Summary of the content on the page No. 1
Phoenix R175 LGR Dehumidifier
TS-348
PO Box 8680 • Madison, WI 53708
Owner’s Manual — Phoenix R175 LGR Dehumidifier
Installation, Operation & Service Instructions
Read and Save These Instructions
The Phoenix R75 is the first roto-mold LGR (low grain refrigerant) dehumidifier manufactured
by Therma-Stor, LLC. The R75 combines Phoenix innovation, technical expertise and
proven durability. This unit will remove more water, produce more grain depression and dry
structures and contents faster
Summary of the content on the page No. 2
Table of Contents 1 Safety Certifications Introduction ............................................................... The Phoenix R75 conforms to standards ANSI/UL 474 1. Safety Certifications ..............................................2 and CSA C22.2 No.92. 2. Specifications .......................................................2 3. Operation ............................................................2 2 Specifications 3. Transporting .........................................
Summary of the content on the page No. 3
3.2 Electrical Requirements 3.6 POWER Button The Phoenix R75 plugs into a common grounded outlet Press the POWER button to turn the dehumidifier on or off. on a 5 amp circuit. It dra ws 6. amps at 80°F , 60% RH. When starting the dehumidifier the display will show the If used in a wet area, a ground fault interrupter (GFI) is accumulated hours. Press the POWER button again to turn required. If an extension cord is required, it must have a the dehumidifier off. The display will also power
Summary of the content on the page No. 4
cause the refrigerant pressure and temperature to drop. It next enters the evaporator coil where it absorbs heat from the incoming air and evaporates. IMPORTANT: DO NOT operate the unit without the filter The evaporator operates in a flooded condition, which or with a less effective filter as the heat exchanger and means that all the evaporator tubes contain liquid coils inside the unit could become clogged and require refrigerant during normal operation. A flooded evaporator disassembly
Summary of the content on the page No. 5
No dehumidification, air mover runs but compressor does Compressor runs with POWER button OFF. not. . Defective rela y . Bad connection in compressor circuit 2. Defective control board 2. Safety float switch closed, check pump reservoir 3. Upper housing not sealed to tower 3. Defective compressor capacitor No hour meter display when the HOURS button is pressed. 4. Defective compressor overload . Unit is plugged in 5. Defective compressor 2. Battery charge is low. Replace battery 6. Def
Summary of the content on the page No. 6
5.5 Condensate Pump 6 Options & Accessories The internal condensate pump removes water that collects 4025568 Air Filter, Pleated 2” x 2” x ” MERV- in the reservoir. 4024750 Intake Flex Duct 2” x 25” To replace the condensate pump: Metallize Polyester . Unplug the unit 4024935 Lay-Flat Duct 0” Round x 250’ Roll 2. Remove the front housing 3. Unplug the pump wires from the wire harness To order, contact Therma-Stor LLC at -800-533-7533. 4. Remove the condensate hose and the o
Summary of the content on the page No. 7
8 Service Parts Items listed are not shown Item Description Qty Part No. Description Qty Part No. Top Cover 402636 Compressor 4023648 2 Top Cover Latch 4026322 Evaporator Coil 4026343 3 Latch Backstop 4026323 Condenser Coil 4026345 4 Hex Bolts, /4”–20 x 4” 4 5409 Accumulator 4026357 5 Hex Bolts, /4”–20 x .75” 2 540 4 Condensate Pump 4026333 6 Handle Assembly 402634 Float Safety Switch 4026339 7 Wheel, 2” 2 4026304 Impeller,
Summary of the content on the page No. 8
This page intentionally left blank. Toll-Free 1-800-533-7533 8 www.thermastor.com • sales@thermastor.com
Summary of the content on the page No. 9
Phoenix R175 Dehumidifier Limited Warranty Warrantor: Therma-Stor LLC PO Box 8680 Madison, WI 53708 Telephone: -800-533-7533 Who Is Covered: This warranty extends only to the original end-user of the Phoenix R75 dehumidifier, and may not be assigned or transferred. Year One: Therma-Stor LLC warrants that, for one () year the Phoenix R 75 dehumidifier will operate free from any defects in materials and workmanship, or Therma-Stor LLC will, at its option, repair or replace the defective
