Summary of the content on the page No. 1
Regal Intensive Care Unit
Controlled Environment
Temperature Controlled Air Flow
Filtered, Re-circulated Oxygen Supply
Built-in Heating/Cooling Systems
New Model Number: 12019-01-NGFREP
SSCI
Wheeling, IL 800 323 7366
Form No. 702718 Rev. A 03/05
Owner’s Manual
Summary of the content on the page No. 2
WARNING: Oxygen is a highly combustible gas. Avoid the use of open flames, smoking materials, or equipment capable of producing sparks in any area in which oxygen is being used. © Copyright 2005 by Suburban Surgical Co., Inc. All rights reserved. No part of this document may be reproduced or utilized in any form or by any means, electronic or mechanical, including photocopying, recording, or by any information storage and retrieval system without written permission. Inquiries should be addresse
Summary of the content on the page No. 3
Owner’s Manual - Regal Intensive Care Unit Table of Contents Chapter 1 - General Information ........................................1 Introduction ......................................................................................................... 1 About this Manual................................................................................................ 1 Information and Safety Notices ........................................................................... 2 Notes .............
Summary of the content on the page No. 4
Table of Contents 13 - Oxygen On/Off Rocker Switch & System Light ..................................................... 15 14 - Alarm On/Off Rocker Switch & System Light ........................................................ 15 15 - Heat On/Off Rocker Switch & System Light .......................................................... 16 16 - Cooling On/Off Rocker Switch & System Light ..................................................... 16 17, 18 - Left & Right Floor Temperature Controls .......
Summary of the content on the page No. 5
Owner’s Manual - Regal Intensive Care Unit Chapter 3 - Installation & Setup.......................................33 Unpacking and Inspection ................................................................................. 33 Parts Included.................................................................................................... 33 Installation and Setup ......................................................................................... 34 Overview ..............................
Summary of the content on the page No. 6
Table of Contents Controlling Oxygen Pressure ......................................................................................... 56 Controlling Oxygen Flow Rate ...................................................................................... 56 Accessing the Electronics Compartment ........................................................................ 57 Accessing the Filter/Fans Compartment ......................................................................... 58 Setting the A
Summary of the content on the page No. 7
Owner’s Manual - Regal Intensive Care Unit Latch Connector Holder ............................................................................................... 78 Tool Required............................................................................................. 78 Removal ..................................................................................................... 78 Installation ..................................................................................................
Summary of the content on the page No. 8
Table of Contents Circuit Breaker ............................................................................................................. 98 Tool Required............................................................................................. 98 Removal ..................................................................................................... 98 Installation .................................................................................................. 98 On/Off Rocker S
Summary of the content on the page No. 9
Owner’s Manual - Regal Intensive Care Unit Oxygen Flow Meter ................................................................................................... 120 Tools and Supplies Required ..................................................................... 120 Removal ................................................................................................... 120 Dis-Assembly ........................................................................................... 121 Re-assembly
Summary of the content on the page No. 10
Table of Contents Chapter 6 - Troubleshooting ..........................................137 General ............................................................................................................. 137 Returning the Intensive Care Unit for Repairs ................................................. 138 RMA Numbers ........................................................................................................... 138 Packing and Shipment .........................................
Summary of the content on the page No. 11
Owner’s Manual - Regal Intensive Care Unit SECTION 11 - TOXICOLOGICAL INFORMATION ............................................. A-4 SECTION 12 - ECOLOGICAL INFORMATION .................................................... A-5 SECTION 13 - DISPOSAL CONSIDERATIONS .................................................... A-5 SECTION 14 - TRANSPORT INFORMATION ...................................................... A-5 SECTION 15 - REGULATORY INFORMATION ...................................................
Summary of the content on the page No. 12
Table of Contents Notes: x SSCI - Suburban Surgical Company, Inc.
Summary of the content on the page No. 13
Owner’s Manual - Regal Intensive Care Unit Chapter 1 - General Information SSCI’s Regal Intensive Care Unit has been uniquely engineered to Introduction provide a temperature and oxygen controlled environment for your most seriously ill patients. This versatile unit can accommodate one large animal or, with the addition of an easily-installed wire grill divider panel, two smaller animals simultaneously. The unit controls temperature in two ways: by controlling air tem- perature, and by warming t
Summary of the content on the page No. 14
Chapter 1 - General Information Throughout this manual you will find text under the headings Note, Information and CAUTION:, and WARNING:. Safety Notices Notes Under the Note: headings, you will be given additional information pertinent to the subject discussed in that paragraph or step. Example: Turn the Temperature Set Knob to 60° F. Note: Set the temperature even lower if your room temperature is 60° or lower. CAUTIONS Under the CAUTION: heading, you will be alerted to potentially haza
Summary of the content on the page No. 15
Owner’s Manual - Regal Intensive Care Unit The following accessories increase the operating convenience of Accessories your Regal Intensive Care Unit. Find descriptions, pictures, and information on SSCI products and accessories in our current catalog, or on our website at www.suburbansurgical.com. To order accessories, refer to Parts Ordering Procedure on Page 73. Stainless Steel Mobile Base (Figure 1) - P/N 12024-00-NIDREJ Modular Cabinetry Base (Figure 2) - Refer to your SSCI C
Summary of the content on the page No. 16
Chapter 1 - General Information CAUTION: Before working on the electrical system, Electrical Warning make sure the unit is Off and the electric power cord un-plugged. CAUTION: Sodalime can cause burns to eyes and Sodalime Warnings skin. Dust can cause irritation to skin and eyes on contact. Harmful if swallowed. CAUTION: Use safety goggles or glasses, PVC or rubber gloves, and a nuisance dust mask when handling Sodalime. CAUTION: Dispose of Sodalime waste and water rinses in accordance with
Summary of the content on the page No. 17
Owner’s Manual - Regal Intensive Care Unit For complete information, refer to the Material Safety Data Sheet (MSDS GTRN-0006) included in the Appendix to this manual. Care and Cleaning of Stainless Steel Introduction Stainless steel is steel alloyed with chromium to make it highly resistant to stain, rust, and corrosion. Note: This does NOT mean that stainless steel will never rust or corrode. Science has not yet developed a steel which is completely stainless or corrosion PROOF. The type of sta
Summary of the content on the page No. 18
Chapter 1 - General Information The large selection of brands and combinations of chemicals Deodorizing Agents, available for deodorizing, disinfecting, and sanitizing is staggering. Disinfectants, and Select one or more agents for use in your facility only after weighing Sanitizers all the benefits claimed by each product. Too often this choice is made without adequate consideration of the effects these agents may produce on equipment or furnishings. CAUTION: Before selecting a chemical to emp
Summary of the content on the page No. 19
Owner’s Manual - Regal Intensive Care Unit SSCI Customer Service can be contacted via mail, telephone, or SSCI Contact fax. The department is available from 8:30am to 5:00pm, Central Information Time, Monday through Friday. Closed holidays. Address: Suburban Surgical Co., Inc. 275 Twelfth Street Wheeling, Illinois 60090 Telephone: Illinois - (847) 537-9320, ext. 3518 Toll Free - 1-800-323-7366 Fax: (847) 537-9061 Web: www.suburbansurgical.com Suburban Surgical Company, Inc. warrants the original
Summary of the content on the page No. 20
Chapter 1 - General Information Notes: 8 SSCI - Suburban Surgical Company, Inc.
