Streszczenie treści zawartej na stronie nr. 1
Part Number: 92P1836
Important
This publication contains product-specific parts
information for IBM ThinkPad Dock, ThinkPad Dock
II, ThinkPad Port Replicator, ThinkPad Mini Dock,
and ThinkPad Port Replicator II products.
This publication is intended for trained service
personnel who are familiar with ThinkPad products.
Before servicing an IBM ThinkPad products, be sure
to review the safety information on the hardware
maintenance manual of the ThinkPad computer.
FRU replacement notices
This secti
Streszczenie treści zawartej na stronie nr. 2
Tighten screws as follows: v Plastic to plastic Turn an additional 90 degrees after the screw head touches the surface of the plastic part: 90 degrees more (Cross-section) v Logic card to plastic Turn an additional 180 degrees after the screw head touches the surface of the logic card: 180 degrees more (Cross-section) v Torque driver If you have a torque driver, refer to the “Torque” column for each step. v Make sure you use the correct screw. If you have a torque screwdriver, tighten all screws
Streszczenie treści zawartej na stronie nr. 3
Removing and replacing a FRU This section presents directions and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before replacing any FRU, review “FRU replacement notices” on page 1. 3. Begin by removing any FRUs that have to be removed before the failing FRU. Any such FRUs are listed at the top of the page. R
Streszczenie treści zawartej na stronie nr. 4
1010 ThinkPad Dock PCI cover Before replacing the PCI cover: There are two types of ThinkPad Dock, as follows: v ThinkPad Dock: FRU no. 08N1546 (PCI cover: FRU no. 05K6246) v ThinkPad Dock with extension plate: FRU no. 08N1537 (PCI cover: FRU no. 08N7317) Confirm the FRU no. of the ThinkPad Dock first and choose the proper PCI cover FRU for the ThinkPad Dock you are servicing. 4
Streszczenie treści zawartej na stronie nr. 5
Note: The following illustration shows how to remove the PCI cover of ThinkPad Dock (FRU no. 08N1546). Do the same to remove the PCI cover of ThinkPad Dock with extension plate (FRU no. 08N1537). 1 1 2 (Bottom view) 5
Streszczenie treści zawartej na stronie nr. 6
1020 ThinkPad Dock top cover Note This section is only for the ThinkPad Dock (FRU no. 08N1546). The top cover and screw kit for ThinkPad Dock (FRU no. 12P4143) is not available for the ThinkPad Dock with extension plate (FRU no. 08N1537) . 1 (Rear view) Step Screw (quantity) Torque 1 M2.5 × 4.8 mm (2) 0.392 Nm (4 kgfcm) (continued) 6
Streszczenie treści zawartej na stronie nr. 7
2 2 2 (Bottom view) Step Screw (quantity) Torque 2 M2.5 × 4.8 mm (8) 0.392 Nm (4 kgfcm) (continued) 7
Streszczenie treści zawartej na stronie nr. 8
Make sure that the system lock key A is set to the Unlock position. Release the front latches in step 3, and then remove the top cover 4. For step 5, see the inside view, shown in the circle. 5 4 3 A When replacing the top cover, do the following: v Make sure that the springs are placed correctly. (continued) 8
Streszczenie treści zawartej na stronie nr. 9
v Make sure that the device release lever is seated correctly. v Make sure that the release button works correctly. 9
Streszczenie treści zawartej na stronie nr. 10
2010 ThinkPad Dock II PCI cover 1 1 2 (Bottom view) 10
Streszczenie treści zawartej na stronie nr. 11
2020 ThinkPad Dock II top cover 1 1 1 (Rear view) Step Screw (quantity) Torque 1 M2.5 × 4.8 mm (3) 0.392 Nm (4 kgfcm) 2 2 2 2 Step Screw (quantity) Torque 2 M2.5 × 4.8 mm (4) 0.392 Nm (4 kgfcm) (continued) 11
Streszczenie treści zawartej na stronie nr. 12
3 3 (Bottom view) Step Screw (quantity) Torque 3 M2.5 × 4.8 mm (6) 0.392 Nm (4 kgfcm) (continued) 12
Streszczenie treści zawartej na stronie nr. 13
Make sure that the system lock key A is set to the Unlock position. Release the front latches in step 4, and then remove the top cover 5. Then detach the connector cable 6 as in the figure. 5 A 4 6 13
Streszczenie treści zawartej na stronie nr. 14
Parts list FRU P/N CRU ID ThinkPad Dock 08N1546 N ThinkPad Dock with extension plate 08N1537 N ThinkPad Dock II 67P9010 * ThinkPad Mini Dock 67P9011 * ThinkPad Port Replicator 08N1536 N ThinkPad Port Replicator II 74P6735 * Optional FRUs FRU P/N CRU ID PCI cover for ThinkPad Dock 05K6246 N Top cover and screw kit for ThinkPad Dock 12P4143 N PCI cover for ThinkPad Dock with extension 08N7317 N plate Top cover and screw kit for ThinkPad Dock II 46P3085 ** PCI cover for ThinkPad Dock II 46P3086 * A
Streszczenie treści zawartej na stronie nr. 15
Power cords (ThinkPad Dock and ThinkPad Dock II) IBM power cords for a specific country or region are usually available only in that country or region: For 3-pin power cords: Region P/N CRU ID Argentina 36L8868 * Australia, New Zealand 75H8988 Brazil 49P2101 Canada, Thailand, U.S. 75H8989 Denmark 75H8992 European countries 75H8990 India, South Africa 75H8993 Israel 75H8999 Italy 75H8998 Japan 75H8996 Korea 76H3536 China (P.R.C.) (other than Hong Kong S.A.R) 02K0540 Switzerland 75H8997 U.K. 75H89
Streszczenie treści zawartej na stronie nr. 16
Power cords (ThinkPad Mini Dock) IBM power cords for a specific country or region are usually available only in that country or region: For 2-pin power cords: Region P/N CRU ID Canada, U.S. 13H5264 * Japan 13H5273 Argentina 36L8870 Brazil 49P2095 For 3-pin power cords: Region P/N CRU ID Australia, New Zealand 76H3514 * Taiwan, Thailand 76H3516 Italy 76H3530 Denmark 76H3520 U.K., China (Hong Kong S.A.R.) 76H3524 European countries 76H3518 India, South Africa 76H3522 Israel 76H3532 Korea 76H3535 C
