Streszczenie treści zawartej na stronie nr. 1
Gas Grill
Built-In LP Gas Grill Installation Guide
t ank Enclosure installation - Pg 27
™
s-460
™
s-660
#43267
YoU mUSt rEad thiS ownEr’S gUidE
m warning: follow all leak-check
bEforE oPErating YoUr gaS griLL. procedures carefully in this manual prior
to barbecue operation. do this even if the
barbecue was dealer-assembled.
m dangEr
if you smell gas:
notiCE to inStaLLEr: these instructions
1. Shut off gas to the appliance.
must be left with the owner and the owner
2. Extinguish any open
Streszczenie treści zawartej na stronie nr. 2
warninGs 2 m Keep any electrical supply cord and the fuel supply hose m dangEr away from any heated surfaces. f ailure to follow the dangers, warnings and Cautions ® m do not use this weber tank enclosure kit unless all contained in this o wner’s manual may result in serious parts are in place. the unit must be properly assembled bodily injury or death, or in a fire or an explosion causing according to the instructions outlined in the “a ssembly damage to property. instruction” section o
Streszczenie treści zawartej na stronie nr. 3
3 BUilT-in CUTOUT DiMEnsiOns “iSLand” S tr UCtUrE ConfigUration oPtionS 2 3 There are many available options for locating the major components of your Island structure.Your major components are: A 1) The Built in Grill 2) Gas supply enclosure 3) Optional Side burner accessory 3 The 3 common options (A, B, C) are illustrated in the “Island Structure Configuration 1 Options” table. note: Gas line limitation The gas supply hose from grill manifold to gas supply bulkhead must not exceed 58" (1
Streszczenie treści zawartej na stronie nr. 4
BUilT-in CUTOUT DiMEnsiOns 4 bUiLt-in S tr UCtUrE CUtoUt dimEnSionS BUilT-in CUTOUT DiMEnsiOns aLL dimEnSionS arE to finiShEd SUrfa CES. S-460™ S-660™ t oLEranCES m warning: all countertop finished surfaces must be 1 1 1 1 1 30 / " (768.35 mm) 38 / " (971.55 mm) + / " - / " (6.35mm) 4 4 4 4 constructed of a noncombustible material. 3 3 1 1 2 34 / " (873.13 mm) 34 / " (873.13 mm) + / " - / " (6.35mm) 8 8 4 4 1 1 3 23" (584.2 mm) 23" (584.2 mm) + / " - / " (6.35mm) 4 4 1 d 1 1 1 4 2 2 5
Streszczenie treści zawartej na stronie nr. 5
ParTs lisT 5 ™ s-460 5 Lid - 1 Left door - 1 Cookbox - 1 right door - 1 warming rack - 1 oR ™ s-660 Lid - 1 right Enclosure Panel - 1 Cookbox - 1 Left Enclosure Panel - 1 f ront f rame rail - 1 f ront Vent Panel - 1 r ear f rame rail - 1 r ear Panel a ssembly - 1 r ear Vent - 1 bottom Shelf - 1 Corrugated gas Line - 1 ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 6
6 ParTs lisT ® flavorizer bars Smoker bar - 1 ™ - 8 s-460 ™ - 12 s-660 1/2 inch bolts (¼-20 x 1/2 inch bolt) - 10 Stainless Steel Cooking grates ™ - 2 s-460 ™ - 3 s-660 nylon washer - 10 Collection t ray - 1 hinge Pin - 2 Catch-Pan holder - 1 hair Pin Cotter - 2 #10-24 x 1 inch Steel Screw - 2 Catch-Pan - 1 Locking washer - 2 disposable drip Pans - 2 #10-32 x 1/4 inch Steel Screw - 5 battery housing - 1 ¼-20 x 1/2 inch t russ head Screw - 2 right f ront Vent Clip - 1 #10 Sheet metal Screw - 3 L
Streszczenie treści zawartej na stronie nr. 7
assEMBlY 7 7 1 door Stop bracket (a) should be positioned as shown. A m attEntion! do not attach rear support screws and washers until Step #6. 2 ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 8
assEMBlY 8 3 m attEntion! do not fully tighten screws. Clips should slide freely when installed. 4 ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 9
assEMBlY 9 9 5 6 back ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 10
assEMBlY 10 7 ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 11
assEMBlY 11 ® m CaUtion: Use two people to lift and install the Summit built-in frame assembly. 11 a) Lift the frame assembly into the “island” structure opening. Make sure the frame is resting level on the finished surface of the structure. 8 b) Adjust the Front Vent to rest squarely on ground. 1 1 1 b A a 1 1 1 a B ClEaranCEs 24" (610 mm) Any Surface 1 Grill Frame a Note: For a countertop treatment: Recommended 19.1 mm (3/4˝ inch) over- b hang. Notch front edge for frame to fully slide in.
Streszczenie treści zawartej na stronie nr. 12
assEMBlY 12 9 1 / " (6.35 mm) 4 drill bit 10 S-460™ S-660™ ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 13
assEMBlY 13 13 11 a) Apply a bead of silicone sealant (1) around the perimeter and front edges of the grill that are in contact with the “island” structure. This will prevent A moisture seepage. The sealant you use must have a temperature rating above 120°F (48.8° C). 1 m attEntion! before applying any silicone sealant make sure the cookbox is flush with the front of the grill frame. ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 14
assEMBlY 14 S-660™ S-460™ 12 3 - 2 1 2 1 4 BaTTErY hOUsinG wirinG 1 BLACK WIRE 3 2 GREEN WIRE 4 3 RED WIRE 3 4 RED WIRE m warning: make sure that all control knobs are turned to the off position before connecting the gas supply and operating the grill. ® www.wEBEr.COM d
Streszczenie treści zawartej na stronie nr. 15
assEMBlY 15 Requires 3 “D” alkaline batteries (included). Use alkaline batteries only. Do not mix old and new batteries or different types 15 of batteries (standard, alkaline or rechargeable). 13 14 note: Secure wire to side panel. (1) (2) (3) ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 16
assEMBlY 16 15 1 2 3 16 S-460™ S-660™ 17 2 1 ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 17
assEMBlY 17 17 S-460™ S-660™ 18 A B match holder C ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 18
assEMBlY 18 19 m attEntion! before drilling any holes for the 1 / " (6.35 mm) 4 rear vent make drill bit sure the cookbox is flush with the front of the grill frame. ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 19
assEMBlY 19 s-460™ s-660™ 19 20 21 ™ ™ s-460 s-660 ® www.wEBEr.COM
Streszczenie treści zawartej na stronie nr. 20
assEMBlY 20 22 ™ ™ s-460 s-660 s-460™ s-660™ 23 ® www.wEBEr.COM
