Summary of the content on the page No. 1
Bio-ethanol Fire Pit with Log Set
Model # 62000
Distributed by:
Duraflame, Inc., Stockton, CA 95201
Made in China
For questions about Assembly and Operating instructions or Warranty Claims
contact Duraflame, Inc. Consumer Affairs
info@duraflame.com
1 (866) 552-3015
www.duraflame.com/illuma
Patents Pending
WARNING: If the information in this manual is not followed exactly, a fire or explosion may
result, causing property damage, personal injury, or loss of life.
Do not store or use gasoli
Summary of the content on the page No. 2
TABLE OF CONTENTS page I. Safety Information ........................................................................3 II. Setup ............................................................................................6 III. Minimum Clearances ....................................................................6 IV. Installation ....................................................................................7 V. Installing the Fuel Canister ................................
Summary of the content on the page No. 3
I. SAFETY INFORMATION IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this appliance. Improper use of this appliance or failure to comply with the safety rules can cause serious injury or death from burns, fire, explosion, or carbon monoxide poisoning. Keep this manual. It should be read by all users of the appliance. This appliance is designed for outdoor use. Do not use indoors. Using this appliance indoors may result in harm
Summary of the content on the page No. 4
This appliance is designed to be smokeless. If the logs begin to smoke, extinguish the appliance by using the snuffer (see Section VI Operation), and check the positioning of the logs. Note: During initial operation, slight smoking may occur due to log curing and the burning off of manufacturing residues. This is a normal condition. Do not run this appliance where flammable liquids or vapors are used or stored, or in a dusty environment. Do not place any flammable material close to the a
Summary of the content on the page No. 5
Figure 1 Parts of the Appliance -5-
Summary of the content on the page No. 6
II. SETUP CAUTION: Do not remove the metal data plate that is attached to the underside of the door to the fuel compartment of the appliance. It contains important product information. WARNING: Never install this appliance • indoors • in a r ecr eational vehicle, boat, or tent • wher e fur nitur e, clothing, or other flammable objects ar e less than 42 inches (3.5 feet) from the front, top, or sides of the appliance • in high traffic ar eas Use this appliance in compliance with all local
Summary of the content on the page No. 7
IV. INSTALLATION 1. Carefully remove the contents of the carton. You should find (See Figure 1): • Table • Table Legs • Hardware needed (screws and nuts) • Fire Pit • Burner Assembly • Log Plate • Five logs • Flame Snuffer • One set of three flame adjustment rings (packaged inside the burners) • Water Proof Cover If components are missing, contact Duraflame. Figur e 3 How to attach the legs 2. Remove all these components from their packing. When handling the logs, take care not t
Summary of the content on the page No. 8
Step #1: Table Step #2: Adding Fir e Pit Step #3: Adding Bur ner Assembly Step #4: Adding Log Plate Figur e 4 Steps for Assembling Fire Pit 9. Remove flame adjustment rings from inside the burners. 10. Carefully position the logs on the log plate according to the illustrations provided below (see Figures 6-10). The pins that protrude upward from the log plate and fuel compartment door will help you to position the logs correctly. Log #1 will fit on a pin that protrudes from the door. Log
Summary of the content on the page No. 9
Figur e 5 Figure 6 Logs Installing Log 1 Figure 7 Figure 8 Installing Log 2 Installing Log 3 Figure 9 Figure 10 Installing Log 4 Installing Log 5 -9-
Summary of the content on the page No. 10
V. INSTALLING THE FUEL CANISTER NOTE: Use only 1 L duraflame illuma-fuel bio-ethanol fuel canisters with this appliance. The canisters are NOT refillable. 1. Remove the log that covers the door of the canister compartment. Set the log in a safe place where it will not be damaged. (see Figure 11). Do not touch the log in any area other than the one shown when flames are present or the appliance is still hot. Figure 11 Figur e 12 Removing Log #1 Opening Compartment door 2. Open the door of
Summary of the content on the page No. 11
might hear a soft gurgling noise as the fuel from the canister begins to fill the burner—this is normal. Make sure the left side is tipped down during installation. 5. After the canister has been installed, close the door of the fuel compartment using the hook on either side of the door, and replace the log that was removed in step 1. (see Figure 14). The appliance is now ready for use. Make sure you use the hook on either side of the door to close the door when the appliance is hot. Th
Summary of the content on the page No. 12
1. Remove the log that covers the fuel compartment door. Be very careful about where you touch the log. See Figure 11. Make sure you handle the log on the branch that is farther from the flames. CAUTION: THE AREAS OF THE LOG THAT ARE CLOSEST TO THE FLAME ARE VERY HOT AND WILL BURN YOUR HAND. Set the log in a safe place where it will not be: damaged, come into contact with anything combustible, or be touched by somebody else. 2. Open the door of the fuel canister compartment using the h
Summary of the content on the page No. 13
X. MAINTENANCE WARNING: Turn off the appliance and let it cool before cleaning. CAUTION: Periodic cleaning is necessary to ensure proper functioning of this appliance. The only maintenance needed for the continued proper performance of this appliance is periodic cleaning. To clean the appliance: 1. Allow the flames to die out naturally by consuming all the fuel. This will ensure that there is only residual alcohol in the tubes between the fuel tray area and the burners. Also, since the b
Summary of the content on the page No. 14
XI. TROUBLESHOOTING Use the following guide to solve any problems you might encounter in operating this appliance. PROBLEM SOLUTION 1. You see fuel on the ground near the • DO NOT light the burner. Extinguish any open appliance. flame near the spill. Wipe up the spill, and wait several minutes for the residue to evaporate. If you see no additional fuel on the ground, you may light the burner. If you see additional fuel on the ground, you might have a leak. DO NOT use this appliance if
Summary of the content on the page No. 15
If the canister is difficult to insert or the canister binds to the piercer when being removed, it means that the bracket on the left side of the reservoir is bent too far to the right. Carefully bend the bracket on the left side of the reservoir slightly to the left to allow a little more space for the canister when it is being installed or removed. XII. PARTS LIST PART NO. ITEM 62000 illuma Fire Pit with Log Set 62001 36” Slate Table 62002 Table Legs 62003 Fire Pit Burner Assembly 62004 Fi
Summary of the content on the page No. 16
WARRANTY INFORMATION KEEP THIS WARRANTY Model: ____________________________________ Serial No.: _________________________________ Date Purchased: ____________________________ Always specify model and serial numbers when communicating with Duraflame, Inc. We reserve the right to amend the specifications of this product at any time without notice. The only warranty applicable is our standard written warranty. We make no other warranty, expressed or implied. LIMITED WARRANTY – DURAFLAME ILLUMA™ LO
