Summary of the content on the page No. 1
CHARNWOOD
Country 8 MkII and Country 12 MkII
Flat Top, Low Canopy & High Canopy
Multifuel Roomheaters
Operating
and
Installation Instructions
Bishops Way, Newport, Isle of Wight, PO30 5WS, U.K.
Tel: (01983) 537799 Fax: (01983) 537788
E-Mail: charnwood@ajwells.co.uk
Summary of the content on the page No. 2
CHARNWOOD COUNTRY 8 Mk II & COUNTRY 12 Mk II Operating and Installation Instructions Contents Operating Instructions Fuels................................................................... 3 Door Operation................................................... 3 Multifuel Grate................................................... 3 Lighting.............................................................. 4 Controlling The Fire........................................... 4 Riddling .......................
Summary of the content on the page No. 3
OPERATING INSTRUCTIONS FOR THE CHARNWOOD COUNTRY 8 MkII & COUNTRY 12 MkII Before lighting the stove check with Airwash Wood Control the installer that the work and checks Closed Open described in the Installation Only dry well seasoned wood should Instructions have been carried out be burnt on this appliance as burning wet unseasoned wood will give rise to Door handle correctly and that the chimney has To Open been swept, is sound and free from heavy tar deposits in the stove, on the Riddle
Summary of the content on the page No. 4
position by moving the tool up until normal and will cease after a short not overfill to prevent fuel from the handle is in the 1 o'clock time, but meanwhile the room should spilling over the top of the front fire position. The grate is put into the be kept well ventilated. bars. wood position by moving the tool At first only light a small fire and Care should be taken especially when down until the handle is in the burn it slowly for two hours to allow burning wood that fuel does not 5 o'clock
Summary of the content on the page No. 5
that it begins to block the passage of withstand high temperatures. Before left ajar. It is also advisable to sweep air into the firebox at the side of the cleaning the glass open the doors and the chimney and clean out the fire. grate. When this is the case do not allow them to cool. Clean the glass Spraying the inside of the doors and remove all of the ash using the using a damp cloth and then wiping firebox with a light oil, such as riddling mechanism but keep a layer over with a dry cloth. A
Summary of the content on the page No. 6
sweep the chimney through the therefore, when lighting the stove blockage, and clean if required. appliance. allow the firebed to become well d) Do not attempt to re-light the established before closing the fire until cause of fume has been First remove the side fire plates, front airslides. This may also be necessary identified, if necessary seek firebars and the throat plate. Then when re-fuelling the stove. professional advice. sweep the chimney ensuring that soot is removed from all horizont
Summary of the content on the page No. 7
INSTALLATION INSTRUCTIONS FOR THE CHARNWOOD COUNTRY 8 MkII & COUNTRY 12 MkII smokeless fuel over a four hourly doubt about the chimney seek expert HEALTH AND SAFETY re-fuelling cycle. advice. PRECAUTIONS CHIMNEY HEARTH AND FIRE Please take care when installing the stove that the requirements of the SURROUND In order for the appliance to perform Health and Safety at Work Act 1974 satisfactorily the chimney height are met. The stove must stand on a fireproof must not be less than 4 metres hearth a
Summary of the content on the page No. 8
The hot water system should be a firebrick. Knock out the knock-outs Soot Door gravity circuit and must be correctly for the boiler tappings in the back of in Side or Rear vented as shown in Fig. 4. the firebox. Of Chimney The steel boiler together with a Remove the backnuts and fibre Register Plate double feed indirect hot water storage washers from the boiler tappings and cylinder to BS:1566 part 1 should be fit the boiler into the appliance. Place used in most situations, unless the the fibre
Summary of the content on the page No. 9
Back of the Stove chimney or in the register plate. Blanking Plate Various types and positions of soot doors are shown in figures 5 to 8. Alternative Soot Door Positions PRE LIGHTING CHECK Clamping Plate Before initial lighting the following Register Plate Blanking Plate with fold horizontal With Soot Door points should be checked :- 1. The bottom grate bars must all be fitted and should move freely and Clamping plate finishes easily when the riddling mechanism flush with inside face of firebox
Summary of the content on the page No. 10
460 106 552 46 Ø154 1072 1012 Country 8 HC (High Canopy) 587 513 322 381 71 299 110 526 513 469 126 552 46 Ø154 Country 8 LC 812 752 (Low Canopy) 587 513 322 381 71 299 110 526 513 461 125 46 508 Ø154 Country 8 FT 699 639 (Flat Top) 587 513 322 381 526 71 299 110 513 Country 8 MkII Dimensions (All dimensions are in mm) Page 10 TW16 3/99
Summary of the content on the page No. 11
480 655 106 Ø154 45 1158 1098 Country 12 HC (High Canopy) 584 462 320 386 210 180 518 489 125 655 Ø154 45 853 Country 12 LC 793 (Low Canopy) 584 462 320 386 210 180 518 468 125 595 Ø154 45 Country 12 FT 718 658 (Flat Top) 584 462 320 386 210 180 616 518 Country 12 MkII Dimensions (All dimensions are in mm) Page 11 TW16 3/99
