Summary of the content on the page No. 1
f
Save this manual
for future reference
I
SEARS
owner's
manual
Stock No.
42-14415
Model No.
758.144151
_J
®
QUIET COMFORT
WHOLE HOUSE
HUMIDIFIER
13 Gallon Output
FOR YOUR
SAFETY: Innovative Twin Fan
R EAD
Technology
ALL INSTRUCTIONS
CAREFULLY
• Operating Instructions
• Parts List
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
Part NO, SP6327 Printed in Canada
Summary of the content on the page No. 2
GENERAL SAFETY INSTRUCTIONS Safety Signal Words 4 Keep the humidifierclean. 5. Do not put foreign objects inside the DANGER: means if the safety information humidifier. is not followed, someone will be seriously 6. Never use your humidifier while any part injured or killed. is missing or damaged in any manner. WARNING: means ifthe safety information 7. To reduce the risk of electrical hazard or is not followed, someone could be serious- damage to humidifier, do not tilt, jolt or ly injured or ki
Summary of the content on the page No. 3
Know Your Humidifier, Control Panel Cover & Pivoting Lid Removed for Clarity Desired Humidity Fan Assembly Controls Light \ Bottles Fill L Filter Filters: 42-14415 Description 13 Gallon Output/24 Hrs. 2-3/8 Gallons Each Capacity of Bottles 2700 Sq. Ft. Coverage Fan Speeds 3 Filters 4 Yes Fill Light Yes Desired Humidity Light Automatic Humidistat Yes Controls Rotary CUL Listed Yes AHAM Certified Yes Volts 120 A.C. Hertz 60 Amps 2.88 Watts 165 Based on an area with average insulation and an 8 foot
Summary of the content on the page No. 4
Humidifier Operations Your new Sears humidifier is designed to Humidified Air is Then Released satisfy home humidity requirements Through the Top through the principle of evaporation of water in the air. After water is added to the bottle, the fil- ii'f,liil ters begin to soak up the water and Dry Air Enters become totally saturated in approximately 30 minutes. Air is drawn in from the rear of the humidifier and through the filters by means of circulation fans. As air passes through the filter
Summary of the content on the page No. 5
Location Instructions (continued) NOTE: Due to release of cool, moist air Step 2 The humidifier should be positioned withthe from humidifier, it is best to direct air away from home thermostat and hot air registers. back (cord exit side), at least 2 inches away It is best to position humidifier next to an from the wall. Air needs to enter through the Iouvres in the rear panel in order for the inside wall. Hot air registers and cold air from outside walls can affect the efficiencies humidifier to
Summary of the content on the page No. 6
Water Fill (continued) Notice the water bottles are designed as right and left hand units. Position them in the correct location so the humidifier can function properly. The water bottles should rest in the front of the cabinet. Each "E-Z- Fill Side-Cap" must be facing the rear of the unit. ___-'_ Rear of Each water bottle is designed with an =E- Z-Fill Side-Cap" that is easily removable, Remove the =E-Z-Fill Side-Cap" on the ,_ _"'_ Humidifier side of the water bottle by twisting coun- "E-Z-Fil
Summary of the content on the page No. 7
Operating Humidifier Controls The operating controls of your Kenmore Fill Light Quiet Comfort whole house humidifier are When the humidifier is almost out of water, located on the top center of the humidifier. the Fill light will come on and the fans will The controls are found under the smoked automatically shut off. control cover, located between the air cir- culating fans. eoO°e °°oo Lift the control cover by placing your finger in the round cutout and lifting. The cover e 0 MAX will stay ope
Summary of the content on the page No. 8
Using Your Humidifier Step 4 Step 1 Be sure humidifier is full of water and If humidifier stops running and the "Desired Humidity" indicator is illuminated, the plugged in. humidity level is at the normal require- Step 2 ments for that setting or it is adjusting to to 1. Set Speed Control _(_ the home conditions• The chart below shows recommended indoor humidity lev- Step 3 els.The figure below shows approximate to medium Set Humidity Control _'_ relative humidity percentages which corre- positi
Summary of the content on the page No. 9
Replacement and Care of Filters WARNING: To reduce the risk of shock] or injury from moving parts, always| unplug humidifier before removing or/ replacing any parts. | CAUTION: To help retard bacteria growth and keep maximum efficiency, the filters should be replaced at least once per season, or more often under hard water conditions. Use Sears rec- ommended replacement filter 42-14911. _,llfilters may be dnsed in clear water onl Fake care not to damage paper. To replace _vaporative wicking filt
Summary of the content on the page No. 10
Replacement and Care of Filters (continued) m c, Install new filters in the filter housing track with the glue beads of the wick- Fixed Tabs ing pad to the inside of the filter hous- ing. d. Return the top cover of the filter Spring Tabs _J housing by installing the cover over the fixed tabs on the rear of the lower filter housing and pivoting the cover down over the top of the filters, Snap the cover over the two spring tabs. e. Replace the filter housing in the cab- inet. Note: There is a left
Summary of the content on the page No. 11
Cleaning Your Humidifier WARNING: To reduce the risk of Step 2 injury, fire or damage to humidifier, To Remove Parts use only cleaners specifically rec- a. Open the pivoting lid and remove water ommended for humidifiers. Never bottles and set aside. Grasp the fan use flammable, combustible or poi- assembly front center and rear center. sonous materials to clean your Lift off and set aside on a clean flat sur- humidifier. To reduce the risk of face. The filter housings are now scalds and damage t
Summary of the content on the page No. 12
Cleaning of Humidifier (continued) End of Season Maintenance Bi-Weekly Maintenance Removing Scale 1. Follow "Bi-Weekly Maintenance" instructions at end of humidification 1. Fitl the humidifier cabinet with one 8 season. oz. cup of undiluted white vinegar. Let solution stay 20 minutes. 2, Remove and throw away filters. 2, Clean all interior surfaces with a soft 3. Let humidifier dry completely before brush. Dampen a soft cloth with undi- storing. Do not store with water inside cabinet or water bo
Summary of the content on the page No. 13
Troubleshooting Trouble Probable Cause Remedy • No Power. Unit will not run and neither • Check 120 volt power source. controlpanel light is illuminated, Unit will not shut off. • Slide float retainer down to • Float retainer is positioned in "Manual Dryout" position. normal operation mode. Refer to "Manual Dryout" • Float is not free. section on page 7. Free float from obstruction. • Float is positioned in This is normal. A small Unit will not dry out amount of water remains in completely. norm
Summary of the content on the page No. 14
28 27 24 23
Summary of the content on the page No. 15
Key Part No. Description Key Pad No. Description No. No, 1 823884 18 509229-1 Cover, Dust Cap, Valve Assembly 2 823730 Cabinet 19 828199-1 Lid, Stationary 3 823724-1 20 823726 Lid, Pivoting Rail, Kick O 4 828381 Knob 21 STD601107 * Screw, Pan Hd. Ty "AB" #10 x 3/4 z == 5 828429 Label, Control 22 828515 Caster, Twin Wheel c 6 8264OO 23 823849 Cover, Control Support, Filter Lower 7 823912 Switch, Rotary 24 42-14911 1"Filter,Evaporative 8 825858 25 828197 Light, Fill Support, Upper L.H. Filter 9 82
Summary of the content on the page No. 16
Forthe repair or replacementpartsyouneed Call7 am - 7 pm, 7 days a week 1-8OO-366-PART (1-800-366-7278) For in-home major brandrepair service Call 24 hours a day, 7 days a week 1-800-4-REPAIR (1-800-473-7247) Forthe locationof a Sears Repair Service ,_pm_h , Centerin yourarea Call 24 hours a day,7 days a week 1-800-488-1222 For information on purchasinga Sears MaintenanceAgreementor to inquire about an existingAgreement Call 9 am - 5 pm, Monday-Saturday 1-800-827-6655 SEARS ,4r_eijca S V]ep_r Sp
