Summary of the content on the page No. 12
II. SAFETY WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications presented in this manual. Doing so could cause instability in your power chair. In compliance with the Americans with Disabilities Act of 1990, all handicap public access ramps are required to have a maximum slope of 5° (8.7%). Therefore, Pride recommends that the maximum slope of an i
Summary of the content on the page No. 13
II. SAFETY Public Streets and Roadways WARNING! You should not operate your power chair on public streets and roadways. Be aware that it may be difficult for traffic to see you when you are seated on your power chair. Obey all local pedestrian traffic rules. Wait until your path is clear of traffic, and then proceed with extreme caution. Outdoor Driving Surfaces Your power chair is designed to provide optimum stability under normal driving conditions—dry, level surfaces composed of concrete, bla
Summary of the content on the page No. 14
II. SAFETY Stairs and Escalators Power chairs are not designed to travel up or down stairs or escalators. Always use an elevator. WARNING! Never use your power chair to negotiate steps or escalators. Doors ! Determine if the door opens toward or away from you. ! Drive your power chair gently and slowly forward to push the door open. Or drive your power chair gently and slowly backward to pull the door open. Elevators Modern elevators have a door edge safety mechanism that, when pushed, reopens
Summary of the content on the page No. 15
II. SAFETY Batteries In addition to following the warnings below, be sure to comply with all other battery handling information. For more information about your power chair’s batteries, see VI. “Batteries and Charging.” WARNING! Battery posts, terminals, and related accessories contain lead and lead compounds. Wear goggles and gloves when handling batteries and wash hands after handling. WARNING! Power chair batteries are heavy. See specifications table. If you are unable to lift that much weig
Summary of the content on the page No. 16
II. SAFETY Transfers Transferring onto and off of your power chair requires a good sense of balance. Always have an attendant or health- care professional present while learning to properly trans- fer yourself. To eliminate the possibility of injury, Pride recommends that you or a trained attendant perform the following tasks be- fore attempting a transfer: ! Turn off the power to the controller. ! Ensure your power chair is not in freewheel mode. See III. “Your Power Chair.” ! Turn the caster w
Summary of the content on the page No. 17
II. SAFETY WARNING! Pride strongly recommends that you do not smoke cigarettes while seated in your power chair, although the power chair has passed the necessary testing requirements for cigarette smoking. You must adhere to the following safety guidelines if you decide to smoke cigarettes while seated in your power chair. ! Do not leave lit cigarettes unattended. ! Keep ashtrays a safe distance from the seat cushions. ! Always make sure cigarettes are completely extinguished before disposal. E
Summary of the content on the page No. 18
III. YOUR POWER CHAIR THE QUANTUM 6000Z SERIES The Quantum 6000Z Series has two main assemblies: the seat assembly and the power base assembly. See figure 5. Typically, the seat assembly includes the armrests, seatback, and seat base. The power base assembly includes two motor/ brake assemblies, two drive wheels, four caster wheels, two batteries, and wiring harnesses. See figures 5, 6, and 7. SEATBACK SEAT ASSEMBLY ARMREST JOYSTICK CONTROLLER (Q-LOGIC SHOWN) SEAT BASE POWER BASE ASSEMBLY CASTER
Summary of the content on the page No. 19
III. YOUR POWER CHAIR QUANTUM 6000Z SERIES SPECIFICATIONS Suspension: Active-Trac ATX with integrated rear dual-strut suspension and articulating caster beam Drive Wheels: 14 in. (35.56 cm), pneumatic (14 in. (35.56 cm) solid optional) Caster Wheels: 6 in. (15.24 cm) solid Maximum Speed:¹ Up to 6 mph (9.66 km/h) (standard in Group 3) Up to 8 mph (12.87 km/h) (standard in Group 4; optional in Group 3) Brakes: “Intelligent Braking” electronic regenerative, disc park brake Ground Clearance:² 3.5 in
Summary of the content on the page No. 20
III. YOUR POWER CHAIR REAR SEAT MOUNT CONNECTORS FRONT SEAT MOUNT CONNECTORS REAR SHROUD REAR SHROUD FASTENER (FASTENER ON OPPOSITE SIDE NOT SHOWN) FRONT COVER MANUAL FREEWHEEL LEVER Figure 6. The Quantum 6000Z Series Power Base Electrical Components The electrical components consist of the controller assembly, the batteries, and the motors. The batteries, motors, and controller power module (if equipped) are located on the power base assembly. The controller is located on the seat assembly. Con
Summary of the content on the page No. 1
QUANTUM
6000Z SERIES
INNOVATIVE REHAB SOLUTIONS
Including Models: Quantum 6000Z 3S, Quantum 6000Z 3SP, Quantum 6000Z 3MP,
Quantum 6000Z 4S, Quantum 6000Z 4SP, and Quantum 6000Z 4MP
1-800-800-8586 (US) 1-888-570-1113 (Canada)
Summary of the content on the page No. 2
SAFETY GUIDELINES WARNING! A Quantum Rehab specialist or a qualified technician must perform the initial setup of this power chair and must perform all of the procedures in this manual. The symbols below are used throughout this owner's manual and on the power chair to identify warnings and important information. It is very important for you to read them and understand them completely. WARNING! Indicates a potentially hazardous condition/situation. Failure to follow designated procedures can ca
Summary of the content on the page No. 3
CONTENTS I. INTRODUCTION.................................................................................................................................4 II. SAFETY .................................................................................................................................................6 III. YOUR POWER CHAIR ....................................................................................................................18 IV. ASSEMBLY..................................
Summary of the content on the page No. 4
I. INTRODUCTION SAFETY WELCOME to Quantum Rehab, a division of Pride Mobility Products Corporation (Pride). The power chair you have purchased combines state-of-the-art components with safety, comfort, and styling in mind. We are confident that these design features will provide you with the conveniences you expect during your daily activities. Once you understand how to safely operate and care for your power chair, it should give you years of trouble free operation and service. Read and follow
Summary of the content on the page No. 5
I. INTRODUCTION PRIDE OWNERS CLUB As an owner of a Pride product, you are encouraged to enroll in the Pride Owners Club. Complete and return your enclosed product registration card or visit Pride’s web site at www.pridemobility.com. From our home page, select “Owners Club” to enter a page dedicated to current and potential Pride product owners. You will gain access to interviews, stories, recreation ideas, daily living tips, product and funding information, and interactive message boards. These
Summary of the content on the page No. 6
II. SAFETY PRODUCT SAFETY SYMBOLS The symbols below are used on the power chair to identify warnings, mandatory actions, and prohibited actions. It is very important for you to read and understand them completely. Read and follow the information in the owner’s manual. Do not allow unsupervised children to play near the power chair while the batteries are charging. Maximum seating weight. Keep your hands away from the tires when driving. Be aware that loose fitting clothing can become caught in d
Summary of the content on the page No. 7
II. SAFETY Do not lift the mobility vehicle while seated in it. Do not lift the mobility vehicle while seated in it. Do not connect an extension cord to the AC/DC converter or the battery charger. Removal of grounding prong can create electrical hazard. If necessary, properly install an approved 3-pronged adapter to an electrical outlet having 2-pronged plug access. Wear safety goggles. Corrosive chemicals contained in battery. Quantum 6000Z Series www.quantumrehab.com 7
Summary of the content on the page No. 8
II. SAFETY EMI-RFI - This product has been tested and passed at an immunity level of 20 V/m. Explosive conditions exist! Use only AGM or Gel-Cell batteries to reduce the risk of leakage or explosive conditions. Keep tools and other metal objects away from battery terminals. Battery Set Configuration: + + + + + = Positive (Red) Terminal Post - = Negative (Black) Terminal Post Connect Red wire to Red Positive (+) Terminal Post Connect Black wire to Black Negative (–) Terminal Post Do not use batt
Summary of the content on the page No. 9
II. SAFETY Battery charger for indoor use only. Disposal and recycling - Contact your Quantum Rehab Specialist for information on proper disposal and recycling of your Pride product and its packaging. Disposal and recycling - Contact your Quantum Rehab Specialist for information on proper disposal and recycling of your Pride product and its packaging. Locked and in drive mode. Unlocked and in freewheel mode. Do not place power chair in freewheel mode on a decline. Do not place power chair in fre
Summary of the content on the page No. 10
II. SAFETY GENERAL GUIDELINES MANDATORY! Do not operate your new power chair for the first time without completely reading and understanding this owner’s manual. Your power chair is a state-of-the-art life-enhancement device designed to increase mobility. Pride provides an extensive variety of products to best fit the individual needs of the power chair user. Please be aware that the final selection and purchasing decision regarding the type of power chair to be used is the responsibility of th
Summary of the content on the page No. 11
II. SAFETY Weight Limitations Your power chair is rated for a maximum weight capacity. Please refer to the specifications table for this limit. MANDATORY! Stay within the specified weight capacity of your power chair. Exceeding the weight capacity voids your warranty. Pride will not be held responsible for injuries and/or property damage resulting from failure to observe weight limitations. WARNING! Do not carry passengers on your power chair. Carrying passengers on your power chair may affect t
