Summary of the content on the page No. 1
CSIG 404
Operating
and
Installation Instructions
Summary of the content on the page No. 2
n CS I G 4 0 4 o i t c u Introduction d o r This gas appliance has been designed and manufactured to all the t n necessary British Standards. It also carries the C.E. mark. The I appliance complies with European Council Directive 90/396/EEC. It is important that you understand how to use and care for the appliance properly before you use it for the first time. We have written this booklet with your safety in mind. Read the booklet thoroughly before you use the appliance. Keep the booklet in a
Summary of the content on the page No. 3
C S I G 4 0 4 Contents Page Lighting the appliance 4 The grill 6 The hotplate 9 The oven 12 Oven cooking chart 15 Slow cooking 18 Care and cleaning 20 Installing the appliance 25 General information 27 What is wrong and why? 29 Servicing 30 Installation Instructions 32 Technical Data 33 Safety requirements/ventilation 34 Location of appliance 35 Installation 36 Testing 37 3 Contents
Summary of the content on the page No. 4
C S I G 4 0 4 Lighting the appliance The ignition system works by means of a battery. Details on how to replace the battery are given on page 27. Hotplate & Grill To light 1. Lift up the lid. You cannot use the hotplate when the lid is down. 2. Push in the control knob and turn it to the large flame symbol (highest setting), and press the ignition button immediately. When the burner has lit release the button 3. Leave the grill door open when you are using the grill. Warning: If the igniti
Summary of the content on the page No. 5
C S I G 4 0 4 The oven To light: 1 Open the oven door. 2 Push in the control knob and turn it to gas mark 9. 3 Now turn the control knob back to the gas mark you want. 4 Wait until the burner is showing large flames. 5 Close the oven door. To turn off any burner 1 Push in the control knob and turn it to the off position. This is shown by a large dot. For your safety When you are lighting any burner check that it has lit before you leave the appliance. When you are turning off a burner, do
Summary of the content on the page No. 6
C S I G 4 0 4 The grill The grill is a high-speed grill. The instructions below tell you how to vary the heat setting and how to change the height of the grid to suit the food you are cooking. You should remember to turn the food regularly. You should not use the grill to keep food warm as it will continue to cook the food. Prior to using the grill We suggest that you operate the grill for approximately 5 - 10 mins to burn off any residue from the surface. During this period a slight odour m
Summary of the content on the page No. 7
C S I G 4 0 4 Cooking positions There is only one position for the grill shelf (Position 2). Positions are counted from the top downwards. Most food should be cooked on the grid in the grill pan. You can turn the grid over to suit different thicknesses of food. You can place some dishes straight on to the grill shelf. This is useful when you are browning the top of food such as cauliflower cheese. Preheating You don't usually need to preheat the grill. You may wish to preheat it for a coupl
Summary of the content on the page No. 8
CS I G 4 0 4 The grill pan and handle The grill pan is supplied with a removable handle. To attach the handle, place the wirework under the cut out in the pan so that the metal plate hooks over the top of the grill pan. Slide the handle to the left and over the central bump on the grill pan. Ensure the handle is correctly located. It is not necessary to remove the grill pan handle during grilling. Place the grill pan on the shelf so that the pan is positioned centrally beneath the grill. To
Summary of the content on the page No. 9
CS I G 4 0 4 The hotplate You can only use the hotplate when the lid is open. If you have any trouble lighting a hotplate burner turn all hotplate control knobs off and make sure the hotplate burner parts have been replaced correctly. See page 21 for more information. Heat control The hotplate control knobs turn anticlockwise from 'OFF' to 'HIGH' and then to 'LOW'. You can adjust the heat by turning the control between the highest and lowest settings. These are shown as a large and a small fl
Summary of the content on the page No. 10
CS I G 4 0 4 For your safety Take care to avoid burns and scalds when you 1 are reaching across the hotplate. Use pans with flat bases. They are more stable than pans which are warped. Do not use pans with very heavy handles which cause the pan to tip. Put pans on the centre of the burners. Position pan handles so they cannot be accidentally knocked. Take extra care when you are deep fat frying. Do not cover the pan with a lid. Do not leave a pan unattended. If the pan catches fire, leave it
Summary of the content on the page No. 11
CS I G 4 0 4 Helpful hints 1 Keep flames under the base of pans. If the flames lick round the sides of the pans you are wasting gas. 2 Only heat the amount of liquid you need. Do not overfill pans. 3 Cover pans with a lid whenever possible. The food will heat up more quickly and there will be less steam in the kitchen. 4 Try cooking more than one vegetable in the same pan, for example potatoes and carrots. 5 Cut vegetables into smaller pieces. This way they will cook more quickly. 6 A pres
Summary of the content on the page No. 12
CS I G 4 0 4 The oven Before you use the oven you should wipe it out with a damp cloth to remove any dust. Heat zones There are zones of heat within the oven. The temperature in the middle is the gas mark you have chosen. The top of the oven is slightly hotter and the lower shelf slightly cooler. The base of the oven is quite a lot cooler. You can make use of these heat zones when you are cooking foods that need different temperatures all at the same time. If you are cooking more than one t
Summary of the content on the page No. 13
CS I G 4 0 4 Baking trays and dishes For your safety Never place cooking dishes, trays and so on over the oven burners. This will damage the appliance as well as the cookware and possibly the floor covering underneath the appliance. Leave a gap of 13mm (½") between all Leave a gap of 13mm (½") between all dishes and the sides of the oven so the dishes and the sides of the oven so the heat can circulate properly. heat can circulate properly. Do not push dishes too far back as food
Summary of the content on the page No. 14
CS I G 4 0 4 Condensation Condensation may form on the appliance. This is quite normal and nothing to worry about. The condensation forms when heat and moisture are present, for example during cooking. Whenever possible try to make sure that food which contains a lot of moisture, for example casseroles, are covered. If you do notice any condensation, wipe it up straight away. 14 The oven
Summary of the content on the page No. 15
CS I G 404 15 Oven cooking chart These instructions are for cooking in the oven after it has been pre-heated for 20 minutes. If you are cooking more than one tray of similar items, for example cakes or biscuits, swap the trays around during cooking or you can take the top tray out of the oven when the food is cooked and move the lower tray to the higher shelf to finish cooking. Always leave at least one shelf position between shelves to allow heat to circulate. The recommended shelf positi
Summary of the content on the page No. 16
CS I G 404 16 Oven cooking chart Gas Shelf Approximate Food mark position cooking time Poultry: Chicken 5 4 20 mins. per ½kg (1lb) and 20 mins. Turkey below 4.5kg (10lbs) 4 4 25 mins. per ½kg (1lb) and 25 mins. over 4.5kg (10lbs) 4 4 or 5 15 mins. per ½kg (1lb) and 15 mins. Duck and duckling 5 4 25 mins. per ½kg (1lb) Stuffed poultry Cook as above
Summary of the content on the page No. 17
CS I G 404 17 Gas Shelf Approximate Food mark position cooking time Pastries: Plate tart (shortcrust) 6 2 25 - 35 mins. Fruit pie (shortcrust) 6 2 25 - 35 mins. Mince pies (flan pastry) 5 2 & 4 15 - 25 mins. To help pastry brown on the underside cook on a metal plate,or if plates are flat and have no rim underneath,place on baking tray. Puddings: Milk pudding 2 3 2 hrs. approx. Baked sponge pudding 4 4 45 -
Summary of the content on the page No. 18
C S I G 4 0 4 Slow cooking The slow cook setting gives a very low heat in the oven. It is particularly useful when you are cooking soups, stews and casseroles because the long slow cooking will make cheaper, tougher cuts of meat more tender. You need to cook food at gas mark 6 for 30 minutes before you turn the oven down to the slow cook setting. This makes sure that the temperature of the food gets hot enough to start the food cooking. Mark 6 Turn to S Some foods such as pastry and bisc
Summary of the content on the page No. 19
C S I G 4 0 4 Soups, casseroles and stews l Do not cook casseroles over 2.7kg (6lb). l Bring to the boil on the hotplate then cook on slow cook. l Cook in the middle of the oven or above. l Cover food with a tight fitting lid or tin foil. Vegetables l Cut into small pieces. l Dried beans must be pre-soaked then boiled in an open pan for 15 minutes before adding to any dish. l Place vegetables under meat in casseroles. l Cover food with a tight fitting lid or tin foil. l Cook for 30 minutes
Summary of the content on the page No. 20
C S I G 4 0 4 Care and cleaning For your safety For hygiene and safety reasons you must keep this gas appliance clean. A build up of fat or other foodstuff could cause a fire. Try to mop up spills and splashes as soon as they happen. But be careful as parts of the appliance will be hot. Do not use any polishes, caustic cleaners, abrasives, washing soda or soap powder except those recommended in this booklet. Please note: If we recommend you use hot soapy water we mean hot water with washing up
