Chromalox PG433-1 user manual

Summary of the content on the page No. 1

®
Chromalox
DIVISION 4 SECTION VTS
SALES
(Supersedes PG433)
REFERENCE (Supersedes ) PG433-1
161-304901-001
DATE
MAY, 2003
Type STAR Radiant Heater
For Portable Installations
Specifications – Table 1
Amperage Dimensions (In.)Cord Ga./No. cond.
Model Figure Volts KW BTU
1 Phase 3 Phase A Height B Width D Depth 1 Phase 3 Phase
STAR-02A-11-PC 120 1.5 12.5 NA 5118 Comes w/cord & plug
STAR-02A-81-P 208 2 9.6 NA 6824 14/3NA
STAR-02A-21-P 12402 8.3NA 6824 28-1/2 11-3/8 11-3/4 14/3NA
STAR-02A-71-P 277 2

Summary of the content on the page No. 2

GENERAL 23-5/8" 11-1/2" 11-1/2" 23-5/8" 55-5/8" 32-1/2" Side View Front View Side View Front View Figure 3Figure 4 IMPORTANT: SAVE THESE INSTRUCTIONS To avoid personal injury read “IMPORTANT INSTRUCTIONS” on this page before installation or operation of heater. FIRE HAZARD. Do not use as a residential or household heater. Keep combustible material away from heater. Do not operate heater where flamma- ble vapors, gases or liquids are present. IMPORTANT INSTRUCTIONS When using electrical applianc

Summary of the content on the page No. 3

WIRING 2. The heater connection points are located in the gasketed termi- nal enclosure. To remove cover, remove screw(s) on the cover. Remove the cover to expose wiring connection points. ELECRIC SHOCK HAZARD. Disconnect all power 3. A green ground terminal is provided in the bottom of the enclo- before installing or servicing heater. Failure to do sure. The ground wire should be connected before other con- so could result in personal injury or property dam- nections are made. age. Heater must

Summary of the content on the page No. 4

OPTIONAL ACCESSORIES Chart A - Kit Selection Disconnect Tipover Tipover Single Phase Three Phase Model Kit Kit w/Ground Fault Cord Set Cord Set Comes w/cord & plug STAR-02A-11-PC NA NA NA STAR-02A-81-P NA NA NA PCN 295670 NA STAR-02A-21-P NA NA NA PCN 295670 NA STAR-02A-71-P NA NA NA PCN 295670 NA STAR-02A-41-P NA NA NA PCN 295670 NA STAR-02A-61-P NA NA NA PCN 295670 NA STAR-05A-81-P NA NA NA PCN 295662 NA STAR-05A-21-P NA NA NA PCN 295662 NA STAR-05A-71-P NA NA NA PCN 295670 NA STAR-05A-41-P NA

Summary of the content on the page No. 5

MAINTENANCE 6. Remove wires and jumper straps as required to replace the failed heating element(s). 7. Remove bulkhead fitting nuts and washers. ELECRIC SHOCK HAZARD. Disconnect all power 8. Remove failed element and replace with a new element. before servicing or replacing heating elements. Replace only with genuine Chromalox "Arctic End" ele- ments. Use of other elements will cause excess temperatures The reflectors should be kept clean to obtain the maximum inside terminal box. radiant output

Summary of the content on the page No. 6

Limited Warranty: Please refer to the Chromalox limited warranty applicable to this product at http://www.chromalox.com/customer-service/policies/termsofsale.aspx. 2150 N. RULON WHITE BLVD., OGDEN, UT 84404 Phone: 1-800-368-2493 www.chromalox.com