Summary of the content on the page No. 1
Clothes Dryers
Owner’s Instructions
DV5008J
DV5006
DV5004J
DV5002
Summary of the content on the page No. 2
Table of Contents Safety Instructions 3,4 Installation Instructions Ducting Installation instructions 5 Duct length calculations 6 Exhaust directions 6 Special accessory 6 Special installation requirements 7 Electrical power supply 7 Operating Instructions, Tips Control panel(DV5008J) 8 Control panel(DV5006) 9 Control panel(DV5004J) 10 Control panel(DV5002) 11 Loading clothes 12 Polyester Knits & Permanent Press Drying Tips 12 Program selecting guide 13 Program chart 14 Drying times 14 Care and
Summary of the content on the page No. 3
Safety Instructions Read all instructions before using this appliance Warning - It is extremely important that you read and adhere to the following instructions. Failure to do so could result in bodily injuries and/or property damage due to fire. Use this appliance only for its intended purpose as described in this Owner’s Manual. This dryer must be: - Properly installed and located in accordance with the Installation Instructions before it is used. - Properly grounded to conform with Local C
Summary of the content on the page No. 4
Safety Instructions Clean the lint filter before each load to prevent lint accumulation inside the dryer or in the room. DO NOT OPERATE THE DRYER WITHOUT LINTFILTER IN PLACE. Keep the area around the exhaust opening, and around and underneath your appliances free from the accumulation of combustible materials, such as lint, paper, rags, chemicals, etc. Regularly inspect the vent duct to ensure it has not been crushed or otherwise restricted. The interior of the dryer cabinet and the ex
Summary of the content on the page No. 5
Installation Instructions DUCTING INSTALLATION INSTRUCTIONS Installation and service must be performed by a qualified installer or service agency. IMPORTANT: Have your dryer installed properly. NOTE: The WARNING and IMPORTANT instructions appearing in this manual are not meant to cover all possible conditions and situations that may occur. It must be understood that common sense, caution, and carefulness are factors that CAN- NOT be built into the dryer. These factors MUST BE supplied by the per
Summary of the content on the page No. 6
Installation Instructions DUCT LENGTH CALCULATION Table 1: RECOMMENDED MAXIMUM LENGTH ELECTRIC DRYERS Weather Hood Type Recommended Use only for short run installations ↔4”(10.16cm) ↔2 1/2”(6.35cm) No. of 90° Rigid Metallic Flexible* Rigid Metallic Flexible* elbows 0 14m(46ft.) 9m(30ft.) 11m(37ft.) 7m(24ft.) 1 11m(38ft.) 7.5m(25ft.) 9m(30ft.) 6m(20ft.) 2 9m(31ft.) 6m(20ft.) 6.5m(22ft.) 4m(14ft.) 3 7m(24ft.) 5m(16ft.) 4.5m(15ft.) 3m(10ft.) * Do not use non metallic flexible duct. SPECIAL ACCESSOR
Summary of the content on the page No. 7
Installation Instructions SPECIAL INSTALLATION REQUIREMENTS ALCOVE OR CLOSET INSTALLATION WARNING: To reduce the risk of fire, this dryer MUST BE VENTED TO THE OUTDOORS. See the VENTING INFORMATION section. The minimum clearances between dryer cabinet and adjacent walls or other surfaces are : 0” either side 1” front and rear The minimum vertical space from floor to overhead cabinets, ceilings, etc. is 52”(132cm). The closet door must be louvered or otherwise ventilated and must conta
Summary of the content on the page No. 8
Operating Instructions, Tips Control panel (DV5008J) 1. The SIGNALbutton Set to OFF at the factory. When switched on, a buzzer sounds when the current program has finished. Push the SIGNALbutton once to turn on and again to turn off. The indicator labelled with a bell symbol will light when this feature is switched on. 2. The TEMPERATURE button Set to OFF at the factory. Used to switch the drying temperature from high to low. Push the button once to set to low and again to set back to high. The
Summary of the content on the page No. 9
Operating Instructions, Tips Control panel (DV5006) 1. The TIME button When pressed, indicators light up to indicate the running time. Initially the 50 indicator is lit up, then with each press time reduces by 10 mins and the indicators light (eg: 50 minutes 40 minutes 30 minutes 20 minutes 50 minutes.) 2. The TEMPERATURE button Set to OFF at the factory. Used to switch the drying temperature from high to low. Push the button once to set to low and again to set back to high. The LOW lamp wil
Summary of the content on the page No. 10
Operating Instructions, Tips Control panel (DV5004J) 1.The DELAY START button (and on/off indicator) This allows you to delay the start of the selected dryer program in increments of 1 hour for each press. (1 hour 2 hours 3 hours ... 24 hours Cancel.) 2.The TIME button When pressed, the timer displays 50 minutes. By pressing the button, you can reduce the setting to a minimum of 20 minutes when the time jumps to 100(1:40) mins and steps down to 50 mins. 3.The TEMPERATURE button Set to OFF a
Summary of the content on the page No. 11
Operating Instructions, Tips Control panel (DV5002) 1.The SIGNALbutton Set to OFF at the factory. When switched on, a buzzer sounds when the current program has finished. Push the SIGNAL button once to turn on and again to turn off. The indicator labelled with a bell symbol will light when this feature is switched on. 2.The TEMPERATURE button Set to OFF at the factory. Used to switch the drying temperature from high to low. Push the button once to set to low and again to set back to high. The LO
Summary of the content on the page No. 12
Operating Instructions, Tips LOADING CLOTHES • Preparing Laundry Check that all fastenings are closed and that pockets are empty. Place laundry loosely in the drum to make sure that they don’t get tangled. • Sort laundry as follows (Examples) As a general rule, sort clothes by surface texture, fabric, color and weight, as you would for your washer. By care symbols Suitable for tumble drying Tumble drying at low temperature only Do not tumble dry By amount and weight Lightweight fabrics dry f
Summary of the content on the page No. 13
Operating Instructions, Tips Programs Max. Laundry Type Example for Load Cotton Extra 5kg Heavy weight or mult-layered Track suits, Towelling fabrics materials, bath robes Very Fabrics of medium weight, Jeans, Towel laundry, articles not made up hand towels of mult-layers Cupboard Normal cotton and linen Sheets, and pillowcase, articles tablecloths, cotton trousers Light lightweight materials Cotton shirt and underwear Iron Cotton and linen articles to be Tablecloths and shirts
Summary of the content on the page No. 14
Operating Instructions, Tips PROGRAM CHART Programs Max. Low Temp Delay Heating Control Estimated Remark Load Select Start (Heater Turn Off) Time(3.6kg) Cotton Extra 5kg High/Low o 50 ± 5˚C 1 : 50 Very o 48 ± 5˚C 1 : 45 DV5008J Cupboard o 47 ± 5˚C 1 : 40 Light o 45 ± 5˚C 1 : 35 DV5008J Iron o 43 ± 5˚C 1 : 10 Rotary Iron o 39 ± 5˚C 1 : 00 Synthetic Extra 2.5kg Low o 47 ± 5˚C 1 : 20 Very o 46 ± 5˚C 1 : 15 DV5008J Cupboard o 41 ± 5˚C 1 : 10 Light o 40 ± 5˚C 1 : 05 DV5008J Iron o 49 ± 5˚C 1 : 00 Rot
Summary of the content on the page No. 15
Care and Cleaning Cleaning the filter Clean the filter before every use Slide the grid out as shown Clean the lint filter. Put your moistened fingers at one corner of the filter and wipe in a sideways motion all the way across to the other corner. PULL CLEAN LINT FILTER AFTER EACH CYCLE Do not operate the dryer without the grid in place. Do not operate the dryer without the filter in place. Periodically, remove the lint filter (it snaps in and out) and insert the suction hose adapter from yo
Summary of the content on the page No. 16
Care and Cleaning DRYER Vent MAXIMIZE YOUR DRYER EFFICIENCY BY KEEPING THE DUCTING CLEAN. EXHAUST HOOD CONNECTED 1. Disconnect or Turn off the electrical power. TO DRYER 2. Disconnect the ducting from the dryer. 3. Clean the ducting from the end where the dryer is connected using: Check turns in the exhaust the hose attachment of your vacuum cleaner duct for any collected lint. a duster attached to a pole (for straight stretches) or to a drain cleaning wire (for less acc
Summary of the content on the page No. 17
PROBLEM SOLVER PROBLEM POSSIBLE CAUSE Dryer unplugged. Make sure power cord is plugged in. DRYER WON’T No power to dryer. Check fuses and circuit breakers to make sure dryer is getting current. ST AR T Most electric dryers have two fuses so make sure you check both. Controls improperly set. Make sure the controls are set correctly and that the Start button is pressed. Opening the door during operation stops the drye
Summary of the content on the page No. 18
IN CASE THE NEED FOR SERVICING ARISES -Don't hesitate to call any AS center nearby with your name, address and telephone number when anything wrong with your product occurs. DC68-00711A-03
