Summary of the content on the page No. 1
®
GENESIS
Natural Gas Grill Owner’s Guide
YOU MUST READ THIS OWNER’S GUIDE
#
BEFORE OPERATING YOUR GAS GRILL 55548
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING
1. Do not store spare liquid propane
cylin
Summary of the content on the page No. 2
Dangers & Warnings DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ® After a period of storage, and/or nonuse, the Weber gas barbecue shoul
Summary of the content on the page No. 3
Contents Danger & Warnings..................................................................................A-2 Warranty ..................................................................................................A-4 Storage and Nonuse .................................................................................A-5 Cooking ...................................................................................................A-6 Cleaning .....................................................
Summary of the content on the page No. 4
Warranty Weber-Stephen Products Co. (Weber) hereby warrants to There are no other express warrants except as set forth ® herein and any applicable implied warranties of merchant- the ORIGINAL PURCHASER of this Weber gas grill that it ability and fitness are limited in duration to the period of will be free of defects in material and workmanship from coverage of this express written Limited Warranty. Some the date of purchase as follows: regions do not allow limitation on how long an implied warr
Summary of the content on the page No. 5
General Instructions ® Your Weber gas barbecue is a portable outdoor cooking Storage ® appliance. With the Weber gas barbecue you can grill, ■ The gas must be turned OFF at the natural gas supply ® barbecue, roast and bake with results that are difficult to when the Weber gas barbecue is not in use. ® duplicate with indoor kitchen appliances. The closed lid ■ When the Weber gas barbecue is stored indoors, the ® and Flavorizer bars produce that “outdoor” flavor in the gas supply must be disconne
Summary of the content on the page No. 6
General Instructions Cooking Cleaning ® ® WARNING: Do not move the Weber gas barbecue WARNING: Turn your Weber gas barbecue OFF and when operating or while barbecue is hot. wait for it to cool before cleaning. ® You can adjust the FRONT and BACK burners as desired. CAUTION: Do not clean your Flavorizer bars or The control settings: High (H), Medium (M), Low (L), or Off cooking grates in a self-cleaning oven. ® (O) are described in your Weber cookbook. The cookbook For availability of repla
Summary of the content on the page No. 7
Exploded View ® Genesis Silver-A Prem. NG 092903 1 2 3 26 27 4 28 29 30 5 31 6 32 7 33 8 34 35 36 9 37 10 38 11 39 12 13 14 40 15 41 16 42 17 43 18 44 19 34 20 45 21 46 22 47 23 48 24 25 49 A-7
Summary of the content on the page No. 8
Exploded View List 1. Hinge Pin 26. Hair Pin Cotter 2. Left Endcap 27. Right Endcap 3. Shroud 28. Thermometer Bezel Assembly 4. Handle 29. Thermometer Assembly 5. Warming Rack 30. Handle Hardware 6. Cooking Grates 31. Warm-Up™ Basket ® 7. Flavorizer Bars 32. Control Panel Knobs 8. Cooking Box 33. Control Panel 9. 1/4-20 keps nut 34. Control Panel Hardware ® 10. Slide Out Bottom Tray 35. Crossover Ignition Button ® 11. Work Surface 36. Crossover tube 12. Catch Pan Holder 37. Front / Rear Burner 1
Summary of the content on the page No. 9
Parts List Cooking Box Assembly - 1 ® Flavorizer Bars - 5 Warm-Up Basket - 1 Warming Rack - 1 Cooking Grates - 2 Caster Frame - 1 Bottom Tray - 1 Wheel Frame - 1 Catch-Pan Holder - 1 Catch-Pan - 1 Side Table - 1 Disposable Drip Pans - 2 Bottom Rack - 1 1 inch Bolts (1/4 x 20 x 1 inch Bolt) - 6 Condiment basket - 1 Nylon Washer - 6 Left Trim Assembly - 1 Wrench - 1 Side Table - 1 7/16” Inch Wrench - 1 Right Trim Piece - 1 Hose A-9
Summary of the content on the page No. 10
Unpacking 1 3 4 2 A-10
Summary of the content on the page No. 11
• Arrow sticker to the front. 1 b a • Push down firmly until Bottom Rack Locking Clip, "locks" under the rail. c 12 3 Ba302.b B-a
Summary of the content on the page No. 12
2 a b 1 2 3 • Push down firmly on both sides to ensure bottom rack is locked under the rails. WARNING: Do not go to next step if bottom rack is not locked in place B-b
Summary of the content on the page No. 13
3 • Install bolts at indicated locations. Use supplied tool to tighten. Recheck each bolt for tightness with a 7/16” open end wrench. B-c
Summary of the content on the page No. 14
4 B303_LP.a B-1
Summary of the content on the page No. 15
5 6 B-2
Summary of the content on the page No. 16
7 a b 9 8 B-3
Summary of the content on the page No. 17
a 11 10 b B-4
Summary of the content on the page No. 18
Gas Instructions Gas Line Piping Install Gas Supply ■ If the length of the line required does not exceed 50 General Specifications for Piping feet, use a 5/8" O.D. tube. One size larger should be Note - Contact your local municipality for building used for lengths greater than 50 feet. codes regulating outdoor gas barbecue installations. ■ Gas piping may be copper tubing, type K or L; In absence of Local Codes, you must confirm to the polyethylene plastic tube, with a minimum wall latest editio
Summary of the content on the page No. 19
Gas Instructions Check that all burner valves are off Check the flexible hose to manifold connection Valves are shipped in the OFF position, but you should See Page C-3 check to be sure that they are turned OFF. Check by pushing down and turning clockwise. If they do not turn, The Natural gas hose has been attached during the they are off. Proceed to the next step. If they do turn manufacturing process. We do recommend that the hose continue turning them clockwise until they stop, then they to
Summary of the content on the page No. 20
Gas Instructions Check for gas leaks Check: 1) Hose to manifold connection. DANGER WARNING: If there is a leak a connection(1), re- tighten the fitting with a wrench and recheck for Do not use an open flame to check for gas leaks with soap and water solution. leaks. Be sure there are no sparks or open If a leak persists after retightening the fitting, turn OFF flames in the area while you check for leaks. the gas. DO NOT OPERATE THE GRILL. Contact the Sparks or open flames will result in a
