Summary of the content on the page No. 1
HBZ2610
848-L0T-93A0 (909)
U
S
OWNER'S/OPERATOR'S
MANUAL
BLOWERS
HBZ2610
WARNING
The engine exhaust from this
product contains chemicals
known to the State of California to
cause cancer, birth defects or
other reproductive harm.
WARNING
Before using our products,
please read this manual carefully
to understand the proper use of
your unit.
APPLICABLE SERIAL NUMBERS :
90100101 and up
US-1
Summary of the content on the page No. 2
HBZ2610 SAFETY FIRST Instructions contained in warnings within this manual WARNING and warning seals marked with a symbol on the blower concern critical points which must be taken into 1. Read this Blower Owner/Operator consideration to prevent possible serious bodily injury, Manual carefully. Be sure you and for this reason you are requested to read all such understand how to operate this unit instructions carefully and follow them without fail. properly before you use it. Failure to do so coul
Summary of the content on the page No. 3
HBZ2610 1. Parts location U S (1) Stop switch (2) Throttle trigger (3) Air inlet screen (4) Spark plug cap (5) Recoil starter knob (6) Air cleaner (7) Fuel tank (8) Blower pipe (9) Screw 2. Specifications ■ MODEL HBZ2610 Dimensions (L x W x H) mm (in) ···············································································327x269x360 (12.9x10.6x14.2) Dry Weight kg (lbs)······················································································································
Summary of the content on the page No. 4
HBZ2610 3. Warning labels on the machine (1) Read owner's manual before operating this machine. (2) Wear head, eye and ear protection. (3) Handling this machine improperly could result in accidents causing serious injury or death. Read this manual carefully and practice using the blower until you are fully acquainted with all operations and have learned to use it correctly. (4) Severing of fingers or hand by fan blade. Do not open or remove safety guards or nets while engine is running. (5) T
Summary of the content on the page No. 5
HBZ2610 5. For safe operation 3. The ignition system of your unit produces WARNING an electromagnetic field of a very low intensity. This field may interfere with some • The blower is used for blowing away pacemakers. To reduce the risk of serious leaves and other debris on the ground. or fatal injury, persons with pacemaker When operating the blower, the U should consult their physician and the operater must stand with both feet S pacemaker munufacturer before operating firmly on the ground. t
Summary of the content on the page No. 6
HBZ2610 5. For safe operation ■ Transport WARNING 1. Drain the fuel from the fuel tank before transporting or storing the blower. 2. Never use the blower without the 2. Secure the unit carefully to prevent screen at the air intake of the blower. movement when it is transported. Before each use, check that, the screw 3. A unit that receives a strong shock during (1) is securely tightened and is free transport and unloading may malfunction. from any damage. ■ Fuel safety 3. Check the work a
Summary of the content on the page No. 7
HBZ2610 5. For safe operation filters. RedMax product. 5. In the event that any part must be replaced ■ For protecting your body from vibration or any maintenance or repair work not described in this manual must be performed, please contact a representative WARNING U from the store nearest RedMax authorized S Prolonged use of a blower, exposing the servicing dealer for assistance. operater to vibrations and cold may 6. Do not use any accessory or attachment produce whitefinger disease (Raynaud
Summary of the content on the page No. 8
HBZ2610 6. Set up ■ BLOWER PIPE F1 • Align groove in blower pipe with projection on blower housing (or another blower pipe) and slide the pipe onto the blower housing (or another blower pipe). Rotate the pipe clockwise to lock it into place. ■ INSTALLING SUPPORT HANDLE F2 • This handle is supplied with the blower. • Fit the holes of volute and handle, tighten the screws. • Be sure to tighten the screws straightly. (1) Support Handle (2) Holes (3) Screws US-8
Summary of the content on the page No. 9
HBZ2610 7. Fuel FUEL lines or fuel tank of the engine. WARNING NOTE • Gasoline is very flammable. Avoid smoking or bringing any • Failures caused by operating engines on gasoline with octane U flame or sparks near fuel. Make sure to stop the engine and rating lower than 89 are not covered by the RedMax Two- S allow it cool before refueling the unit. Select outdoor bare Stroke engine warranty. ground for fueling and move at least 10 ft (3 m) away from the fueling point before starting the engine.
Summary of the content on the page No. 10
HBZ2610 7. Fuel test standard has been discontinued by API in 1995 and it no WARNING longer exists. 1. Select flat and bare ground for fueling. 2. Move at least 10 feet (3 meters) away from the fueling point IMPORTANT before starting the engine. • Gasoline/Oil mixture Storage Recommendations 3. Stop the engine before refueling the unit. At that time, be Store your gasoline or gasoline/oil mixture in a cool dry area in sure to sufficiently agitate the mixed gasoline in the a tightly sealed approv
Summary of the content on the page No. 11
HBZ2610 8. Operation ■ STARTING ENGINE F3 NOTE 1. Rest the unit on a flat, firm place. 2. Pump the primer until fuel flows out in Except for an emergency, avoid stopping the clear tube. the engine while pulling the throttle trigger. U (1) Primer S ■ ADJUSTING IDLE SPEED F7 1. When the engine tends to stop frequently at an idle mode, turn the adjusting screw clockwise. 3. Move the choke lever upward to close F4 the choke. (1) Idle adjusting screw (2) Cable adjuster (1) Choke lever (2) Close
Summary of the content on the page No. 12
HBZ2610 9. Maintenance Maintenance, replacement, or repair of the emission control device and systems may be performed by any non-road engine repair establishment or individual. ■ MAINTENANCE CHART every every every 25 50 100 system/compornent procedure before hours hours hours note use after after after fuel leaks, fuel spillage wipe out ✔ fuel tank, air filter, fuel filter inspect/clean ✔✔ replace, if necessary see ■ADJUSTING replace carburetor idle adjusting screw ✔ IDLING SPEED (p.11) if nec
Summary of the content on the page No. 13
HBZ2610 9. Maintenance ■ MUFFLER (1) Screw (2) Air inlet screen WARNING ■ PROCEDURES TO BE PERFORMED F14 • Inspect periodically, the muffler for AFTER EVERY 50 HOURS OF USE U loose fasteners, any damage or • Remove the muffler, insert a S corrosion. If any sign of exhaust screwdriver into the vent, and wipe leakage is found, do not use the blower away any carbon buildup. Wipe away and have it repaired immediately. any carbon buildup on the muffler • Note that failing to do so may result exhaus
Summary of the content on the page No. 14
HBZ2610 10. Storage BEFORE STORING THE BLOWER: 1. Drain a fuel tank and push the primer bulb until it becomes empty of fuel. 2 .Remove the spark plug and drop a spoonful of 2-cycle oil into the cylider. Crank the engine several time and install the spark plug. 3. Store unit in a dry, dust free place, out of the reach of children. 11. Disposal • When disposing your machine, fuel or oil for the machine, be sure to allow your local regulations. 12. Optional vacuum kit usage • See the operating ins
Summary of the content on the page No. 15
HBZ2610 FEDERAL AND CALIFORNIA EMISSIONS CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS U The EPA (U.S. Environmental Protection Agency), CARB (California Air Resources Board), Environment S Canada and RedMax are pleased to explain the emissions control system's warranty on your 2009 and later small off-road engine. In U.S. and Canada, new equipment that use small off-road engines must be designed, built, and equipped to meet the applicable Federal or Californian stringent anti-
Summary of the content on the page No. 16
HBZ2610 warranty is warranted for the remaining warranty period. Any warranted part that is scheduled only for regular inspection in the maintenance schedule will be warranted for a period of two years. A statement in such written instructions to the effect of "repair or replace as necessary" will not reduce the period of warranty coverage. Any such part repaired or replaced under warranty will be warranted for the remaining warranty period. DIAGNOSIS The owner must not be charged for diagnostic
