Summary of the content on the page No. 1
USER’S INFORMATION MANUAL
RPGE/RGE Series
Gas Heating/Electric Cooling Package Unit
Save these instructions for future reference
Congratulations...
WARNING
...your outdoor heating/cooling package unit is a valuable
FIRE OR EXPLOSION HAZARD
piece of equipment, designed and manufactured by the
most modern methods. Proper care of your unit should
Failure to follow the safety warnings
result in many years of service and comfort.
exactly could result in serious injury,
death, or property damage.
To
Summary of the content on the page No. 2
IMPORTANT SAFETY INFORMATION 3. This unit is equipped with an ignition device which automatically lights the burners. See OPERATING WARNING YOUR UNIT on page 3 for information on lighting and shutting down the unit. ELECTRICAL SHOCK, FIRE, OR EXPLOSION HAZARD 4. Should the gas supply fail to shut off or if overheating Failure to follow the safety warnings exactly occurs, shut off the gas valve to the unit before could result in dangerous operation, serious shutting off the electrical supply.
Summary of the content on the page No. 3
7. Wait 5 minutes to clear out any gas, then smell for OPERATING YOUR UNIT gas (including at the bottom of the unit near the ground). If you smell gas, stop and follow the directions in These units are equipped with an ignition device which WHAT TO DO IF YOU SMELL GAS on page 1. If you automatically lights the burners. Do not try to light the don’t smell gas, continue to next step. burners by hand. 8. Turn the gas control knob, or slide the gas control Before operating, smell around furnace ar
Summary of the content on the page No. 4
O T U A 80 50 N O N A F 70 60 Temperature Control 3. Be sure air can circulate freely throughout your home. There are many types and styles of thermostats. Yours Do not block supply registers or return grilles with may look different from the one shown in Figure 2. How- furniture or rugs. ever, almost all thermostats perform the same basic functions described in the following section. 4. Keep surface of the outdoor coil free from dirt, lint, paper, or leaves. If your unit fails to operate, che
Summary of the content on the page No. 5
If the burner does not ignite, contact a qualified service MAINTENANCE OF YOUR UNIT technician for assistance. Should you observe unusual amounts of any of the following WARNING conditions, it is important that you call your authorized dealer Always shut off all power to the unit before attempting at once to obtain a qualified service inspection: any of the following maintenance procedures. Failure to do so may result in personal injury. • Rust, flakes, or other deposits • Coatings • Corrosio
Summary of the content on the page No. 6
Contact your dealer if you desire more information about Outdoor Coil this important safety feature. Leaves and other large obstructions should be carefully removed from the outdoor coil surfaces without damaging Should any unusual conditions be observed during your the fin surface of the coil. inspections, call an authorized service dealer immediately. Lubrication Return Air Lubrication of the bearings in the circulating air blower motor All return air duct connections must be tight and sealed
Summary of the content on the page No. 7
REPAIR PARTS Owner Record The following repair parts are available from your local distributor. When ordering parts, include the complete Model # _________________________________ unit model number and serial number which are printed on the rating plate located on the unit. Serial # _________________________________ Installation Date ___________________________ Gas Control Group Manifold Orifice Installed by: Spark electrode Ignition wire Burner Gas valve Dealer ________________________________
Summary of the content on the page No. 8
ALLIED AIR ENTERPRISES EQUIPMENT LIMITED WARRANTY APPLIES IN U.S.A. AND CANADA ONLY FAILURE TO MAINTAIN YOUR EQUIPMENT WILL VOID THIS WARRANTY COVERED EQUIPMENT The following Allied Air Enterprises heating and cooling equipment is covered by the Limited Warranty, Condensing Units: 2SCU13, 4SCU13, 4SCU14, 4SCU16, 4SCU18, 2AC13, 2AC14, 4AC13, 4AC14 Heat Pumps: 2SHP13, 4SHP13, 2SHP14, 4SHP14, 4SHP16, 4SHP18, 2HP13, 2HP14, 4HP13, 4HP14 Gas Furnaces: G1N80, G1D80, G2D80, G1D91, G1D93, G2D93, G2D95
Summary of the content on the page No. 9
5-YEAR LIMITED EXTENDED PARTS WARRANTY Allied Air Enterprises Inc. (“Allied Air”) provides its air conditioning and heating products with a Standard Limited Parts Warranty for five (5) years. This additional 5-Year Limited Extended Parts Warranty is in addition to and is intended to supplement Allied Air’s Standard Limited Parts Warranty. As such, Allied Air provides for a total of 10- years of limited warranty coverage (Standard Limited Parts Warranty plus additional 5-Year Limited Extended
Summary of the content on the page No. 10
NOTES Page 10 Issue 0912 506299-01
