Summary of the content on the page No. 1
First Edition
Part No. 18093-E
Printed In U.S.A.
OWNER’S MANUAL
PORTABLE
SPACE HEATERS
PV 060
Models HH35A, HH55, HH110 & HH150A
IMPORTANT: Read and understand this manual before assem-
bling, starting, or servicing heater. Improper use of heater can
cause serious injury. Keep this manual for future reference.
NOTICE: For Servicing Dealer Information see back page.
®
ARL LOGO G 004
Summary of the content on the page No. 2
PORTABLE SPACE HEATER • Use only kerosene or No. 1 fuel oil to minimum safe distance is 10 feet. It is SAFETY avoid risk of fire or explosion. Never use further recommended that these enclo- INFORMATION gasoline, naphtha, paint thinners, alco- sure materials be of a fire retardant na- hol, or other highly flammable fuels. ture. These enclosure materials shall be securely fastened to prevent them from • Fueling WARNINGS igniting or from upsetting the heater a) Personnel involved with fueling shall
Summary of the content on the page No. 3
OWNER’S MANUAL PRODUCT UNPACKING 1. Remove all packing items applied to IDENTIFICATION heater for shipment. 2. Remove all items from carton. Hot Air Outlet Handle 3. Check items for shipping damage. If Upper Shell heater is damaged, promptly inform dealer where you bought heater. Fan Guard Lower Shell Air Filter End Cover Fuel Tank Fuel Cap Side Cover Flame-Out Control Reset Button Power Cord 35/50/70,000 BTU/HR DOMESTIC PFA/PV 042 Figure 1 - 35/55,000 BTU/Hr Models Hot Air Outlet Upper Shell Lo
Summary of the content on the page No. 4
PORTABLE SPACE HEATER 2. Place cap nuts on axle ends. Gently tap ASSEMBLY FUELS with hammer to secure. (For 110,000 and 150,000 BTU/ 3. Place heater on wheel support frame. Hr Models Only) WARNING: Use only kerosene Make sure air inlet end (rear) of heater or No. 1 fuel oil to avoid risk of fire is over wheels. Line up holes on fuel These models are furnished with wheels and or explosion. Never use gaso- tank flange with holes on wheel sup- a front handle. Wheels, handle, and the line, naphtha, p
Summary of the content on the page No. 5
OWNER’S MANUAL Extension Cord Wire Size THEORY OF OPERATION Requirements OPERATION • 6 to 10 feet long, use 18 AWG rated IMPORTANT: Review and under- cord stand the warnings in the Safety The Fuel System: The air pump forces • 11 to 100 feet long, use 16 AWG Information section. They are air through the air line. The air is then rated cord pushed through the burner head nozzle. This needed to safely operate this • 101 to 200 feet long, use 14 AWG heater. Follow all local codes air causes fuel t
Summary of the content on the page No. 6
PORTABLE SPACE HEATER STORING, PREVENTATIVE WARNING: Never service heater TRANSPORTING, MAINTENANCE while it is plugged in, operating, or hot. Severe burns and electrical OR SHIPPING SCHEDULE shock can occur. Note: If shipping, transport companies re- quire fuel tanks to be empty. Item How Often How To 1. Drain fuel tank. Fuel tank Flush every 150-200 hours of opera- See Storing, Transporting, or Note: Some models have drain plug on tion or as needed. Shipping, column 1. underside of fuel tank.
Summary of the content on the page No. 7
OWNER’S MANUAL TROUBLESHOOTING WARNING: Never service heater while it is plugged in, operating, or hot. Severe burns and electrical shock can occur. OBSERVED FAULT POSSIBLE CAUSE REMEDY Heater ignites, but flame-out control shuts 1. Wrong pump pressure 1. See Pump Pressure Adjustment, page 9 off heater after a short period of time. 2. Dirty air output, air intake and lint filters 2. See Air Output, Air Intake and Lint Fil- ters, page 8 3. Dirty fuel filter 3. See Fuel Filter, page 9 4. Dirt in no
Summary of the content on the page No. 8
PORTABLE SPACE HEATER FAN AIR OUTPUT, AIR INTAKE, SERVICE AND LINT FILTERS IMPORTANT: Remove fan from motor PROCEDURES shaft before removing motor from heater. 1. Remove upper shell (see Upper Shell The weight of the motor resting on the fan Removal). WARNING: Never service could damage the fan pitch. 2. Remove filter end cover screws using heater while it is plugged in, op- 1. Remove upper shell (see Upper Shell 5/16" nut-driver. erating, or hot. Severe burns and Removal). 3. Remove filter end c
Summary of the content on the page No. 9
OWNER’S MANUAL FUEL FILTER SERVICE Fuel Filter, (35/55/110/150,000 BTU/Hr Bushing, and PROCEDURES Models) Lower Fuel Line Continued 1. Remove side cover screws using 5/16" Upper Fuel PUMP PRESSURE nut-driver. Line ADJUSTMENT 2. Remove side cover. 1. Remove pressure gauge plug from filter 3. Pull upper fuel line off fuel filter neck. end cover. 4. Carefully pry bushing, fuel filter, and 2. Install accessory pressure gauge (part lower fuel line (110/150,000 BTU/Hr number 00529-02). models only) out o
Summary of the content on the page No. 10
PORTABLE SPACE HEATER 8. Remove burner strap from spark plug. Spark Plug SERVICE 9. Clean and regap spark plug electrodes (110/150,000 BTU/Hr Models) PROCEDURES to .055" gap for 35,000 Btu/Hr model 1. Remove upper shell (see Upper Shell Continued and .075" gap for 55,000 Btu/Hr model. Removal, page 8). 10. Replace burner strap onto spark plug. 2. Remove fan (see Fan, page 8). SPARK PLUG Rotate burner strap to position spark 3. Remove spark plug wire from spark plug. (35/55,000 BTU/Hr Models) plu
Summary of the content on the page No. 11
OWNER’S MANUAL 9. Replace nozzle into nozzle adapter un- 6. Remove three screws using SERVICE til nozzle seats. Tighten 1/3 turn more 5/16" nut-driver and remove burner PROCEDURES using 5/8" socket wrench (40-45 inch- head from combustion chamber. pounds). Continued 7. Place burner head into vise and lightly 10. Attach nozzle assembly to burner strap. tighten. NOZZLE 11. Attach fuel and airline hoses to nozzle 8. Carefully remove nozzle from burn-er (35/55,000 BTU/Hr Models) assembly. head using
Summary of the content on the page No. 12
PORTABLE SPACE HEATER 5. Remove pump plate. 11. Replace fan guard and upper shell. SERVICE 6. Remove rotor, insert, and blades. 12. Adjust pump pressure (see page 10). PROCEDURES 7. Check for debris in pump. If debris is Note: If rotor is still binding, proceed Continued found, blow out with compressed air. as follows. PUMP ROTOR 8. Install insert and rotor. 13. Perform steps 1 through 6. (Procedure if rotor is binding) 9. Check gap on rotor. Adjust to 14. Place fine grade sandpaper (600 grit) .0
Summary of the content on the page No. 13
OWNER’S MANUAL SPECIFICATIONS Output Rating (BTU/Hr.) 35,000 55,000 110,000 150,000 Fuel Use Only Kerosene or No. 1 Fuel Oil Fuel Tank Capacity (U.S. Gal.) 3.0 5.0 9.0 13.5 Fuel Consumption (Gal. Per Hr.) .26 .40 .82 1.10 Electric Requirements 120 V/60 Hz (Same All Models) Amperage (Normal Run) 2.0 2.0 4.5 4.5 Hot Air Output (CFM) 165 175 490 500 WIRING DIAGRAMS Power Plug 120V/60Hz White Black Green White White B White Flame- Green Blue White Blue Spark Plug Terminal Out Reset Ignitor Motor Boa
Summary of the content on the page No. 14
PORTABLE SPACE HEATER ACCESSORIES Purchase accessories and parts from your nearest dealer. THERMOSTAT KIT - 00529-03 AIR GAUGE KIT - 00529-02 For all models. Keeps your building at the For all models. Special tool to check pump temperature you select day and night. Helps pressure. economize on fuel. STANDARD WHEELS AND HANDLE KIT - 00529-05 HEAVY DUTY WHEELS AND HANDLE KIT - 00529-04 Makes heater even more portable and con- venient. Easy to assemble. Fits 35/55,000 For heavy duty applications. M
Summary of the content on the page No. 15
OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________
Summary of the content on the page No. 16
CUSTOMER ASSISTANCE For the location of your nearest Homelite servicing dealer in the United States, Puerto Rico, and the Virgin Islands CALL: 1-800-242-4672 NOTE: Dealer information, technical advice, and product information can be obtained at this number. HEADQUARTERS HOMELITE P.O. BOX 7047 CHARLOTTE, N.C. 28241 OVERSEAS OFFICES CANADIAN OFFICES HOMELITE ENGLAND NETHERLANDS 1850 55th Avenue HOMELITE HOMELITE Lachine, Quebec, Canada UNIT 22 (HDQS. — Europe, Africa and Middle East) H8T 3J5 Hithe
