7
GTO14001 Trans. Clamp Trans. Clamp Trans. Clamp RCA CAP (Red) RCA CAP (Wht) Front Plate Standoff 6
Streszczenie treści zawartej na stronie nr. 8
GTO14001 BALANCED INPUT UNIT Block Diagram GTO14001 INPUT L 1 OP 2 LP FREQ BASSBOOST VARIABLE VARIABLE MAIN AMP 32Hz-320Hz/12dB 0dB-12dB/50Hz 2 ohm/4 ohm GAIN CONTROL OUTPUT L 32 80 320Hz 32 50 320Hz OP OP AMP OUTPUT R OP SPEAKER INPUT R 1 OP 2 2 ohm/4 ohm BALANCED INPUT UNIT OP IMS INPUT 7 UnRegistered
Streszczenie treści zawartej na stronie nr. 9
GTO14001 GTO14001 Electrical Parts List Qty Part Number Reference Designator Description MAIN PCB Resistors 1 0702-3103-02 R95 Carbon film resistor 1/2W 10K Ω ±5% 12.5MM 5 0702-3220-02 R85 R86 R87 R88 R89 Carbon film resistor 1/2W 22 Ω ±5% 12.5MM 2 0702-4123-02 R100 R101 Carbon film resistor 1W 12K ±5% 15mm 2 0705-5470-02 R1 R133 Cement resistor 5W 47 Ω ±5% 2 0712-64R7-02 R128 R129 Metal Oxide film resistor 2W 4.7 Ω ±5% Horizontal 10MM 2 0712-6221-02 R123 R124 Metal
Streszczenie treści zawartej na stronie nr. 10
GTO14001 Qty Part Number Reference Designator Description MAIN PCB 6 06D231047000 C31 C32 C33 C37 C74 C75 Ceramic cap 0.1uF/100V ±20% 5MM 3 06D3C2247700 C100 C101 C102 Metal film cap 224/100V ±5% Brown 5MM 2 06D374717400 C64 C65 Ta capacitor 470pF/100V ±5% 5.5mm 3 06D1C4747701 C48 C85 C94 C93 Metal film cap 474/100V ±10% Brown 7.5mm 1 06D1C105G700CX11 Metal film cap 105/160V ±10% Brown 15MM thickness ≤6.5MM 1 06D341547400 C44 MET CAP 154/100V ±5% 5MM 1 06D341847000
Streszczenie treści zawartej na stronie nr. 11
GTO14001 Qty Part Number Reference Designator Description CONTROL PCB NOTE THERE ARE TWO IDENTICAL CONTROL PCB'S IN THE GTO14001 Resistors 1 0701-2104-02 R64 Resistor SMD 100K Ω 1/8W ±5% 0805 4 0701-2103-02 R3 R33 R30 R31 Resistor SMD 10K Ω 1/8W ±5% 0805 4 0701-2100-02 R117 R118 R193 R198 Resistor SMD 10 Ω 1/8W ±5% 0805 2 0701-2102-02 R55 R58 Resistor SMD 1K Ω 1/8W ±5% 0805 2 0701-2222-02 R105 R106 Resistor SMD 2.2K Ω 1/8W ±5% 0805 1 0701-2153-02 R2 Resistor SMD 15K
Streszczenie treści zawartej na stronie nr. 12
GTO14001 Qty Part Number Reference Designator Description PWM PCB 1 0701-2333-02 2R98 Resistor SMD 33K Ω 1/8W ±5% 0805 2R3 2R4 2R19 2R20 2R44 2R97 7 0701-2473-02 Resistor SMD 47K Ω 1/8W ±5% 0805 2R145 1 0701-2623-02 2R2 Resistor SMD 62K Ω 1/8W ±5% 0805 1 0701-2753-02 2R103 Resistor SMD 75K ±5% 1/8W 0805 1 0701-2104-02 2R154 Resistor SMD 100K Ω 1/8W ±5% 0805 Capacitors 1 06S121026000 2C143 Capacitor SMD 1000pF/50V 0805 X7R ±10% 2C1 2C22 2C34 2C79 2C80 2C81 12 06S121
Streszczenie treści zawartej na stronie nr. 13
GTO14001 Qty Part Number Reference Designator Description MISCELLANEOUS/MECHANICAL Screw, BM4*14Black zinc 16 LS1JM0401401 For power transistor plating Screw, BT3*12Black zinc 4 LS1JT0301201 For PCB board plating Screw, BT3*10Black zinc 1 LS1JT0301001 For RCA terminal plating 4 ZL-10038A-15 Standoff φ4.9*φ7.2*7.0mm Nylon 66 5 DQ8069032084 Washer Φ6.9*Φ3.2*0.8MM M3, For Logo house PCB board 1 JY264A22A01X MICA 64*22*0.1MM Ф4.5MM 16.5MM 7MM 1 PL-E0011-150 Light d
Streszczenie treści zawartej na stronie nr. 14
GTO14001 13
Streszczenie treści zawartej na stronie nr. 15
GTO14001 14
Streszczenie treści zawartej na stronie nr. 16
GTO14001 15
Streszczenie treści zawartej na stronie nr. 17
GTO14001 16
Streszczenie treści zawartej na stronie nr. 18
GTO14001 17
Streszczenie treści zawartej na stronie nr. 19
GTO14001 18
Streszczenie treści zawartej na stronie nr. 20
GTO14001 19
