Summary of the content on the page No. 1
OWNERS MANUAL
Read and understand this entire manual before riding!
Item Number
13114099
Summary of the content on the page No. 2
CONTENTS Safety Warnings ................................................................................ 1 Troubleshooting Guide ...................................................................7-8 Before You Begin ............................................................................... 2 E500S Scooter Parts ....................................................................9-10 Assembly and Set-Up ........................................................................ 3 Safety Remi
Summary of the content on the page No. 3
BEFORE YOU BEGIN Remove contents from box. Remove the foam separators that protect the components from damage during shipping. Inspect the contents of the box for scratches in the paint, dents or kinked cables that may WARNING: DO NOT USE NON-RAZOR have occurred during shipping. Because the E500S scooter was 95 percent assembled and packed at the factory, there should not be any problems, even if the box has a few scars or dents. PRODUCTS WITH YOUR RAZOR E500S SCOOTER. The scoo
Summary of the content on the page No. 4
ASSEMBLY AND SET-UP q Charging the Battery WARNING: Your electric scooter may not have a fully charged battery. Therefore it is a good idea to charge the battery Always disconnect your E500S prior to use. scooter from the charger before • Initial charge time: 12 hours • Run time: up to 40 minutes cleaning with liquid. • Recharge time: up to 8 hours, • Average battery life: 250 charge/discharge cycles depending on the level of depletion Note: If your charger does not look
Summary of the content on the page No. 5
ASSEMBLY AND SET-UP Note: The pressurized air q Inflating the Tires supplies found at gasoline Tires are inflated when shipped, but they invariably lose some pressure between the point of stations are designed to inflate manufacturing and your purchase. high-volume automobile tires. If you decide to use such an air supply to inflate your scooter tires, first make sure the pressure gauge is working, then use very short bursts to inflate to the correct PSI. If you inadvertently over-inflate
Summary of the content on the page No. 6
REPAIR AND MAINTENANCE q Front Tire Replacement 1 Loosen front axle by 2 Remove wheel and replace attaching 10/15 mm wrenches tire. To reinstall wheel, reverse to both axle nuts and loosening these steps. counter-clockwise. q Rear Tire/Chain Replacement 1 Remove chain guard with 2 Loosen rear axle by attach- 3 Remove wheel and replace Phillips Screwdriver. ing wrenches to both axle nuts tire or chain. To reinstall wheel, and loosening counter-clock- reverse these steps. wise. Pull cha
Summary of the content on the page No. 7
SB 1918 (CALIFORNIA) DECLARATION YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS INVOLVING THE USE OF THIS SCOOTER/ELECTRIC VEHICLE. TO DETERMINE IF COVERAGE IS PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT. 6
Summary of the content on the page No. 8
TROUBLESHOOTING GUIDE Problem Possible Cause Solution Scooter does not run Undercharged battery Charge the battery. A new battery should have been charged for at least 12 hours before using the scooter for the first time and up to 8 hours after each subsequent use. Check all connectors. Make sure the charger connector is tightly plugged into the charging port, and that the charger is plugged into the wall. Make sure power flow to the wall outlet is on. Charger is not working You may
Summary of the content on the page No. 9
TROUBLESHOOTING GUIDE Problem Possible Cause Solution Sometimes the scooter Loose wires or connectors Check all wires around the motors and all connectors to make sure doesn’t run, but other they are tight. times it does Motor or electrical switch damage Contact your local Razor authorized service center for diagnosis and repair. Charger gets warm Normal response to charger use No action required. This is normal for some chargers and is no cause during use for concern. If your charger
Summary of the content on the page No. 10
E500S PARTS Keep your E500S scooter running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part avail- ability. (Specifications subject to change without notice.) 1. Front wheel with tire, tube, axle nuts 2. Rear wheel with tire, tube, sprocket, freewheel, axle nuts 3. Fork 4. Handlebar 5. Quill and handlebar clamp 6. Brake levers 7. Speed control 8. Seat mast w/screws 9. Chainguard w/screws 10. Sprocket and freewheel 11. Chain 12. Chain tension
Summary of the content on the page No. 11
9 6 25 8 7 4 10 23 11 12 2 5 22 13 14 21 1 3 20 19 18 24 17 16 15 E500S PARTS 10
Summary of the content on the page No. 12
SAFETY REMINDERS PRE-RIDE CHECKLIST Loose Parts Tire Inflation Check and secure all fasteners before every ride. Make Periodically inspect the tires for excess wear, and q q sure steering stem clamp bolts are locked properly in place. regularly check the tire pressure and re-inflate as There should not be any unusual rattles or sounds from necessary. If you get a flat tire, the inner tube can be loose parts or broken components. If you are not sure, ask patched or a new tube can be purchased f
