Summary of the content on the page No. 1
R
INSTALLATION AND OPERATING INSTRUCTIONS
Gas Foodwarmer
MODEL: WW G (Convertable)
PRODUCT AL MANU
Safety Instructions
Installation Instructions
Operation Instructions
Maintenance Instructions
Replacement Parts List
Warranty/Service Information
IMPORTANT FOR FUTURE REFERENCE
Please complete this information and ain ret this manual for the life of the equipment. For
arranty W Service and/or s, Part this information is required.
Model Number Serial Number Date Purchased
FOR YOUR SAFETY: Do not sto
Summary of the content on the page No. 2
allation Inst and art-up st should be performed by a qualified aller inst who thoroughly read, ands underst and follows these instructions. If you have questions concerning the allation, inst operation, maintenance or service of this product, write echnical T Service artment Dep APW yott W Foodservice Equipment , any Comp .O. P Box 1829, Cheyenne, WY 82003. 1. SAFETY PRECAUTIONS Before alling inst and operating this equipment be sure everyone involved in s it operation is fully trained and is aw
Summary of the content on the page No. 3
WARNING: A factory authorized agent should handle all maintenance and . air rep Before ! doing any maintenance or , air rep act cont APW yott. W ! WARNING: An earthing cable must connect the appliance to all other s unit ni the ! ! complete allation inst and from there to an independent earth connection. NOTICE: This product is intended for commercial use . only Not for household use. ! ! WARNING: SHOCK HAZARD: Do not open any anels p that require the use of tools. ! ! WARNING: Improper allation
Summary of the content on the page No. 4
The countertop foodwarmer provides countertop warming abilities. cap The unit incorporates a 4000 BTU burner for ficient ef operation. TABLE OF CONTENTS: SECTION ITEM PAGE 1 Safety Precautions 2 2 General allation Inst Instructions 4 3 pecifications S . 5 4 Lighting Instructions 6 5 Maintenance ... 6 6 Conversion ..... 7 7 Replacement s Part List & Exploded iew V 8 8 arranty W 1 1 TION LOCA OF A T TE DA PLA The a dat plate for the gas warmer well is located on the back side of the front anel. p
Summary of the content on the page No. 5
Caution: DO NOT use an open flame to check for leaks. Check all gas piping for leaks ! ! with a soap and water solution before operating unit. 3. SPECIFICATIONS These s unit are able suit for allation inst on combustible and noncombustible surfaces. NONCOMBUSTIBLE CLEARANCES COMBUSTIBLE CLEARANCES Sides Rear Sides Rear 3 0 0 3 Gas Foodwarmer: These gas s unit are designed for countertop operation. They are used for holding s product at serving temperature and producing evenly cooked s. produ
Summary of the content on the page No. 6
4. LIGHTING INSTRUCTIONS Lighting instructions are located on the inside of the front anel. p Access to the manifold and pilot valves are gained through the front anel. p Lighting Pilot Burner: 1. urn T on main gas supply to unit. 2. urn T the burner control knob to the OFF position. Open the front anel p and wait at least 5 minutes to allow any gas which may have accumulated in the burner artment comp to escape. 3. Depress red button on pilot safety valve and light through observation hole in
Summary of the content on the page No. 7
CAUTION: The foodwarmer is for wet operation only. Do not operate the unit dry. If the unit runs dry, follow these steps: A. urn T control knob to OFF . B. ait W until the an p well is cool enough to be handled. Do not pour water in the hot an p well. C. Remove na p well and thoroughly wash the internal bottom surface per weekly cleaning instructions. D. Replace an p well, add water and resume normal operation. 2. For proper operation, add approximately three s quart fo water in the an p well.
Summary of the content on the page No. 8
30 32 17 45 24 43 44 29 38 46 47 33 26 28 37 20 21 40 22 39 36 34 23 35 0 0 6 0 8 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Below Detail Below Detail Burner 7 0 Burner See See 0 0 0 0 0 0 0 0 0 4 0 0 0 2 0 0 0 0 5 0 0 0 SHOWN NOT 0 1 0 0 0 3 0 0 0 0 9 0 0 REPLACEMENT PARTS LIST & EXPLODED VIEW 35 48 49 50 51 23 34 36 14 39 14 22 40 16 16 21 18 18 3 20 Burner Detail 13 13 6 37 27 19 27 19 28 25 25 1 26 33 12 7 12 1 4 2 15 47 15 46 8 10 10 38 29 41 41 44 5 11 43 24 11 45 31 17 42 31 42 9 32 30
Summary of the content on the page No. 9
ITEM PART NUMBER DESCRIPTION QUANTITY 1 21817920 SUPPORT, LEG, 14" 2 2 21813313 SIDE PANEL, LH & RH 2 3 21817910 WELDMENT, TOP, WELL 1 21817921 BACK PANEL 4 1 5 86320-00 LEG, 4" 4 6 2066105 PRESSURE REG, 3/4NPT 1 7 2068000 VALVE, GAS, ON-OFF 1 8 2066842 HOOD, ORIFICE, #42 1 9 8705600 KNOB, MED. DUTY UNIT 1 10 8196602 RETAINER 4 11 8196601 NUT, U-TYPE 4 12 21817927 FRONT PANEL, 1 21817928 BOTTOM PANEL 1 13 14 82016400 BRCKT, BURNER SUPPORT 1 15 2065815 BURNER, GAS WARMER 1 16 3100719 PAN, WARMER
Summary of the content on the page No. 10
Notes: 10
Summary of the content on the page No. 11
APW WYOTT EQUIPMENT LIMITED ARRANTY W APW yott W Foodservice Equipment Company warrants it ’s equipment against defects in materials and workmanship, subject to the following conditions: This warranty applies to the original owner only and is not assignable. Should any product fail to function in its intended manner under normal use within the limits defined in this , warranty at the option of APW yott W such product will be repaired or replaced by APW yott W or its Authorized Service . Agency A
Summary of the content on the page No. 12
R APW WYOTT Foodservice Equipment Company .O. P Box 1829 Cheyenne, WY 82003 +1 (307) 634-5801 Phone +1 (800) 752-0863 oll T Free +1 (307) 637-8071 .apwwyott.com www 12
