Summary of the content on the page No. 1
L4031A,C
®
Pool Heater Aquastat Controller
PRODUCT DATA
FEATURES
• Pool control regulates pool water temperature.
• L4031A pool side control is ambient-temperature
compensated so changes in air temperature do not
affect water temperature.
• High limit provides shutdown protection to prevent
boiler overheating.
• L4031A provides automatic high limit reset.
• L4031C requires manual high limit reset.
• Each limit control has its own remote-bulb sensing
element and snap switch for system control.
GE
Summary of the content on the page No. 2
® L4031A,C POOL HEATER AQUASTAT CONTROLLER Differential: SPECIFICATIONS L4031A: Fixed 2°F (1°C) or 5°F (3°C). When 5°F (3°C), the electrical rating is the High Limit Electrical Rating. IMPORTANT L4031C: Fixed 5°F (3°C). The specifications given in this publication do not include normal manufacturing tolerances. Therefore, Electrical Rating: this unit may not exactly match the listed L4031A: specifications. Also, this product is tested and Pilot Duty: 125 VA at 120 and 240 Vac. ® calibrated unde
Summary of the content on the page No. 3
® L4031A,C POOL HEATER AQUASTAT CONTROLLER Optional Specifications: When Installing this Product… L4031A: Read these instructions carefully. Failure to follow them —Pool control dial marked WARMER-COOLER. could damage the product or cause a hazardous — High limit capillary exiting from top or bottom of case. condition. — Pool control range: 53°F to 107°F (12°C to 42°C), Check the ratings given in the instructions and on the 100°F to 240°F (38°C to 116°C). product to make sure the product is
Summary of the content on the page No. 4
® L4031A,C POOL HEATER AQUASTAT CONTROLLER CLAMP B CLAMP SCREWS (2) CLAMP A BULB BULB COMPRESSION SEALING FITTING WASHER JAWS SPREAD JAWS TO FIT OVER RIDGE ON SPUD OF WELL INSERTION LENGTH APPROX. 3-3/16 in. (81 mm) SCREWDRIVER SPLIT SLEEVE M8815 INSERT— MOUNTING CLAMP Fig. 2. 104486 Bulb compression fitting. DRAW NUT MOUNTING CLAMP SPUD WELL Using Capillary Compression Fitting (Fig. 3) BULB B 1. Screw fitting into boiler or pipe tapping. 2. Place packing nut on tubing. 3. Slide bulb comple
Summary of the content on the page No. 5
® L4031A,C POOL HEATER AQUASTAT CONTROLLER L4031 POOL HEATER Checkout AQUASTAT® CONTROLLER POOL HIGH WARNING CONTROL LIMIT CAN CAUSE PROPERTY DAMAGE, SEVERE INJURY OR DEATH. GAS BURNER CONTROL This product is intended for use only in systems with a pressure relieve valve. PP PP TH1 TH2 Always conduct a thorough checkout when the installation is complete. Make sure the controller was installed and adjusted properly by putting it into operation and observing at least one complete cycle. Further ad
Summary of the content on the page No. 6
® L4031A,C POOL HEATER AQUASTAT CONTROLLER 1-888-809-3787 60-2107—5 6
Summary of the content on the page No. 7
® L4031A,C POOL HEATER AQUASTAT CONTROLLER 7 60-2107—5
Summary of the content on the page No. 8
® L4031A,C POOL HEATER AQUASTAT CONTROLLER 1-888-809-3787 60-2107—5 8
Summary of the content on the page No. 9
® L4031A,C POOL HEATER AQUASTAT CONTROLLER 9 60-2107—5
Summary of the content on the page No. 10
® L4031A,C POOL HEATER AQUASTAT CONTROLLER 60-2107—5 10
Summary of the content on the page No. 11
® L4031A,C POOL HEATER AQUASTAT CONTROLLER 11 60-2107—5
Summary of the content on the page No. 12
® L4031A,C POOL HEATER AQUASTAT CONTROLLER Home and Building Control Home and Building Control Helping You Control Your World Honeywell Inc. Honeywell Limited-Honeywell Limitée Honeywell Plaza 740 Ellesmere Road P.O. Box 524 Scarborough, Ontario QUALITY IS KEY Minneapolis, MN 55408-0524 M1P 2V9 60-2107—5 60-2107—5 J. H. Rev. 5-95 Printed in U.S.A. 12 customer.honeywell.com
