Streszczenie treści zawartej na stronie nr. 1
Dell Latitude C610/C510 Service Manual
Dell™ Latitude™ C610/C510 Service Manual
Before You Begin
System Components
Hard Drive
Memory Modules, Mini PCI Card, and Modem
Keyboard
Display Assembly, Display Latch, and Hinge Covers
Palm Rest
Microprocessor Thermal Cooling Assembly
Microprocessor Module
Hybrid Cooling Fan
Reserve Battery
Flashing the BIOS
Speaker Assemblies
System Board
Battery and Module Bay Latches
Pin Assignments for I/O Connectors
Notes, Notices, and Cautions
NOTE: A NOTE indicates
Streszczenie treści zawartej na stronie nr. 2
Before You Begin: Dell Latitude C610/C510 Service Manual Back to Contents Page Before You Begin Dell™ Latitude™ C610/C510 Service Manual Preparing to Work Inside the Computer Recommended Tools Screw Identification Preparing to Work Inside the Computer CAUTION: Before working inside your computer, read "Safety and EMC Instructions: Portable Computers" in your System Information Guide. NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicin
Streszczenie treści zawartej na stronie nr. 3
Before You Begin: Dell Latitude C610/C510 Service Manual The procedures in this manual require the following tools: #1 magnetized Phillips screwdriver ¼-inch flat-blade screwdriver Small plastic scribe Microprocessor extractor Flash BIOS update program floppy disk or CD Computer Orientation 1 back 2 right 3 front 4 left Screw Identification When you are removing and replacing components, photocopy the placemat as a tool to lay out and keep track of the screws. The placemat provides the number of
Streszczenie treści zawartej na stronie nr. 4
Before You Begin: Dell Latitude C610/C510 Service Manual NOTICE: When reinstalling a screw, you must use a screw of the correct diameter and length. Make sure that the screw is properly aligned with its corresponding hole, and avoid over tightening. Keyboard to Hard Drive Door: Bottom Case: (1 each) (5 each) Display Bezel: Hinge Bracket to Bottom Case: (6 each) (5 each) Rubber Screw Covers (6 each) Display Assembly to Top Cover: Display-Feed Flex Cable: (5 each) (4 each) Palm Rest to Hybrid Cool
Streszczenie treści zawartej na stronie nr. 5
Before You Begin: Dell Latitude C610/C510 Service Manual System Board to Bottom Case: Modem to System Board: (10 each) (2 each) Display Latch: Memory Module Cover: (2 each) (2 each) (2 captive screws) (1 each) NOTE: The single screw is one of the five keyboard screws. Back to Contents Page file:///C|/Work%20Area%20-%20A/E%20DOC%20Posting/latc610/service%20manual/begin.htm[2/1/2013 11:00:42 AM]
Streszczenie treści zawartej na stronie nr. 6
System Components: Dell Latitude C610/C510 Service Manual Back to Contents Page System Components Dell™ Latitude™ C610/C510 Service Manual Exploded View NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. NOTICE: Unless otherwise noted, each procedure in this manual assumes that a part can be replaced by performing the removal procedure in reverse order. 1 display assembly 10
Streszczenie treści zawartej na stronie nr. 7
System Components: Dell Latitude C610/C510 Service Manual 9 fan guard Back to Contents Page file:///C|/Work%20Area%20-%20A/E%20DOC%20Posting/latc610/service%20manual/system.htm[2/1/2013 11:00:43 AM]
Streszczenie treści zawartej na stronie nr. 8
Hard Drive: Dell Latitude C610/C510 Service Manual Back to Contents Page Hard Drive Dell™ Latitude™ C610/C510 Service Manual Removing the Hard Drive Replacing the Hard Drive Removing the Hard Drive 1. Save and close any open files, exit any open programs, and shut down the computer. NOTICE: Disconnect the computer and any attached devices from electrical outlets, and remove any installed batteries. NOTICE: The hard drive is very sensitive to shock. Handle the hard drive by its edges (do not
Streszczenie treści zawartej na stronie nr. 9
Hard Drive: Dell Latitude C610/C510 Service Manual 4. Lift up the hard drive door until you hear a click. 5. Slide the hard drive out of the computer. Replacing the Hard Drive NOTICE: Use firm and even pressure to slide the hard drive into place. If you force the hard drive into place using excessive force, you may damage the connector. 1. Lift up the hard drive door until you hear a click. Push the hard drive into the drive bay until it is fully seated in the bay. 2. Press the hard drive doo
Streszczenie treści zawartej na stronie nr. 10
Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Service Manual Back to Contents Page Memory Modules, Mini PCI Card, and Modem Dell™ Latitude™ C610/C510 Service Manual Memory Modules Mini PCI Card Modem Memory Modules Removing the Memory Module Cover NOTICE: Disconnect the computer and any attached devices from electrical outlets, and remove any installed batteries. NOTICE: To avoid ESD, ground yourself by using a wrist grounding strap or by touching an unpainted metal sur
Streszczenie treści zawartej na stronie nr. 11
Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Service Manual Removing the Memory Modules NOTICE: Disconnect the computer and any attached devices from electrical outlets, and remove any installed batteries. NOTICE: To avoid ESD, ground yourself by using a wrist grounding strap or by touching an unpainted metal surface on the computer. NOTICE: Read "Preparing to Work Inside the Computer" before performing the following procedure. 1. Remove the memory module cover. NOTICE: To
Streszczenie treści zawartej na stronie nr. 12
Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Service Manual 1. If you only have one memory module, install it in the connector labeled "JDIM1" on the system board. Install a second memory module in the connector labeled "JDIM2." NOTE: Memory modules are keyed, or designed to fit into their sockets, in only one direction. NOTICE: The memory module must be inserted at a 45-degree angle to avoid damaging the connector. 2. Align the notch in the memory module with the slot in t
Streszczenie treści zawartej na stronie nr. 13
Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Service Manual 1 antenna connectors on card (2) 2 antenna cables (2) Replacing the Mini PCI Card 1. Align the Mini PCI card with the socket at a 45-degree angle, and press the Mini PCI card into the socket. NOTICE: The connectors are keyed for correct insertion; do not force the connections. 2. Lower the Mini PCI card toward the inner tabs to approximately a 20-degree angle. 3. Continue lowering the Mini PCI card until it snaps
Streszczenie treści zawartej na stronie nr. 14
Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Service Manual NOTICE: Do not pull on the modem cable. Pull from the modem connector to disconnect the cable. 3. Pull straight up on the attached pull tab to lift the modem out of its connector on the system board and disconnect the modem cable. Modem Removal 1 M2 x 3-mm screws (2) 2 modem connector 3 modem cable 4 pull tab Replacing the Modem 1. Connect the modem cable to the modem. NOTICE: The connectors are keyed for correct
Streszczenie treści zawartej na stronie nr. 15
Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Service Manual file:///C|/Work%20Area%20-%20A/E%20DOC%20Posting/latc610/service%20manual/upgrades.htm[2/1/2013 11:00:44 AM]
Streszczenie treści zawartej na stronie nr. 16
Keyboard: Dell Latitude C610/C510 Service Manual Back to Contents Page Keyboard Dell™ Latitude™ C610/C510 Service Manual Removing the Keyboard Replacing the Keyboard Removing the Keyboard NOTICE: Disconnect the computer and any attached devices from electrical outlets, and remove any installed batteries. NOTICE: To avoid ESD, ground yourself by using a wrist grounding strap or by touching an unpainted metal surface on the computer. NOTICE: Read "Preparing to Work Inside the Computer" before
Streszczenie treści zawartej na stronie nr. 17
Keyboard: Dell Latitude C610/C510 Service Manual b. Lift the center control cover up and away from the bottom case. Center Control Cover Removal 5. To release the keyboard from the palm rest, use a small, flat-blade screwdriver or plastic scribe to pull up on the scalloped edge of the blank key on the keyboard. Keyboard Removal 1 keyboard 2 track stick 3 scalloped edge of blank key 4 palm rest 6. Lift the keyboard straight up until it clears the keyboard boss support in the bottom case. file:
Streszczenie treści zawartej na stronie nr. 18
Keyboard: Dell Latitude C610/C510 Service Manual 7. Rotate the keyboard forward toward the front of the computer. 8. Rest the key face of the keyboard on the palm rest. NOTICE: Do not pull on the keyboard flex and track stick cables. 9. Pull up on the keyboard connector to disconnect it from the interface connector on the system board. Keyboard Connector Removal 1 boss support (5) 2 track stick cable 3 keyboard flex cable 4 keyboard connector 5 orientation label 10. Remove the keyboard from t
Streszczenie treści zawartej na stronie nr. 19
Keyboard: Dell Latitude C610/C510 Service Manual snap the right side of the keyboard into place. NOTICE: Position the keyboard flex and track stick cables so that they are not pinched when you replace the keyboard in the bottom case. 4. Check that the keyboard is correctly installed. The keys should be flush with the left and right surfaces of the palm rest. 5. Replace the center control cover, close the display assembly, and turn the computer over. 6. Reinstall the five M2.5 x 12-mm screws i
Streszczenie treści zawartej na stronie nr. 20
Display Assembly, Display Latch, and Hinge Covers: Dell Latitude C610/C510 Service Manual Back to Contents Page Display Assembly, Display Latch, and Hinge Covers Dell™ Latitude™ C610/C510 Service Manual Display Assembly Display Latch Hinge Covers Display Assembly NOTICE: You must remove the display assembly before you remove the palm rest. NOTICE: Disconnect the computer and any attached devices from electrical outlets, and remove any installed batteries. NOTICE: To avoid ESD, ground yours
