Streszczenie treści zawartej na stronie nr. 1
G GAS GRILL AS GRILL
LP Gas Grill Own LP Gas Grill Owne er’ r’s s Guid Guide e
E/S-310/320, EP-310/320
#89708
#00000
WARNING: Follow all leak-check
YOU MUST READ THIS OWNER’S GUIDE
procedures carefully in this manual
BEFORE OPERATING YOUR GAS GRILL
before operating barbecue. Do this even if
barbecue was dealer assembled.
DANGER
If you smell gas:
®
WARNING: Do not try to light the Weber
1. Shut off gas to the appliance.
gas barbecue without fi rst reading the
2. Extinguish any open
Streszczenie treści zawartej na stronie nr. 2
2 W WARNINGS ARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. WARNINGS Follow regulator connection instructions for your type of gas grill. Do not store a spare or disconnected gas supply cylinder under or near this barbecue. Do not put a barbecue cover or anything fl ammable on or in the storage area under the barbecue. Improper a
Streszczenie treści zawartej na stronie nr. 3
3 W WARNINGS ARNINGS ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber This Limited Warranty does not cover any failures or operating diffi culties due to accident, abuse, gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or 3 service, or failure to perform normal and routine maintenance, including but n
Streszczenie treści zawartej na stronie nr. 4
4 EXPLODED VIEW E/S/EP 310 ® WWW.WEBER.COM
Streszczenie treści zawartej na stronie nr. 5
EXPLODED VIEW LIST E/S/EP 310 5 1. Shroud Hardware 27. Igniter Module 5 2. Thermometer 28. Right Side Table ® 3. Thermometer Bezel 29. Flavorizer Bar 4. Shroud 30. Rear Burner Tube 5. Handle 31. Middle Burner Tube 6. Warming Rack 32. Front Burner Tube 7. Left Side Table 33. Back Panel 8. Cooking Grates 34. Manifold 9. Crossover Tube 35. Hose / Regulator 10. Cookbox 36. Right Frame Panel 11. Left Frame Panel 37. Cylinder Bracket 12. Frame Support 38. Tank Glides 13. Left Trim Piece 39. Drip Tray
Streszczenie treści zawartej na stronie nr. 6
6 EXPLODED VIEW E/S/EP 320 ® WWW.WEBER.COM
Streszczenie treści zawartej na stronie nr. 7
EXPLODED VIEW LIST E/S/EP 320 7 1. Shroud Hardware 30. Right Side Table 7 ® 2. Thermometer 31. Flavorizer Bar 3. Thermometer Bezel 32. Rear Burner Tube 4. Shroud 33. Middle Burner Tube 5. Handle 34. Front Burner Tube 6. Warming Rack 35. Back Panel 7. Side Burner Table 36. Manifold 8. Side Burner Lid 37. Hose / Regulator 9. Cooking Grates 38. Right Frame Panel 10. Side Burner 39. Manifold Hose 11. Crossover Tube 40. Cylinder Bracket 12. Cookbox 41. Tank Glides 13. Left Frame Panel 42. Drip Tray 1
Streszczenie treści zawartej na stronie nr. 8
8 GENERAL INSTRUCTIONS • Gas supply cylinders must be stored outdoors in a well-ventilated area out of GENERAL INSTRUCTIONS reach of children. Disconnected gas supply cylinders must not be stored in a Your Weber Gas Barbecue is a portable outdoor cooking appliance. With the Weber building, garage or any other enclosed area. Gas Barbecue you can grill, barbecue, roast and bake with results that are diffi cult to ® duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars pro
Streszczenie treści zawartej na stronie nr. 9
9 GENERAL INSTRUCTIONS Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, Preserve Your Stainless Steel GENERAL INSTRUCTIONS then rinse. Your grill or its cabinet, lid, control panel and shelves may be made from stainless steel. 9 To keep the stainless steel looking its best is a simple matter. Clean it with soap and ® Flavorizer bars and Cooking grates - Clean with a suitable brass bristle brush. As water, rinse with clear water and wipe dry. For stubborn particle
Streszczenie treści zawartej na stronie nr. 10
10 GAS INSTRUCTIONS CONNECTING THE LIQUID PROPANE CYLINDER A1 A2 WARNING: Make sure that the LP cylinder valve is closed. Close by turning valve clockwise. DANGER Do not use an open fl ame to check for gas leaks. Be sure a) there are no sparks or open fl ames in the area while you check for leaks. Sparks or fl ames will result in a fi re or explosion that can cause serious bodily injury or death, and damage to property. B1 B2 You will need: LP cylinder, a soap-and-water solution and a rag o
Streszczenie treści zawartej na stronie nr. 11
GAS INSTRUCTIONS 11 CHECK FOR GAS LEAKS 11 DANGER 310 Do not use an open fl ame to check for gas leaks. Be sure there are no sparks or open fl ames in the area while you check for leaks. Sparks or open fl ames will result in a fi re or explosion, which can cause serious bodily injury or death *The grill illustrated may and damage to property. have slight differences to the model purchased. WARNING: You should check for gas leaks every time you disconnect and reconnect a gas fi tting. Note:
Streszczenie treści zawartej na stronie nr. 12
12 GAS INSTRUCTIONS Check: GAS INSTRUCTIONS 1) Hose-to-manifold connection. 320 2) Side burner hose-to-manifold connection and side burner hose-to-side burner gas line connection. 3) Side burner hose-to-side burner connection, side burner valve and orifi ce connections. WARNING: If there is a leak at connection (1, 2, or 3), retighten the fi tting with a spanner and recheck for leaks with soap-and-water solution. If a leak persists after re- tightening the fi tting, turn OFF the gas. DO NOT
Streszczenie treści zawartej na stronie nr. 13
13 GAS INSTRUCTIONS REFILLING THE LIQUID PROPANE CYLINDER GAS INSTRUCTIONS We recommend that you refi ll the LP cylinder before it is completely empty. 13 To refi ll, take LP cylinder to a “Gas Propane” dealer. A Removal of the gas supply cylinder 1) Shut off gas supply. 2) Disconnect hose with regulator from the cylinder. A) Unscrew regulator fi tting from tank turning clockwise. B) Move regulator lever (b) to down/off position. Push in regulator lever (b) until it releases from tank. a) C) Move
Streszczenie treści zawartej na stronie nr. 14
14 OPERATING INSTRUCTIONS MAIN BURNER LIGHTING MAIN BURNER LIGHTING 1) Open the lid. 2) Make sure all burner control knobs are turned OFF. (Push control knob down and 5 2 turn clockwise to ensure that it is in the OFF position.) WARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank valve. 4 3) Turn the cylinder on by slowly turning the cylinder valve counter-clockwise. WARNING: Do not lean over the open barbecue. Keep your 1 fac
Streszczenie treści zawartej na stronie nr. 15
OPERATING INSTRUCTIONS 15 LIGHTING THE SIDE BURNER 15 DANGER Failure to open the lid while igniting the side burner, or not 320 waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive fl ame-up, which can cause serious bodily injury or death. WARNING: Check hose each time before using barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be 1 damaged in any way, do not use the barbecue. Replace using 2 ® only Weber aut
Streszczenie treści zawartej na stronie nr. 16
16 TROUBLESHOOTING PROBLEM CHECK SOLUTION Burners burn with a yellow or orange fl ame, in Inspect Spider / Insect Screens for possible obstructions Clean Spider / Insect Screens. conjunction with the smell of gas. (blockage of holes.) (See Section “Annual Maintenance”) Some countries have regulators with an excess gas The excess fl ow safety device, which is part of the To reset the excess fl ow safety device, turn all burner control fl ow safety device. barbecue to cylinder connection, may have a
Streszczenie treści zawartej na stronie nr. 17
MAINTENANCE 17 SIDE BURNER MAINTENANCE 17 (3) WARNING: All gas controls and supply valves should be in the “OFF” position. Make sure black wire is connected between the igniter and electrode. Make sure white wire is connected between the igniter and grounding clip. (1) Spark should be a white/blue color, not yellow. (2) 1) Igniter Wire 2) Ground wire 3) Burner Side Burner Grate Side Burner cap Side Burner Ring & Head Igniter Electrode (1) (2) Control Knob Igniter ® WEBER SPIDER /INSECT SCREEN
Streszczenie treści zawartej na stronie nr. 18
18 MAINTENANCE ANNUAL MAINTENANCE Inspection and cleaning of the Spider/Insect Screens To inspect the Spider/Insect Screens, remove the control panel. If there is dust or dirt on the screens, remove the burners for cleaning the screens. Brush the Spider/Insect Screens lightly with a soft bristle brush (i.e. an old toothbrush). CAUTION: Do not clean the Spider/Insect Screens with hard or sharp tools. Do not dislodge the Spider/Insect Screens or enlarge the screen openings. Lightly tap the bu
Streszczenie treści zawartej na stronie nr. 19
MAINTENANCE 19 4) Loosen the two nuts (a) that hold the manifold to the cooking box. Pull the manifold and valve assembly out of the burners (b) and carefully set it down. 19 a b 5) Slide the burner assembly out from under the guide screw and washer (a) in the a corners of the cooking box. 6) Lift and twist the burner assembly slightly, to separate the crossover tube (b) from the burners. Remove the burners from the cooking box. 7) To reinstall the burners, reverse 3) to 7). CAUTION: The bu
Streszczenie treści zawartej na stronie nr. 20
ATTENTION: This product has been safety tested and is only certifi ed for use in a specifi c country. Refer to country designation located on outside of box. These parts may be gas-carrying or gas-burning components. Please contact Weber-Stephen Products Co., Customer Service Department for genuine Weber- Stephen Products Co. replacement part(s) information. WARNING: Do not attempt to make any repair to gas-carrying or gas-burning components without contacting Weber-Stephen Products Co. Cus
