Summary of the content on the page No. 1
BM46I
MCO080103 (910)
U
S
OWNER / OPERATOR
MANUAL
BACKPACK SPRAYER
BM46I
WARNING
This sprayer is not designed to be
used with acids of any kind,
corrosive products like caustic
soda, gasoline, materials capable
of generating heat, hot fluids,
explosive or highly volatile
products.
USE OF THESE AND OTHERS
EXPOSE USERS TO SERIOUS
INJURY AND EVEN DEATH.
WARNING
Before using our products,
please read this manual carefully
to understand the proper use of
your unit.
US-1
Summary of the content on the page No. 2
BM46I SAFETY FIRST Instructions contained in warnings within this manual and warning seals marked with a symbol on the sprayer concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail. Note that there may be times when warning seals peel off or become soiled and impossible to read. If this happens, you should contact the dealer from which you
Summary of the content on the page No. 3
BM46I 1. Parts location 4. For safe operation 2 WARNING 6 7 1. Read this Sprayer Owner/Operator Manual carefully. Be sure you 3 U understand how to operate this unit S properly before you use it. Failure to 4 do so could result in serious injury. 2. Be sure to keep this manual handy 1 so that you may refer to it later 5 whenever any questions arise. Also note that you are requested to 1. Tank contact the dealer from whom you 2. Pump purchased the product for assistance 3. Lid (cap) the event tha
Summary of the content on the page No. 4
BM46I 4. For safe operation ■ WORKING CONDITION 1. Always inspect your sprayer thoroughly 1. Refrain from operating the sprayer if you before and after each use. Check to be are tired, ill, or upset, or if you are under sure hose is securely attached and in good the influence of alcohol, drugs or condition before pressurizing the tank. medication. 2. Check the work area that the sprayer will 2. To reduce the risk of injury when filling, be used in and remove or cover all using and/or cleaning th
Summary of the content on the page No. 5
BM46I 4. For safe operation • Keep spray materials locked up and out 5. When replacing the any other part, or any of reach of children and animals. lubricant, always be sure to use only • Use only original manufacturer’s RedMax products or products which have replacement parts. been certified by RedMax for use with the • As a rule, mix your chemicals in a RedMax product. U separate container from which to fill the 6. In the event that any part must be replaced S sprayer. Do not mix formulas insi
Summary of the content on the page No. 6
BM46I 5. Set up ASSEMBLY OF PUMP HANDLE PUMP NOTE LEVER & PUMP MODULE Pull sprayer, pump lever, pump handle, Hose clamps are not completely tight. Fig.2 spray wand, plastic bag (with washers Please tighten hose clamps prior to using. and pins), etc. out of box. Place parts in Hose clamps are left loose to extend life front of you. Take the pump lever, there of gaskets and fittings. are bends on either side. (See figure 2). Place one Washers through the bar, then WARNING push lever through openi
Summary of the content on the page No. 7
BM46I 6. Pre-operation 7. Operation • Always release pressure in the pump prior to filling, cleaning, or NOTE servicing the sprayer. • Before opening a container of pesticide or other spray material, Hose clamps are not completely tight. carefully read, understand, and follow all instructions on the Please tighten hose clamps prior to using. label. Hose clamps are left loose to extend life of gaskets and fittings. U • Do not use flammable materials in the sprayer: they can ignite S and/or explod
Summary of the content on the page No. 8
BM46I 8. Maintenance 9. Storage WARNING WARNING Before you remove cap, be sure there is no pressure in the Never store chemicals in your sprayer for any length of time tank. in order to release pressure, invert unit upside down and squeeze spray pistol (aim away from you). Pressure will 1. Before you remove cap, be sure there is no pressure in the escape; when hissing stops, all pressure has been released. tank. in order to release pressure, invert unit upside down and Remove pump assembly by tu
Summary of the content on the page No. 9
BM46I LIMITED WARRANTY U S FOR TWO (2) YEARS OF HOME USE, ONE (1) YEAR FOR COMMERCIAL USE AND NINETY (90) DAYS FOR RENTAL USE FROM THE DATE OF ORIGINAL PURCHASE,THE COMPANY, THROUGH ANY RedMax DEALER, WILL REPAIR OR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL PURCHASER, ANY PART OF PARTS FOUND TO BE DEFECTIVE IN MATERIAL AND/OR WORKMANSHIP. THIS IS THE EXCLUSIVE REMEDY. THE PURCHASER SHALL BEAR COSTS OF TRANSPORTING THE UNIT TO AND FROM THE RedMax DEALER. THE PURCHASER SHALL NOT BE CHARGED FOR DIA
