Summary of the content on the page No. 1
OWNER’S MANUAL
Room Air Heat Pump
with R-410A:
RAH-183G
Heat Controller, Inc. • 1900 Wellworth Ave. • Jackson, MI 49203 • (517)787-2100 • www.heatcontroller.com
Summary of the content on the page No. 2
Summary of the content on the page No. 3
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual TM Comfort Zone Room Air Conditioner & Heat Pump Use and Care Manual Contents Introduction ............................................................. 1 Introduction .................................................................. 1 Safety Information .................................................. 1 Safety Information ....................................................... 1 Normal Care & Maintenance Electrical Requireme
Summary of the content on the page No. 4
Owner’s Manual Room Air Heat Pump with R-410A Heat Controller, Inc. WARNING WARNING To avoid death, personal injury or property HIGH TEMPERATURE STRESS HAZARD damage due to electrical shock: This room air conditioner is not meant to • Observe all local codes and ordinances. provide unattended cooling or life support • Disconnect electrical power to unit before servicing. for persons or animals that are unable to • Ground appliance properly. react to failure of the product. • Check with a qua
Summary of the content on the page No. 5
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual Unit Plug Receptacle Circuit Rating, Voltage Unit Plug Receptacle Circuit Rating, Voltage Room Heat Pumps Room Heat Pumps Type Required Breaker, Time Rating On Type Required Breaker, Time Rating On Heat pumps work by moving heat instead of creating it. In the Heat pumps work by moving heat instead of creating it. In the Delay Fuse Nameplate Delay Fuse Nameplat
Summary of the content on the page No. 6
Owner’s Manual Room Air Heat Pump with R-410A Heat Controller, Inc. Front Grille and Filter Removal Optional Air Filter Installation The front contains a removable grille that provides easy Remove air filter from plastic bag. Insert three tabs access to the air filter. To clean the filter use one of the on right side of filter into three slots on filter frame. Carefully following methods for filter removal: bow middle of filter until two tabs on filter can be inserted into two slots on filte
Summary of the content on the page No. 7
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual from outer case. Use both hands to grasp basepan and Drain Cup Installation and Use(on some models) pull remaining chassis from outer case. Your air conditioner uses a system where the water removed from the indoor air (condensate) is channeled to the outdoor side of the unit. The outdoor fan blade has a “slinger” ring attached to it that dips into the water and slings the water onto the outdoor coil surface. This is the sou
Summary of the content on the page No. 8
Installation Air Conditioner Instructions Question? Consumer information line (86-756) 8617555(Customer Service Center) BEFORE YOU BEGIN CAUTION: Do not, under any circumstances, cut or remove the third (ground) prong from the Read these instructions completely power cord. and carefully. Do not change the plug on the power cord of this air conditioner. IMPORTANT Save these instructions for local inspector's use. Aluminum house wiring may present special problems consult a qualified electric
Summary of the content on the page No. 9
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual Installation Instructions PARTS INCLUDED Window (Appearance may vary) sash seal Left accordion panel Foam top Top window gasket mounting rail Right accordion panel V-support (2) Window locking Bolt (2) & nuts (2) bracket (2) Type A (6) Type B (4) Type C (7) Type D (6) T Ty yp pe e E E ( ( 4) Type F (2) 7 7
Summary of the content on the page No. 10
Owner’s Manual Room Air Heat Pump with R-410A Heat Controller, Inc. Installation Instructions 1 WINDOW REQUIREMENTS 3 REMOVE THE AIR CONDITIONER FROM THE CASE These instructions are for a standard double-hung window. You will need to Remove the locking screw and locking A Remove the locking screw and lock- modify them for other types of windows. bracket from the lower frame. Save to ing bracket from the lower frame. The air conditioner can be installed reinstall later. Save to reinstall later
Summary of the content on the page No. 11
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual Installation Instructions 5 PREPARE THE CASE 6 INSTALL THE CASE IN THE WINDOW Install the top mounting rail with 4 type B A screws from the inside of the case. Carefully slide the case into the window and A center the case. Lower the window behind Insert the frames for the accordion panels B the top mounting rail. Pull the bottom of the into the top mounting rail and the bottom case forward so that the bottom mounting frame guid
Summary of the content on the page No. 12
Owner’s Manual Room Air Heat Pump with R-410A Heat Controller, Inc. Ins tallation Ins tructions 6 7 INSTALL SUPPORT BRACKETS INSTALL THE CASE INSTALL SUPPORT BRACKETS AND TOP WINDOW FOAM GASKET IN THE WINDOW (cont.) AND THE FOAM TOP WINDOW GAS KET Adjust the leveling bolts and nuts against the D outside wall so that the case has a slight tilt Attach the support brackets with two A to the outside. Tighten nuts with an adjustable type D screws, one on each side. wrench. Use a level; about a 1/2 b
Summary of the content on the page No. 13
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual Ins tallation Ins tructions 8 8 INS INST TALL ALL THE THE AIR CONDITIONER AIR CONDITIONER INSTALL THE AIR CONDITIONER IN THE CASE IN THE CASE IN THE CASE (cont.) IN THE CASE (cont.) Slide the air Pull the coiled power cord from its shipped A G conditioner into position in the air discharge area. Attach the case. Do not the front grille frame to the case by inserting push on the the tabs on the grille frame into the slots contro
Summary of the content on the page No. 14
Owner’s Manual Room Air Heat Pump with R-410A Heat Controller, Inc. Owner’s Manual Room Air Heat Pump with R-410A Heat Controller, Inc. Operating Controls(For Electronic units) Controls Operating your air conditioner properly helps you to obtain the bestO pop sse iblr ea retsiun ltsg . Controls(For Electronic units) Power Pad Controls Operating Controls(For Electronic units) This section explains proper air conditioner operation. Turns air conditioner on and off. Controls Operating your air con
Summary of the content on the page No. 15
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual Cooling Descriptions Timer/Delay OFF—When the air conditioner is on, TIMER OFF—When the air conditioner is on, it can be set to automatically turn off in 0.5 to For Normal Cooling—Select the Cool mode and 24 hours. High or Med fan with a middle set temperature. How to set: For Maximum Cooling—Select the Cool mode and High fan with a lower set temperature. Press the T TIIM M E ER R 1 0.5 –2-4 2 h 4 rhr pad on the unit or TIM
Summary of the content on the page No. 16
Operating Controls(For Mechanical units) COMFORT ZONETM AND HEAT PUMP MODELS Fan Control Temperature Control OFF – Completely shuts off the unit. To prevent blowing Slide this control to the left for a warmer room temperature, fuses, wait two minutes after turning the unit off before to the right for a cooler room temperature. Owner’s Manual Room Air Heat Pump with R-410A Heat Controller, Inc. turning it on again. LOW COOL – Filters and circulates room air with the fan running continuously on
Summary of the content on the page No. 17
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual TB roubleshooting efore Calling Service WARNING To reduce the risk of electric shock, personal injury, or death, turn the fan control to the off position and remove the unit plug from the wall outlet before doing any inspection or maintenance work. The following is a list of problems that are sometimes encountered when using a room air conditioner. Possible cause and suggested remedies are given for each problem. If the problem
Summary of the content on the page No. 18
Owner’s Manual Room Air Heat Pump with R-410A Heat Controller, Inc. THIS PAGE WAS LEFT INTENTIONALLY BLANK 16
Summary of the content on the page No. 19
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual THIS PAGE WAS LEFT INTENTIONALLY BLANK 17
Summary of the content on the page No. 20
07/2010 66129905195 04/2009
