Summary of the content on the page No. 1
The Big Caboose Stand-On Triple
Instruction Manual
43X Series
Patent No. 5,622,375
Joovy • 2919 Canton Street • Dallas, TX 75226 • (877) 456-5049 • Fax: (214) 761-1774
E-mail: customerservice@joovy.com • Website: www.joovy.com
Summary of the content on the page No. 2
! WARNINGS ! Please read this instruction manual completely before using this stroller. Keep these instructions for future reference. • Failure to follow these instructions could result in serious injury or death. • Never leave child unattended. • Avoid serious injury from falling or sliding out. • Always use safety belts and ensure that all children are positioned according to these instructions. • Keep all small parts out of reach of children while assembling the stroller.
Summary of the content on the page No. 3
Assembling and Using your Stroller ! To ensure safe operation of your stroller, please follow these instructions carefully. Unpacking the Product • Carefully remove stroller and all parts from the box and plastic bag. • Identify the parts (stroller, front wheels (2), rear wheels (2), canopy (2), tray (2), car seat carrier support (2), rear axle, small washer (2), large washer (4), spring washer (2), snap pin (2), hub cap (2), red plastic cap, and documents) with the pictures in Figures 1a and
Summary of the content on the page No. 4
Unfolding the Stroller • Keep children away from stroller while unfolding. • Position the stroller with the handle bar closest to you. • Release the locking latch located on the right side by lifting the lever off of the extended rivet. See Figure 2. • Lift up slightly on the handle of the stroller. Then place one foot onto the rear platform and pull up and back on the handle until both side frame bars snap into their locking positions in the frame. CAUTION: While unfolding the stroller, be c
Summary of the content on the page No. 5
• Push the axle across and into the axle hole on the other side of the stroller. NOTE: you may need to guide the axle into this hole. • Slide one small washer over one end of the axle. • Next place a rear wheel over the the small washer. NOTE: The brake teeth on the wheel should be facing inward toward the red brake lever AND the arrow shapes on the tire tread should point toward the handlebar. • Then place one large washer over the axle. • Next slide a spring washer over the end of th
Summary of the content on the page No. 6
Front Wheel Locks The front wheels can be either in swivel mode or locked mode. • To put the front wheels in their locked mode, first rotate each wheel set so that the wheels are pointed straight ahead. • Pull up on the lever to engage the small tab on the lever with the slot in the plastic frame sleeve. The lever can be either facing forward or rearward to lock the wheels. See Figure 6. • To unlock the wheels and put them into swivel mode, push down on the lever to disengage Figure 6 th
Summary of the content on the page No. 7
Figure 7 Figure 8 Figure 9 Figure 10 ! WARNING Possible pinching hazard - Be careful when closing and opening the side hinges so as not to pinch your fingers. Attaching/Detaching the Front Tray The following instructions apply to BOTH Trays • To attach the front tray, line up the female fittings on the tray with the male fittings on each side of the stroller just in front of the seat and push inward until the fittings snap into place. See Figure 11. Pull outward on both sides of the tray to
Summary of the content on the page No. 8
Rear Wheel Brakes • Before placing any child into the stroller or removing them from the stroller, be certain that the rear wheel brakes are engaged. • To engage the rear wheel brakes, push down on the brake lever located on each rear wheel. See Figure 13. The stroller may require slight forward or rearward movement in order to line up the teeth on the brake with each wheel brake cluster. • Check that the brakes are properly applied by attempting to push the stroller backward and forward.
Summary of the content on the page No. 9
Securing a Child in Either Front Seat • Ensure that the two snaps on both armrest pads that hold the seat onto the frame are securely snapped together. • Ensure that both shoulder straps are attached to the waist strap buckles. See Figure 17. • Unlatch the waist/shoulder buckle by squeezing the latch releases on both sides of the buckle and removing the male ends of each buckle. • Carefully place the child in the stroller seat with the shoulder straps over their shoulders and chest. Then pla
Summary of the content on the page No. 10
Seatback Positioning Each front seat has two positions. The fully upright position should only be used for a child that is at least 6 months old. • To place the seat in the upright position, push the bar on the rear of the seat toward the front of the stroller and rotate the seatback towards the front of the stroller until this bar is locked in its LOWEST position. See Figure 21. • To recline the seat, pull the bar on the rear of the seat toward the rear of the stroller and rotate the seatba
Summary of the content on the page No. 11
Storage Basket The maximum weight that can be carried in the storage basket is 10 pounds. Excessive weight may result in a hazardous unstable condition. You can access the storage basket by sliding the ear bench seat forward or backward. Using the Rear Bench Seat • Push the bench seat to its most rearward position. • NOTE that there are webbing straps attached to the bottom of the rear seat pad. These straps will lock the seat into the most rearward position. To lock the seat, pull the str
Summary of the content on the page No. 12
Using the Stroller as an Infant Car Seat Carrier The Big Caboose will accommodate a car seat carrier in EACH of the front seating locations. Follow the same instructions for each seat if two car seats are to be installed. • To use the stroller to carry an infant car seat carrier, you must replace the Front Tray with the Car Seat Carrier Support. • Remove the Front Tray by pressing in on Figure 25 the lock tabs and pulling the tray off the brackets. Store the tray in a convenient place f
Summary of the content on the page No. 13
! WARNING ALWAYS install the infant carrier so that the child is facing toward the rear (handle) of the stroller with the restraining straps secured. ALWAYS position the infant carrier so that it is securely placed down inside the Car Seat Carrier Support frame. ALWAYS position the infant carrier so that it is resting ON the seatback, but NOT on the top of the seatback. NEVER position the carrier restraining straps on or near the child’s neck as this may result in strangulation. Right Way Ri
Summary of the content on the page No. 14
! IMPORTANT NOTE When using your stroller as an infant car seat carrier, the following are the compatible infant car seat models that the Big Caboose Stand-On Triple will accommodate: • Evenflo® Embrace™ • Baby Trend® Latch-Loc and Flex-Loc • Britax® Companion™ • Graco® Safe Seat™ • Chicco® Key Fit Car Seat • Graco® Snug Rider™ Series • Combi® Centre Series • Maxi Cosi Mico • Peg Perego® Primo Viaggio • Combi® Connection • Peg Perego® Primo Viaggio SIP • Compass® Light and Portable Infant
Summary of the content on the page No. 15
Figure 30 Maintenance All of the fittings, snaps, locks, rivets, and other hardware and plastic parts on the stroller should be inspected periodically to ensure that they are secured properly and not damaged or malfunctioning. The seat belts and safety harnesses, as well as all other straps and fabric items and their stitching should also be inspected periodically to ensure that they are secured properly and not loose, torn or otherwise damaged. All moving parts, such as wheels, brakes, and
Summary of the content on the page No. 16
SATISFACTION GUARANTEED We want you to be completely satisfied with your purchase of this product. Should you experience any difficulty in assembling or using this product, or if you have any questions, please contact our Customer Service Department at (877) 456-5049 between the hours of 8:30 am and 5:00 pm Central Time. Deluxe neoprene parent organizer 2 Cupholders Zipperedpocket Three additional pockets Notools needed for installation Reversible two-sidedseat pad. COOL
Summary of the content on the page No. 17
Custom raincover for both children Zipperedbutton hole pass through for front seat Custom sun filter for both children’s comfort Zippered button hole pass throughfor front seat Protects frominsects Page 15 The Big Caboose Stand-On Triple Instruction Manual Page 16
Summary of the content on the page No. 18
Please log onto www.joovy.com to register your new Joovy product. Look for these other Joovy products Page 17 Page 18 The Big Caboose Stand-On Triple Instruction Manual
Summary of the content on the page No. 19
h t e B n a i c k s , e o r d S Page 17 Page 18 The Big Caboose Stand-On Triple Instruction Manual i i R t s i l n l t o h e D F r o r n t! u o Y
Summary of the content on the page No. 20
2919 Canton Street • Dallas, TX 75226 • (877) 456-5049 • Fax: (214) 761-1774 E-mail: customerservice@joovy.com • Website: www.joovy.com ©Joovy 2008 • Document Version 1.1
