Summary of the content on the page No. 1
Installation Instructions
Distinctive Series Cooktop
Models DCT305, DCT365
Part No. 106927 Rev. E
Summary of the content on the page No. 2
Table of Contents Important Safety Instructions .......................................... 1 Installation Instructions .................................................... 7 Important Information About Safety Instructions .............. 1 Verify Package Contents .................................................. 7 General Safety Precautions ............................................. 2 Installing the Cooktop ...................................................... 7 Installation Specifications .
Summary of the content on the page No. 3
Important Safety Instructions Important Information About WARNING TO REDUCE THE RISK OF INJURY TO PERSONS IN Safety Instructions THE EVENT OF A RANGE TOP GREASE FIRE: • The Important Safety Instructions and warnings in a. SMOTHER FLAMES with a close-fitting lid, cookie these instructions are not meant to cover all possible sheet or metal tray, then turn off the burner. BE problems and conditions that can occur. Use common CAREFUL TO PREVENT BURNS. If the flames do sense and caution wh
Summary of the content on the page No. 4
Important Safety Instructions General Safety Precautions To reduce the risk of fire, electric shock, serious injury or death when using this appliance, follow basic safety precautions, including the following: WARNING WARNING • Read the accompanying use and care manual com- • Do not leave children alone or unattended in the area pletely before operating this appliance. around the cooktop. Do not allow children to play with the controls or touch other parts of the cooktop. • Keep packag
Summary of the content on the page No. 5
Installation Specifications WARNING Observe all governing codes and ordinances during planning and installation. Contact your local building department for further information. Product Specifications All tolerances ±1/16” (±1.6 mm) unless otherwise noted. A 2" (5.1 cm) countertop to cooking surface 4" (10.2 cm) chassis height 21" Model (A) (B) (53.3 cm) DCT305 30” (76.2 cm) 27 5/16” (69.4 cm) DCT365 36” (91.4 cm) 33 5/16” (57.8 cm) Rear Front overhang overhang ” 17/32” 1 3/16 1 11/32” 1 11/
Summary of the content on the page No. 6
Installation Specifications Electrical Requirements Gas Supply Requirements • Be certain that the cooktop being installed is correct for WARNING the gas service being provided (natural gas or LP gas). Also, if operating the cooktop at an altitude above 4000 To prevent an electric shock hazard, the power supply ft. (1219 m) make sure it is equipped for high altitude must meet the specifications stated below. It is the own- operation. er’s responsibility to make sure that the electrical se
Summary of the content on the page No. 7
Installation Specifications • Allow a minimum 1/4” (6 mm) clearance between the Cabinet and Countertop Layout bottom of the cooktop chassis and all combustible sur- faces, including the upper edge of a drawer installed below the cooktop. WARNING • Failure to meet or exceed the maximum and minimum dimensions/clearances stated in these instructions may result in a fire hazard. • Follow the countertop manufacturer’s instructions regarding the minimum corner radius, use of heat 1/4” (6 mm)
Summary of the content on the page No. 8
Installation Specifications All tolerances +1/16” -0 (+1.6 mm, 0) unless otherwise noted. Cutout Dimensions Rear wall Vertical combustible surface 4 1/4” (10.8 cm) min. F from mounting surface to combustibles below cooktop chassis C E D F Minimum distance to combustible side 1 5/8” min. wall above countertop (both sides) (4.1 cm) Countertop Cutout Dimensions Installation Type (C) Minimum (D) (E) (F) Minimum DCT305* 3 1/4” (8.3 cm) 19 5/8” (49.9 cm) 27 5/8” (85.4 cm) 6 7/8” (17.5 cm) DCT365 wi
Summary of the content on the page No. 9
Installation Instructions Verify Package Contents Connecting the Gas Line • Hold down brackets (2) WARNING • Grates (3) • Verify that the gas supply meets specifications before • Burner sets (5) connection. See page 4. • Gas pressure regulator with 3/4” to 1/2” reducer • Do not install the cooktop without also installing the • Stainless steel cleaner included gas regulator. Do not use the cooktop without the regulator installed. Installing the Cooktop • Ensure that the arrow on the
Summary of the content on the page No. 10
Installation Instructions Installing the Burner Components WARNING • Never attempt to operate the cooktop with any of the Inner burner cap burner parts removed. (bottom shown) • Do not attempt to adjust the burner air mixture set- tings. All adjustments are preset at the factory. Outer burner cap 1. Remove the burner rings, burner caps and grates from their shipping packages. 2. Assemble the burners as shown. Match the burner parts to the correct size and type of burner. When Burner rin
Summary of the content on the page No. 11
Installation Instructions IMPORTANT: Install the grates as instructed below for longest life. When installed properly, the openings in the grates are centered over the burners. 3. Locate the notch on the bottom of each grate. 4. Use the notch on the bottom of each grate to determine location and orientation. See diagram below. The notch on the bottom of each grate goes towards the back of the cooktop. The notches on the left and right grates go toward the outside. 5. Gently lower the legs
Summary of the content on the page No. 12
Installation Instructions NOTE: If the cooktop does not operate properly, follow Verifying Proper Operation these troubleshooting steps: • Verify that power and gas are supplied to the cooktop. WARNING • Check to make sure that the power plug is connected • Make sure that power to the electrical outlet is turned to the electrical outlet and that power is turned on at off at the circuit breaker panel or fuse box and that the the circuit breaker panel or fuse box. gas is turned off at th
Summary of the content on the page No. 13
Installation Instructions Installation Checklist WARNING • To ensure a safe and proper installation, the follow- ing checklist should be completed by the installer to ensure that no part of the installation has been over- looked. • Proper installation is the responsibility of the home- owner. The importance of proper installation of your Dacor cooktop cannot be overemphasized. □ Is the electrical outlet for the cooktop grounded and located according to these instructions and in accor- dan
Summary of the content on the page No. 14
Wiring Diagram WARNING Label all wires prior to dis-connection when servicing Verify proper operation controls. Wiring errors can cause improper and after servicing dangerous operation. 120 Vac, 60 Hz. power supply Wiring Diagram - DCT305/DCT365 12
Summary of the content on the page No. 15
Summary of the content on the page No. 16
Dacor ● 600 Anton Blvd. Suite 1000 Costa Mesa, CA 92626 ● Phone: (800) 793-0093 ● Fax: (626) 403-3130 ● www .dacor .com
