Summary of the content on the page No. 1
PROPANE
CONSTRUCTION HEATER
TM
OWNER’S MANUAL
Models: TC200V and RCP200V
IMPORTANT: Read and understand this manual before assembling, starting, or servicing
heater. Improper use of heater can cause serious injury. Keep this manual for future reference.
GENERAL HAZARD WARNING:
FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS
HEATER, CAN RESULT IN DEATH, SERIOUS BODILY INJURY AND PROPERTY LOSS OR
DAMAGE FROM HAZARDS OF FIRE, EXPLOSION, BURN, ASPHYXIATION, CARBON MON-
OX
Summary of the content on the page No. 2
TABLE OF CONTENTS SAFETY INFORMATION 2 TABLE OF CONTENTS SAFETY INFORMATION ............................................................ 2 STORAGE................................................................................... 5 PRODUCT IDENTIFICATION ..................................................... 3 MAINTENANCE .......................................................................... 5 UNPACKING ............................................................................... 3 REPLACEM
Summary of the content on the page No. 3
SAFETY INFORMATION 3 UNPACKING 3 THEORY OF OPERATION PRODUCT IDENTIFICATION PROPANE SUPPLY SAFETY INFORMATION PRODUCT IDENTIFICATION Top Continued • Keep propane tank(s) below 100° F. • Check heater for damage before each use. Do not use a dam- aged heater. • Use only the hose and factory preset regulator provided with the heater. Shell • Check hose before each use of heater. If highly worn or cut, replace with hose specified by manufacturer before using heater. Ignitor • Do not alter heater. Ke
Summary of the content on the page No. 4
VENTILATION INSTALLATION 4 OPERATION VENTILATION Fuel Gas WARNING: Provide at least a 6 square foot open- Fitting ing of fresh, outside air while running heater. If proper Hose fresh, outside air ventilation is not provided, carbon monoxide poisoning can occur. Provide proper fresh, Regulator outside air ventilation before running heater. Supply Valve Vent FRESH OUTSIDE AIR OPENING REQUIREMENTS (pointing down) HEATER SIZE SQ. FT. OPENING Propane Tank 200,000 Btu/Hr 6.0 Figure 2 - Regulator With
Summary of the content on the page No. 5
OPERATION 5 STORAGE 5 MAINTENANCE REPLACEMENT PARTS OPERATION MAINTENANCE Continued WARNING: Never attempt to service heater while 6. After ignition, hold control knob down for about 30 seconds. it is connected to propane supply, operating, or hot. This activates the automatic control system. Severe burns can occur. 7. When burner remains lit, set heater at the desired heat level by turning the control valve counterclockwise. If burner goes out, 1. Keep heater clean. turn off gas. Turn control
Summary of the content on the page No. 6
SPECIFICATIONS TROUBLESHOOTING 6 ACCESSORIES SPECIFICATIONS ACCESSORIES Rating (BTU/Hr) High - 200,000 Purchase these accessories and parts from your local dealer or Low - 100,000 service center. If your dealer or service center can not supply an accessory or part, contact your nearest Parts Central (listed in the Fuel Propane Vapor Only separate Authorized Service Center booklet) or call DESA Interna- Fuel Consumption Gallons/Hour - 1.09min./2.19 max. tional at 1-866-672-6040 for referral infor
Summary of the content on the page No. 7
ILLUSTRATED PARTS BREAKDOWN AND PARTS LIST 7 7 ILLUSTRATED PARTS BREAKDOWN AND PARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 5 of this manual. KEY PART NO. NO. DESCRIPTION QTY. 1 1 103925-01 Top and Shell Assembly 1 2 103923-01 Burner Ring Assembly 1 3 101263-01 Burner Plate 1 4 097162-02 Burner Nozzle 1 5 103031-02 Base 1 6 103924-01 Knob Assembly 1 7 102445-01 Piezo Ignitor 1 8 099236-01
Summary of the content on the page No. 8
8 WARRANTY AND REPAIR SERVICE KEEP THIS WARRANTY LIMITED WARRANTY DESA International warrants this product and any parts thereof, to be free from defects in materials and workmanship for one (1) year from the date of first purchase when operated and maintained in accordance with instructions. This warranty is extended only to the original retail purchaser, when proof of purchase is provided. This warranty covers only the cost of parts and labor required to restore the product to proper operating
