Summary of the content on the page No. 1
2050PSI
Owner’s Manual / Manual del Propietario
Questions? Help is just a moment away!
Preguntas? La ayuda es justa un momento lejos!
Call: Pressure Washer Helpline
Llame: Línea Directa del Lavador a Presión - 1-800-743-4115 M-F 8-5 CT
CleanShot™ is a trademark of Briggs & Stratton Power Products.
CleanShot™ es una marca registrada de Briggs & Stratton Power Products.
BRIGGS & STRATTON POWER PRODUCTS GROUP, LLC
JEFFERSON,WISCONSIN, U.S.A.
Model No. 020206-0 (2050 PSI Pressure Washer) Manual
Summary of the content on the page No. 2
CleanShot™ 2050 PSI Pressure Washer TABLE OF CONTENTS SAFETY RULES Safety Rules. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4 This is the safety alert symbol. It is used to Know Your Pressure Washer. . . . . . . . . . . . . . . . . . . . . . . . 5 alert you to potential personal injury hazards. Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7 Obey all safety messages that follow this Operation . . . . . . . . . . . . . . . . . .
Summary of the content on the page No. 3
CleanShot™ 2050 PSI Pressure Washer DANGER WARNING Running engine gives off carbon monoxide, an Fuel and its vapors are extremely flammable an odorless, colorless, poison gas. explosive. Some chemicals or detergents may be harmful if Fire or explosion can cause severe burns or inhaled or ingested, causing severe nausea, death. fainting or poisoning. WHEN ADDING FUEL Breathing carbon monoxide will cause nausea, Turn pressure washer OFF and let it cool at least 2 minutes fainting or death. befor
Summary of the content on the page No. 4
CleanShot™ 2050 PSI Pressure Washer WARNING CAUTION Excessively high or low operating speeds increase risk Running engines produce heat and hot exhaust of injury and damage to pressure washer. gases.Temperature of muffler and nearby areas can reach or exceed 150°F (65°C). DO NOT tamper with governed speed. Fire or severe burns can occur. DO NOT operate pressure washer above rated pressure. DO NOT touch hot surfaces. CAUTION Stay clear of exhaust gases. A pressure washer produces a high p
Summary of the content on the page No. 5
CleanShot™ 2050 PSI Pressure Washer KNOW YOUR PRESSURE WASHER Read this owner’s manual and safety rules before operating your pressure washer. Compare the illustrations with your pressure washer to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Recoil Starter Air Cleaner Primer Bulb High Pressure Outlet & Water Inlet Fuel Tank Pump equipped with Automatic Cool Down System Data Tag (not shown, near rear of base plate) – Air Cle
Summary of the content on the page No. 6
CleanShot™ 2050 PSI Pressure Washer Required Assembly Tools NO Tools Required for Assembly ASSEMBLY PREPARING PRESSURE IMPORTANT: Read entire owner’s manual before you WASHER FOR USE attempt to assemble or operate your new pressure washer. If you have any problems with the assembly of your Remove Pressure Washer From pressure washer or if parts are missing or damaged, call the pressure washer helpline at 1-800-743-4115. If calling for Carton assistance, please have the model, revision, and seria
Summary of the content on the page No. 7
CleanShot™ 2050 PSI Pressure Washer 4. Run water through your garden hose for 30 seconds Connect Hose and Water Supply to to clean out any debris. Pump IMPORTANT: DO NOT siphon standing water for the IMPORTANT: To avoid pump damage, you must assemble water supply. Use ONLY cold water (less than 100°F). the nozzle extension to the spray gun and attach all hoses 5. Connect the garden hose (not to exceed 50 feet in before you start the engine. length) to the water inlet.Tighten by hand (Figure 3).
Summary of the content on the page No. 8
CleanShot™ 2050 PSI Pressure Washer 7. Engage safety latch to spray gun trigger (Figure 5). HOW TO USE YOUR Figure 5 — Spray Gun with Safety Latch Engaged PRESSURE WASHER If you have any problems operating your pressure washer, Safety Latch please call the pressure washer helpline at 1-800-743-4115. How to Start Your Pressure Washer 8. Start engine according to instructions given in engine owner’s manual. To start your pressure washer for the first time, follow these instructions step-by-step.Th
Summary of the content on the page No. 9
CleanShot™ 2050 PSI Pressure Washer 5. If you get spray nozzle too close, especially using high Figure 6 — Adjusting Nozzle for Pressure pressure mode, you may damage surface being cleaned. 6. DO NOT get closer than 6 inches when cleaning tires. Using the Turbo Nozzle The turbo nozzle rotates the high pressure stream in a rapid circular pattern.The high pressure spray is most effective when the tip of the nozzle extension is held between 8 to 24 inches from the surface being cleaned. CAUTION Sli
Summary of the content on the page No. 10
CleanShot™ 2050 PSI Pressure Washer 4. Attach the brush with the adapter to the spray gun. 7. Allow detergent to "soak in" for 3-5 minutes before Tighten by hand (Figure 10). washing and rinsing. Reapply as needed to prevent surface from drying. DO NOT allow detergent to dry Figure 10 - Attaching Utility Brush to Spray Gun on (prevents streaking). IMPORTANT: You must flush the chemical injection system after each use by placing the filter into a bucket of clean water, then run the pressure washe
Summary of the content on the page No. 11
CleanShot™ 2050 PSI Pressure Washer SPECIFICATIONS PRESSURE WASHER Outlet Pressure . . . . . 2050 psi MAINTENANCE Flow Rate . . . . . . . . . . 2.0 gallons per minute (gpm) Detergent . . . . . . . . . . Use detergent approved for Check and Clean Inlet Screen pressure washers Examine the screen on the water inlet. Clean it if the Water Supply . . . . . . Not to Exceed 100°F screen is clogged or replace it if screen is damaged. Temperature Automatic Cool . . . . Will cycle when water Check High
Summary of the content on the page No. 12
CleanShot™ 2050 PSI Pressure Washer 2. Pull trigger on spray gun and hold. Nozzle Maintenance 3. When water supply is steady and constant, engage A pulsing sensation felt while squeezing the spray gun safety latch. trigger may be caused by excessive pump pressure.The principal cause of excessive pump pressure is a nozzle To remove contaminants from the pump, follow clogged or restricted with foreign materials, such as dirt, these steps: etc.To correct the problem, immediately clean the orifice 1
Summary of the content on the page No. 13
CleanShot™ 2050 PSI Pressure Washer 6. Reinstall orifice and in-line filter into nozzle extension. 2. Use a 8mm allen wrench to remove black pump oil DO NOT overtighten orifice with allen wrench. cap between high pressure outlet and garden hose inlet (Figure 14). 7. Reconnect nozzle extension to spray gun. Figure 14 - Changing Pump Oil 8. Reconnect water supply, turn on water, and start engine. 9. Test pressure washer by operating with nozzle in high and low positions. Oil Cap O–Ring Maintenance
Summary of the content on the page No. 14
CleanShot™ 2050 PSI Pressure Washer NOTE: PumpSaver is available as an optional accessory. It PREPARING THE UNIT is not included with the pressure washer. Contact the nearest authorized service center to purchase PumpSaver. FOR STORAGE Water should not remain in the unit for long periods of CAUTION time. Sediments or minerals can deposit on pump parts and “freeze” pump action. If you do not plan to use the You must protect your unit from freezing temperatures. pressure washer for more than 30 da
Summary of the content on the page No. 15
CleanShot™ 2050 PSI Pressure Washer TROUBLESHOOTING Problem Cause Correction 1. Nozzle in low pressure mode. 1. Pull nozzle backward for high pressure mode. 2. Water inlet is blocked. 2. Clear inlet. 3. Inadequate water supply. 3. Provide adequate water flow. 4. Inlet hose is kinked or leaking. 4. Straighten inlet hose, patch leak. Pump has following problems: 5. Clogged inlet hose strainer. 5. Check and clean inlet hose failure to produce pressure, erratic strainer. pressure, chattering, loss o
Summary of the content on the page No. 16
CleanShot™ 2050 PSI Pressure Washer EXPLODED VIEW AND PARTS LIST – MAIN UNIT Item Part # Description Item Part # Description 1 194494GS ASSY, BASE 7 193482GS GUN 2 B5693GS HOSE 8 194344DGS ASSY,Wand, Hi-Lo 3 19525GS KIT, Pump/Engine Mounting 9 194343BGS ASSY,Wand,Turbo Hardware 10 B1236DGS ORFICE 4 88935GS ADAPTER, Extension Brush 11 23139GS KEY 5 192310GS KIT,Vibration Mount 12 194216GS ASSY, Pump (see page 17) 6 88185GS BRUSH, Utility 900 NSP ENGINE Items Not Illustrated: Part # Description 19
Summary of the content on the page No. 17
CleanShot™ 2050 PSI Pressure Washer EXPLODED VIEW AND PARTS LIST – PUMP Item Part # Description Item Part # Description 19 190571GS CAP, Oil A NSP ASSY, CASE, PISTON 28 190627GS MANIFOLD B 190632GS KIT,WATER INLET,ALUM 29 190575GS O-RING C 190634GS KIT, OUTLET,ALUM 30 190576GS SCREW E 190591GS KIT,CHECK VALVES 34 190577GS CONNECTION, Chemical Inlet F 190592GS KIT, INLET CHECK 45 190578GS PIN G 190593GS KIT, CHEMICAL INJECTION 46 190629GS VALVE, Seat Plate, Plastic H 190628GS KIT, UNLOADER STEM 4
Summary of the content on the page No. 18
CleanShot™ 2050 PSI Pressure Washer NOTES 18
Summary of the content on the page No. 19
BRIGGS & STRATTON POWER PRODUCTS GROUP, LLC EQUIPMENT OWNER WARRANTY POLICY Effective January 1, 2003 replaces all undated Warranties and all Warranties dated before January 1, 2003 LIMITED WARRANTY Briggs & Stratton Power Products Group, LLC will repair or replace, free of charge, any part(s), of the equipment that is defective in material or workmanship or both. Transportation charges on parts submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is
Summary of the content on the page No. 20
Lavadora de Presión 2050 PSI de CleanShot™ TABLA DE CONTENIDOS REGLAS DE SEGURIDAD Reglas De Seguridad . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20-22 Éste es el símbolo de alerta de seguridad. Sirve Conozca Su Generador . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 para advertir al usuario de un posible riesgo para Ensamblaje . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-25 su integridad física. Siga todos los mensa
