Summary of the content on the page No. 1
C-90A
Electronic Air Cleaner
2003
Service Information
C90ASI3(1-03)
Summary of the content on the page No. 2
Table of Contents Page Friedrich Electronic Air Cleaner ................................................................. 3 Specifications ............................................................................................. 3 CAUTION - Before Operation .................................................................... 4 Operating Your Friedrich Air Cleaner ......................................................... 4 How Electronic Air Cleaners Work .....................................
Summary of the content on the page No. 3
Friedrich Electronic Air Cleaner The Friedrich Electronic Air Cleaner is a self-contained console model consisting of a high voltage DC power supply, electronic cell, 3 speed fan, pre-filter and activated carbon post-filter in a rugged plastic cabinet. It is designed to remove dust, tobacco smoke, pollen, bacteria, and other airborne contaminants from the air. In just minutes, you will notice improvements in your indoor air quality as your Friedrich air cleaner begins the job of removing the bil
Summary of the content on the page No. 4
CAUTION - before operation . . . • Remove the plastic cover from the activated carbon filter Make sure that the top cover is securely in place. and install in unit. This unit is equipped with a grounded plug for your Position the pre-filter at the rear of the unit (closest to protection against shock hazards and should be plugged the electronic cell) and the carbon filter at the front (side directly into a properly grounded receptacle. air comes out.) Electronic air cleaners should NOT b
Summary of the content on the page No. 5
How electronic air cleaners work Electronic air cleaners are an extremely efficient, cost effective method of removing indoor air contaminants. Unlike standard media that merely block relatively large particles, electronic air cleaners attract and hold particles so small that an electron microscope is needed to see them. The PRE-FILTER catches lint, hair and large dust 1 particles, as room air is drawn in through the rear grille by the powerful 3-SPEED FAN. In the IONIZING SECTION of the ELECTR
Summary of the content on the page No. 6
Cleaning (Cont.) 6. If dirt stains or detergent residue remain after washing, it CLEANING THE ELECTRONIC CELL may be necessary to rewash the cell or switch detergent. ALTERNATE CELL CLEANING METHOD The simplest method of cleaning the electronic cell is to use an automatic dishwasher. The dishwasher provides the correct cycle of wash, rinse and dry. Water temperatures If an automatic dishwasher is not available or not of sufficient normally found in dishwashers 150°F to 170°F will not harm
Summary of the content on the page No. 7
Replacing the cell in cabinet After the cell has been washed, check for broken ionizer cell seems stuck when being inserted or the access cover wires and bent collector plates. If broken wires are observed, will not fit securely, check to be sure that the cell is being return unit to Authorized Warranty Station for wire positioned properly. If excessive force is used, the cell or air replacement. If bent collector plates are observed, carefully cleaner unit could be damaged. Airflow arrows point
Summary of the content on the page No. 8
Troubleshooting electronic air cleaner Electrical Troubleshooting Procedure for Electronic Air Cleaner START TO USE THIS CHART: 1. Follow the steps in order. Don't skip around. Make sure elec- tronic cell is clean, 2. Each time you isolate and fix a problem, go back to START. dry and properly 3. Repeat ALL the steps until the air cleaner checks out OK installed WARNING Make sure pre-filter and activated Some of these steps expose dangerous high carbon filter are properly voltage. On
Summary of the content on the page No. 9
Wiring Schematic Page 9
Summary of the content on the page No. 10
Major Components C-90A Page 10
Summary of the content on the page No. 11
C-90A ELECTRONIC AIR CLEANER COMPONENT PARTS LISTING PART NO. DESCRIPTION QTY. 616-203-00 FILTER, PRE ............................................................................................................1 616-420-00 FILTER, CARBON ....................................................................................................1 616-424-01 CARTON, RSC .........................................................................................................1 616-425-00 PACKING, TOP &
Summary of the content on the page No. 12
Regional C-90A Authorized Warranty Repair Stations R & B Appliance Parts B & G Service Co. Reeve Air Conditioning, Inc. 11111 33333 44444 5070 Lindsay Ct. 3950 North Elston 2501 South Park Road Chino, California 91710 Chicago, Illinois 60618 Hallandale, Florida 33009 TEL: 714/591-9405 TEL: 773/588-2290 TEL: 954/962-0252 1-800-421-2189 1-800-962-3383 Alamo Service Co. Superior A/C Service, Inc. 222 22 555 55 1450 North Flores 524 Sackett Street San Antonio, Texas 78212 Brooklyn, New York 1121
