Summary of the content on the page No. 1
42" WOODBURNING FIREBOX
Model C42EC2 Circulating (Louvered)
INSTALLATION INSTRUCTIONS
SAVE THIS BOOK
Model ________________________________
This book is valuable. In addition to instructing you
on how to install and maintain your appliance, it also
Serial No. _____________________________
contains information that will enable you to obtain
replacement parts or optional accessory items when
Date Purchased ________________________
needed. Keep it with your other important papers.
22"
1
17 /2"
3
37
Summary of the content on the page No. 2
MINIMUM CLEARANCES TO COMBUSTIBLES FOR YOUR SAFETY Framing and enclosures may safely make direct contact with the • Do not store or use gasoline or any other flam- spacers on the top of the firebox. The firebox may sit directly on mable vapors or liguids in the vicinity of this or combustible flooring (see Step 4, below). The firebox opening must any other appliance. not be less than 24 inches from combustible materials and the chimney • Due to high temperatures, the appliance should 1 must be a
Summary of the content on the page No. 3
FIRESTOP SPACERS 3 15 /8" Firestop spacers are required at each point where the chimney penetrates a floor or ceiling joist space. Their purpose is two fold, they establish and maintain the required clearance between the 5 46 /8" chimney and combustible materials, and provide complete separa- 33" tion from one floor space to another floor or attic space as required by most codes. When penetrating a floor or ceiling at an angle, 5 12 /8" firestop in pack should be used. When the double wall pipe
Summary of the content on the page No. 4
FOR ROUND TOP TERMINATION ON ROOF EXISTING “J” BOX IN FIREPLACE STEP 1: Slide the flashing over the pipe (no firestop is needed at the COVER PLATE WITH roof level). Tack the flashing down at the top two corners with STRAIN RELIEF roofing nails. Lay roofing over the top and sides of the flashing and TO WALL SWITCH secure them to the roof through the flashing with roof nails. Place 10', 14 GA. W/GROUND ROMEX ADDED TO U.L. roofing under the lower edge and secure to the roof. LISTED (MM11306) WIRE N
Summary of the content on the page No. 5
Appliances for Installation in solid Fuel burning Fireplaces, GAS LINE ANS Z21.60-1996 and shall also be installed in accordance with the A gas line may be installed for the purpose of installing a decorative National Fuel Gas code, ANS Z223.1-1996. gas appliance available through your local distributor. Use only 1/2" black iron pipe and appropriate fittings. When installing a gas line, WARNING: When using a decorative appliance, the a shut-off valve designed for installation outside the firebox
Summary of the content on the page No. 6
COMBUSTIBLE AIR KIT MANTEL An Air kit is available for use as an optional accessory. The outside A mantel may be installed if desired. See Figures 17A or 17B for air vent can be installed through an outside wall or a ventilated crawl minimum heights above and beyond opening of the fireplace face. space. Attach flex tube (CLASS 1) to air vent and air inlet tube. Seal Woodwork, such as wood trim and mantels, and other combustible with duct tape (see Figure 14). For air inlet tube installation (se
Summary of the content on the page No. 7
INSTRUCTIONS WHEN OFFSET OF CHIMNEY IS OFFSETS AND RISE NEEDED A B 48 36 18 12 A B 48 36 18 12 12S 3 3 1 1 To Install Elbows 4 /8 16 /8 41 /4 80 /4 111 1 1. To achieve desired offset, you may install combinations of 12", 3 1 3 9 /4 25 /2 1 45 86 /4 21 18", 36", and 48" lengths of double wall pipe (see Offsets and 3 3 3 1 12 /4 30 /4 1 46 /4 89 /21111 Rise chart and Figures 18 and 20). 3 15 34 /4 2 51 97 11 1 2. Chimney weight above offset rests on return elbow. Straps must be securely nailed to
Summary of the content on the page No. 8
COMPONENT PARTS REPLACEMENT PARTS CRTL-8DM CRTL-8DM CRTL-8DM TOGGLE CHIMNEY PACK SWITCH FIRESTOP CSC1-20-8DM CFS-8DM C6F-8DM DELUXE BLOWER KIT CBK3 ROUND TOP TERMINATION CRTL-8DM MINIMUM CFS-8DM HEIGHT 16 FT. STORM GLASS DOOR COLLAR KIT CSC1-20-8DM CDG42E OUTSIDE AIR KIT FLASHING CAK4E MAXIMUM HEIGHT ROOF PITCH 60 FT. C6F-8DM - 0 to 6/12 DOUBLE WALL CHIMNEY DOUBLE WALL 30° ELBOW SET C30E-8DM C12-8DM CFS-8DM ADJUSTABLE HOOD GA6050 (Black) GA6052 (Polished Brass) GRATE 42E GR (Provided) GA6053 (An
